1997 AUDI A4 display

01-24

VAG1551 scan tool
display Possible cause
Corrective action
00000
No DTC recognized If "no DTC recognized appears after performing repairs, OBD is ended.
00529 2122
Speed information
missing /SP1) - Open circuit in wiring between Engine Control Module
(ECM), instrument cluster and A/C control head -E87-
- ECM and instrument cluster supply an unusable engine
speed signal - Diagnose and repair open circuit in
wiring using wiring diagram
- Read measuring value block
page 01
-63

- Test engine speed signal
Repair Manual, Fuel Injection &
Ignition, Repair Group 24
00532 2234
Supply voltage

Signal too low /SP - Voltage drops in electrical system to levels of less than
9.5 V2)
- Contact resistance in cable connection to A/C
Refrigerant Low Pressure Switch -F73- - Test Generator (GEN) and Voltage
Regulator (VR)
Repair Manual, Engine
Mechanical, Repair Group 27
- Diagnose and repair contact
resistance using wiring diagram
1)This fault may be generated during Output Diagnostic Test Mode (DTM) (no engine speed signal recognized although A/C
compressor speed detected).
2) If voltage at -E87-connector -C3- drops below 9.5 V, compressor switches off for a minimum of 25 seconds. Compressor
switches on again when voltage exceeds 10.8 V.
Pa
ge 31 of 91 A/C s
ystem, On Board Dia
gnostic
(OBD
)
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.01.1

01-25

VAG1551 scan tool display
Possible cause
Corrective action
00600
Temperature Regulator Flap Motor
Position Sensor -G92- for
Temperature Regulator Flap Motor
V681)
Short circuit to ground /SP

Open circuit/short circuit to
positive /SP
Adaptation limit exceeded
Mechanical malfunction. - Short circuit, open circuit in wiring or
incorrect terminal assignment (wires
interchanged) of connectors between -G92-
and -E87-
- Temperature flap not operating freely
- -G92- in -V68- inoperative- Diagnose and repair short circuit,
open circuit in wiring or confirm
terminal assignment using wiring
diagram

- Check for free operation of
temperature flap
- Replace -V68-
00601
Central Flap Motor Position Sensor
G112 in Central Air Flap Motor V70
Short circuit to ground /SP

Open circuit/short circuit to
positive /SP
Adaptation limit exceeded2)
Mechanical malfunction - Short circuit, open circuit in wiring or
incorrect terminal assignment (wires
interchanged) of connectors between -
G112- and -E87-
- Central flap not operating freely
- -G112- in V70 inoperative- Diagnose and repair short circuit,
open circuit in wiring or confirm
terminal assignment using wiring
diagram

- Check for free operation of central
flap3)
- Replace -V70-
Pa
ge 32 of 91 A/C s
ystem, On Board Dia
gnostic
(OBD
)
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.01.1

1)If a fault exists at potentiometer -G92-, flap motor V68 can be set manually by operating "+" or "-" button for temperature
selection (display range between 0 C and 50 C). 2)This fault only recognized during the basic setting.
3)Both end stops must be reached.
Pa
ge 33 of 91 A/C s
ystem, On Board Dia
gnostic
(OBD
)
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.01.1

01-26

VAG1551 scan tool display
Possible cause
Corrective action
00602
Footwell/Defrost Flap Motor
Position Sensor G114 in
Footwell/Defroster Flap Motor V85
Short circuit to ground /SP

Open circuit/short circuit to
positive /SP

Adaptation limit exceeded1)

Inoperative - Short circuit, open circuit in wiring or
incorrect terminal assignment (wires
interchanged) of connectors between -G114-
and -E87-
- Footwell/defroster flap not operating freely
- -G114- in -V85- inoperative- Diagnose and repair short circuit,
open circuit in wiring or confirm
terminal assignment using wiring
diagram

- Check for free operation of
footwell/defroster flap2)
- Replace -V85-
00603
Footwell/Defroster Flap Motor V85

Blocks or de-energized /SP - Short circuit, open circuit in wiring or
incorrect terminal assignment (wires
interchanged) of connectors between V85
and -E87-
- Footwell/defroster flap flap not operating
freely
- -V85- inoperative- Diagnose and repair short circuit,
open circuit in wiring or confirm
terminal assignment using wiring
diagram

- Check for free operation of
footwell/defroster flap
- Check -V85- using function 03
(Output DTM) page 01
-42

1)This fault only recognized during basic setting.
2) Both end stops must be reached.
Pa
ge 34 of 91 A/C s
ystem, On Board Dia
gnostic
(OBD
)
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.01.1

01-27

VAG1551 scan tool
display Possible cause
Corrective action
00604
Back Pressure Flap
Motor Position Sensor
G113 in Air Flow Flap
Motor V71

Short circuit to
ground /SP

Open circuit/short
circuit to positive /SP

Adaptation limit
exceeded1)

