1996 VOLVO 850 low beam

1996 Volvo 850

Installation of accessories

In order to help avoid interference and damage to your car's electrical \
system, your car is equipped with
an accessory connector located under the instrument panel on the driver'\
s side.

Please consult your Volvo retailer if you have any questions before conn\
ecting accessory or optional
equipment to the vehicle's electrical system.

Connector (for accessories)
Position Connection Max.
load
1 Battery + (30) 20 A
2 X Supply 0,5 A
3 High beam 1 A
4 Low beam 1 A
5 Pos Light 1 A
6 Rheostat 0,5 A
7 Front acc.
conn. 2 A
8 Earth (31) –
file:///K|/ownersdocs/1996/1996_850/96850_613.htm (4 of 8)12/30/2006 9\
:59:46 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850

Air pump system (B5254S)

When the engine is being started from cold, an electrical air pump which\
draws air to the exhaust system
is activated. This starts an afterburning process which leads to reduced\
hydrocarbon and carbon
monoxide (HC and CO) emissions and reduces the warm-up period for the \
catalytic converter.
The pump starts when the car has been started and is moving. It continue\
s to work until the catalytic
converter has reached normal working temperature, although it can also s\
tart when the engine is idling.
If the air pump is running and the engine is switched off, the pump cont\
inues working in order to protect
the pump motor.
Note! A soft whining noise can be heard from the pump, and when it perfo\
rms a self-diagnosis, the high/
low beam and the instrument lighting will flash briefly. This is complet\
ely normal. pg. 8:15 Windshield washer nozzles, Washer fluid reservoir

Adjusting washer nozzles

The washer jets should spray the windshield as shown above. Use the edge\
of a small screwdriver to
adjust the nozzles if necessary.
file:///K|/ownersdocs/1996/1996_850/96850_813.htm (3 of 7)12/30/2006 9\
:59:53 AMClassic Cars & Cycles www.ClassicCycles.org

1996 Volvo 850
pg. 9:6 Specifications (cont.)
Electrical system

12 Volt, negative ground.
Voltage-controlled generator. Single-wire system with chassis and engine\
used as conductors.

Battery
Voltage 12 V
Capacity 520 A/100 min
(certain markets) 420 A/75 min

The battery contains corrosive and poisonous acids. It is of the utmost \
importance that old batteries are
disposed of correctly. Your Volvo retailer can assist you in this matter\
.

Generator
Rated output 1400 W
Max. current 100 A

Bulbs
Bulb US No. Power Socket No/
bulbs
Headlights
High beam
Low beam
HB3/9005
HB4/9006

70W
60W
–
–
2
2
Front parking lights/turn signals 1157 N.
A. 21/5 W/24/2.2
cp
BAY 15 d
2
Turn signals, rear – 21W BAU 15 s 2
Tail lights (sedan) 67 5 W/4cp BA 15 s 4
Tail lights (wagon) – 21/4W BAZ 15 d 4
Brake lights 1156 21W/32cp BA 15 s 2
file:///K|/ownersdocs/1996/1996_850/96850_906.htm (1 of 9)12/30/2006 9\
:59:57 AMClassic Cars & Cycles www.ClassicCycles.org