1997 CHEVROLET MALIBU engine coolant

Downloaded from www.Manualslib.com manuals search engine Surge Tank Pressure Cap
NOTICE:
Your pressure cap is an 15 psi (105 kPa)
pressure-type cap and must be tightly installed to
prevent coolant
loss and possible engine damage
from overheating.
When you replace your surge tank pressure cap, a GM
cap is recommended.
Thermostat Power Steering Fluid
Engine coolant temperature
is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow of coolant through the radiator until the coolant
reaches a preset temperature.
When
you replace your thermostat, an AC@ thermostat
is recommended.
When to Check Power Steering Fluid
It is not necessary to regularly check power steering
fluid unless you suspect there is a leak in the system or
you hear an unusual noise.
A fluid loss in this system
could indicate a problem. Have the system inspected
and repaired.
6-22

Downloaded from www.Manualslib.com manuals search engine I Short Trip/City Maintenance Schedule I
100,000 Miles (166 000 km) (Continued)
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
lfyou do not use your vehicle under any of
these conditions, the fluid and filter do not
require changing.
DATE h I’UAL MILEAGE SERVICED BY:
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling system and pressure cap.
An Emission Control Service.
DATE ACTUAL MILEAGE SERVICED BY:

Downloaded from www.Manualslib.com manuals search engine 1 Lone TridHighway Maintenance Schedule
I 100,000 Miles (1 66 000 km) (Continued)
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
lfyou do not use your vehicle under any of
these conditions, the fluid and filter do not
require changing.
150,000 Miles (240 000 km)
~ 0 Drain, flush and refill cooling system
~ (or every 60 months since last service,
~ whichever occurs first). See “Engine
Coolant’’ in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test
the cooling system and pressure cap.
An Emission Control Service.
DATE SERVICED BY: ACTUAL MILEAGE DATE
SERVICED BY: ACTUAL MILEAGE

Downloaded from www.Manualslib.com manuals search engine Part B: Owner Checks and Services
Listed below are owner checks and services which
should be performed at the intervals specified to help
ensure the safety, dependability and emission control
performance of your vehicle.
Be sure any necessary repairs
are completed at once.
Whenever any fluids or lubricants
are added to your
vehicle, make sure they
are the proper ones, as shown in
Part D.
At Each Fuel Fill
It is important for you or a service station attendant to
pe@orm these underhood checks
at each fuel fill.
Engine Oil Level Check
Check the engine oil level and add the proper oil
if necessary. See “Engine Oil” in the Index for
further details.
Engine Coolant Level Check
Check the engine coolant level and add the proper
coolant mix if necessary. See “Engine Coolant” in the
Index for further details.
Windshield Washer Fluid Level Check
Check the windshield washer fluid level in the
windshield washer tank and add the proper fluid if
necessary. See “Windshield Washer Fluid” in the Index
for further details.
At Least Once a Month
Tire Inflation Check
Make sure tires are inflated to the correct pressures.
See “Tires”
in the Index for further details.
Cassette Deck Service
Clean cassette deck. Cleaning should be done every
50 hours of tape play. See “Audio Systems” in the
Index for further details.
7-37

Downloaded from www.Manualslib.com manuals search engine Part D: Recommended Fluids and
Lubricants
NOTE: Fluids and lubricants identified below by name,
part number or specification may be obtained from your
GM dealer.
I USAGE
I Engine Oil
I Engine Coolant
Hydraulic Brake System
FLUIDLUBRICANT
Engine oil with the American
Petroleum Institute Certified For
Gasoline Engines “Starburst”
symbol of the proper viscosity.
To
determine the preferred viscosity
for your vehicle’s engine, see
“Engine Oil” in the Index.
50/50 mixture of clean water
(preferably distilled) and use only
GM Goodwrench@ DEX-COOL
TM
or Havoline@ DEX-COOL TM
coolant. See “Engine Coolant” in
the Index.
Delco Supreme
ll@ Brake Fluid
(GM Part
No. 12377967 or
equivalent DOT-3 brake fluid).
USAGE FLUIDLUBRICANT
Power Steering
GM Power Steering Fluid (GM
System Part No. 1052884
- 1 pint,
1050017
- 1 quart, or equivalent). ~ ~~~~~
Automatic DEXRON@-I11 Automatic
Transaxle Transmission Fluid.
1
Key Lock
Cylinders Multi-Pu ose lubricant,
Superlube
% (GM Part
No. 12346241 or equivalent).
Windshield GM Optikleen@ Washer Solvent (GM
Washer Solvent Part
No. 1051515) or equivalent.
Hood Latch Lubriplate lubricant aerosol (GM
Assembly, Part
No. 12346293 or equivalent)
Pivots, Spring or lubricant meeting requirements
Anchor and of NLGI
# 2, Category LB or
Release Pawl
GC-LB.
Hood and Door Multi-pu ose lubricant,
Hinges Superlube
% (GM Part No.
1234624 1 or equivalent).
Weatherstrip Dielectric Silicone Grease (GM
Conditioning Part
No. 12345579 or equivalent). I
I
See “Replacement Parts” in the Index for recommended
replacement filters and spark plugs.
7-42