Inoperative - Short circuit, open circuit in wiring or incorrect terminal
assignment (wires interchanged) of connectors between -
G113- and -E87-
- Air flow flap not operating freely
- -G113- in -V71- inoperative- Diagnose and repair short circuit,
open circuit in wiring or confirm
terminal assignment using wiring
diagram

- Check for free operation of air flow
flap2)
- Replace -V71-
00625
Road speed signal

Implausible signal /SP - Loose terminal in wiring/connections between
Speedometer Vehicle Speed Sensor (VSS) G22, the
instrument cluster or in another component also
connected to this signal (e.g. radio or control module for
cruise control) and -E87-
- Speedometer -G21- or instrument cluster supplying
unusable signal or a component disrupts signal - Diagnose and repair loose terminal
using wiring diagram.





Pa
ge 35 of 91 A/C s
ystem, On Board Dia
gnostic
(OBD
)
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.01.1

01-28

VAG1551 scan tool display
Possible cause
Corrective action
00779 3133
Outside Air Temperature Sensor G17

Short circuit to ground /SP

Open circuit/short circuit
to positive /SP - Short circuit or open
circuit
between -G17- and -
E87-
- -G17- malfunction- Diagnose and repair short circuit or open circuit in
wiring using wiring diagram
- -G17- electrical test page 01
-115
00785 3211
Instrument Panel Interior Temperature
Sensor G56

Short circuit to ground /SP

Open circuit/short circuit to
positive /SP - Short circuit or open
circuit
between -G56- and -
E87-
- -G56- malfunction- Diagnose and repair short circuit or open circuit using
wiring diagram
- -G56- electrical test page 01
-115
00787 3213
Fresh Air Intake Duct Temperature
Sensor G89

Short circuit to ground /SP
- Short circuit or open
circuit
between -G89- and -
E87-
- -G89- malfunction- Diagnose and repair short circuit or open circuit in
wiring using wiring diagram
- -G89- electrical test page 01
-115
Pa
ge 37 of 91 A/C s
ystem, On Board Dia
gnostic
(OBD
)
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.01.1

01-29

VAG1551 scan tool display
Possible cause
Corrective action
00797 3241
Sunlight Photo Sensor G107

Open circuit/short circuit to positive /SP

Short circuit to ground /SP - Short circuit or open
circuit
between -G107- and -
E87-
- Connections to -
G107-
interchanged
- -G107- malfunction- Diagnose and repair short circuit or open circuit in
wiring using wiring diagram
- Confirm connection using wiring diagram

- Test G107 using function 08
(Read measuring value block) page 01
-63
- Replace -G107-
00799 3243
A/C Engine Coolant Temperature (ECT)
Sensor G1101)

Open circuit/short circuit to positive /SP

Short circuit to ground /SP - Short circuit or open
circuit
between -G110-1) and
-E87-
- -G110-1) malfunction- Diagnose and repair short circuit or open circuit in
wiring using wiring diagram
- Test -G110-1) using function 08
(Read measuring value block)
page 01
-63

1) Not on USA/CDN models.
Pa
ge 39 of 91 A/C s
ystem, On Board Dia
gnostic
(OBD
)
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.01.1

01-30

VAG1551 Scan Tool display
Possible cause
Corrective action
00785 3211
Instrument panel
interior temperature
sensor
-G56
Short circuit or open circuit between
instrument panel interior temperature
sensor -G56- and A/C control head -E87- - Locate short circuit or open
circuit using wiring diagram and
repair
Short circuit to
Ground /SP
Open/Short
circuit to B+ /SP Instrument panel interior temperature
sensor -G56- malfunctioning - Check instrument panel interior
temperature sensor -G56-
electrical testing, page 01
-115

Note for DTC 00785:
For the A/C control head -E87-, the instrument panel interior temperature sensor -G56- is installed with only one display in the
A/C control head -E87-. instrument panel interior temperature sensor-G56- cannot be checked or replaced individually, if
malfunctioning replace A/C control head -E87- completely. VAG1551 Scan Tool display
Possible cause
Corrective action
00796 6) 3234
Interior temperature
sensor fan-V42
Open circuit in power supply to -V42- or in
wiring connection between -V42- and -E87- - Locate and repair open
circuit using wiring diagram
Blocked or no
voltage /SP Interior temperature sensor fan -V42-
malfunctioning - Replace A/C control head -
E87-
6) For an A/C control head -E87- with only one display, the interior temperature sensor fan -V42- is installed in the A/C control
head -E87-; if malfunctioning replace complete unit.
Pa
ge 40 of 91 A/C s
ystem, On Board Dia
gnostic
(OBD
)
11/21/2002 htt
p://127.0.0.1:8080/audi/servlet/Dis
play?action=Goto&t
yp
e=re
pair&id=AUDI.B5.HA01.01.1