Downloaded from www.Manualslib.com manuals search engine Climate Control System ........................... 3-2
Clock. Setting
the ................................ 3-7
Comfort Controls
................................ 3-2
Compact Disc Care
............................. 3-24
Compact Disc Player
............................ 3-14
Compact Spare Tire
............................. 5-32
Control of a Vehicle
.............................. 4-6
ConvenienceNet ............................... 2-44
Convex Outside Mirror
.......................... 2-41
Coolant
....................................... 6-18
Adding
..................................... 6-21
Checking
................................... 6-20
Heater. Engine
............................... 2- 17
Surge Tank Pressure Cap
....................... 6-22
Cooling System
................................ 5-14
Courtesy Transportation
........................... 8-8
Cruise Control
................................. 2-33
CruiseLight
................................... 2-62
Cupholder. Center Console
....................... 2-43
Cupholder. Instrument Panel
...................... 2-43
Cupholder. Rear Seat
............................ 2-43
Customer Assistance for Text Telephone Users
......... 8-4
Customer Assistance Information
................... 8- 1
Customer Satisfaction Procedure
.................... 8-2
SurgeTank
.................................. 5-14
Damage. Finish
............................... 6-51
Damage. Sheet Metal
............................ 6-50
Daytime Running Lamps
......................... 2-37
Dead Battery
................................... 5-3 Defects. Reporting Safety
........................ 8-10
Defensive Driving
............................... 4-2
Defogging
..................................... 3-4
Defrosting
..................................... 3-4
Dimen ions. Vehicle
............................ 6-62
Dolby B Noise Reduction 3-13
Dome Lamp
................................... 2-39
Dome Lamp Bulb Replacement
.................... 6-34
DoorLocks
..................................... 2-4
Drive. Automatic
............................... 2-20
Driver Position
................................. 1-12
Driving
City
........................................ 4-19
Defensive
.................................... 4-2
Drunken
..................................... 4-3
Freeway
.................................... 4-20
InaBlizzard
................................. 4-26
In Foreign Countries ........................... 6-5
In the Rain
.................................. 4-16
Night
...................................... 4-15
OnCurves
................................... 4-9
On Grades While Towing a Trailer
............... 4-37
On Hill and Mountain Roads
.................... 4-22
On Snow and Ice
............................. 4-25
Throughwater
............................... 4-18
WetRoads
.................................. 4-16
Winter
...................................... 4-24
With a Trailer
................................ 4-37
DrunkenDriving
................................ 4-3
Defogger. Rear Window
.......................... 3-5
8 .......................

Downloaded from www.Manualslib.com manuals search engine Electrical Equipment. Adding ..... 2.15.2.16.3.22. 6.64
Electrical System
............................... 6-54
Engine
.................................. 6.10. 6.11
Coolant
..................................... 6-18
Coolant Heater
............................... 2-17
Coolant Levelcheck
.......................... 7-37
Coolant Temperature Gage
..................... 2-56
Exhaust
...................... 2.10.2.26.4.27. 4.36
FuseBlock
.................................. 6-58
Identification
................................ 6-53
Oil Level Check
.............................. 7-37
Overheating
................................. 5-12
Running While Parked
......................... 2-26
Specifications
................................ 6-62
Starting Your
........................... 2- 14. 2. 16
EngineOil .................................... 6-12
Adding
..................................... 6-13
Additives
................................... 6-16
Checking ................................... 6-13
Pressure Warning Light
........................ 2-60
Used
....................................... 6-17
What Kind to Use
............................. 6- 15
Ethanol ........................................ 6-4
Exterior Lamps
................................. 2-36
Whentochange
.............................. 6-16
Fabric Cleaning ............................... 6-45
FillingYourTank
................................ 6-5
Filter. Air
..................................... 6-17
Finishcare
.................................... 6-49 Finish Damage
................................. 6-51
First Gear. Automatic Transaxle
................... 2-21
Flashers. Hazard Warning
......................... 5-2
Flash-to-Pass .................................. 2-30
Flat Tire. Changing
............................. 5-20
Fluids and Lubricants
............................ 7-42
FogLmps
.................................... 2-38
Following Distance with a Trailer
.................. 4-37
Foreign Countries. Fuel
........................... 6-5
FrenchLanguageManual
11
FrontTowing .................................. 5-10
Fuel .......................................... 6-3
Filling Your Tank
.............................. 6-5
Gage
....................................... 2-64
In Foreign Countries
........................... 6-5
Fuses and Circuit Breakers
....................... 6-55
.. ...........................
Gages Engine Coolant Temperature
.................... 2-56
Fuel
....................................... 2-64
Tachometer
.................................. 2-52
Garment
Hook ................................. 2-46
GAWR
....................................... 4-31
Gear Positions. Automatic Transaxle
................ 2-19
GloveBox
.................................... 2-42
Gross Axle Weight Rating
........................ 4-31
Gross Vehicle Weight Rating ...................... 4-31
Guide en Frangais
11
GVWR ....................................... 4-31
.. .................................
9-4

Downloaded from www.Manualslib.com manuals search engine Leaving Your Vehicle ............................. 2-6
Leaving Your Vehicle with the Engine Running
....... 2-24
Lighter
....................................... 2-44
Lights Air Bag Readiness
....................... 1.22. 2.54
Anti-Lock Brake System Warning
............ 2.56. 4.7
Brake System Warning
.................... 2.55. 6.25
Charging System Indicator
...................... 2-54
CheckEngine
................................ 2-57
CheckOil
.............................. 2.61. 6.12
Cruise
...................................... 2-62
DoorAjar
................................... 2-63
Interior
..................................... 2-38
Low Coolant Warning
.................... 2.57. 6.21
LowWash
.................................. 2-62
Oil Pressure Warning
.......................... 2-60
Passlock@ Warning
........................... 2-6 1
Safety Belt Reminder
...................... 1.8. 2.53
Service Vehicle
Soon .......................... 2-63
Loading Your Vehicle ........................... 4-30
Lock Out Switch
............................... 2-28
Locks
......................................... 2-4
Cylinders
................................... 7-38
Door
........................................ 2-4
Key Lock Cylinder Service
..................... 7-38
PowerDoor
.................................. 2-5
Rear Door Security
............................. 2-5
Low Coolant Warning Light
................. 2.57. 6.21
Lubricants and Fluids ............................ 7-42
Lubrication Service. Body
........................ 7-38 Maintenance.
~ormal Replacement parts ........... 6-62
Maintenance Record
............................ 7-43
Maintenanceschedule
............................ 7-1
Introduction
.................................. 7-2
Long Tripmighway Definition
................... 7-6
Long Tripmighway Intervals
..................... 7-6
Owner Checks and Services
..................... 7-37
Periodic Maintenance Inspections
................ 7-41
Recommended Fluids and Lubricants
............. 7-42
Scheduled Maintenance Services
.................. 7-4
Selecting the Right Schedule
..................... 7-4
Short TripKity Definition ....................... 7-5
Short TripKity Intervals ........................ 7-5
Maintenance. Underbody
......................... 6-51
Maintenance When Trailer Towing
................. 4-40
Making Turns with a Trailer
...................... 4-38
Malfunction Indicator Lamp
...................... 2-57
ManualFrontSeat
............................... 1-2
Manual Remote Control Mirror .................... 2-40
Methanol
...................................... 6-4
Mirror Reading Lamps ........................... 2-39
Mirrors
....................................... 2-40
Convex Outside
.............................. 2-41
Inside Daymight Rearview
..................... 2-40
Manual Remote Control
........................ 2-40
Outside
..................................... 2-40
Power Remote Control
......................... 2-41
Visorvanity
................................. 2-45
Mountain Roads
................................ 4-22
Multifunction Lever
............................. 2-29
9-6