1996 PONTIAC GRAND-AM radiator

Surge Tank Pressure Cap
NOTICE: ~~ ~
Your pressure cap is an 15 psi l(105 kPa)
pressure-type cap and must be tightly installed to
prevent coolant loss and possible engine damage
from overheating,
When you replace your surge tank pressure cap, a GM
cap is recommended.
Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system, The thermostat stops the
flow of coolant through the radiator until the coolant
reaches
a preset temperature.
When you replace your thermostat,
an AC@ thermostat
is recommended.
Power Steering Fluid
When to Check Power Steering Fluid
It is not necessary to regularly check power steering
fluid unless
you suspect there is a leak in the system or
you hear an unusual noise. A fluid loss in this system
could indicate a problem. Have the system inspected
and
repaired.
6-26
ProCarManuals.com

~~~
~~~~ NOTICE:
~ ~~~~ ~~~~~~~~~
When using concentrated washer fluid,
follow the manufacturer’s instructions for
adding water.
e Don’t mix water with ready-to-use washer’
fluid. Water can cause the solution to freeze
and damage your washer fluid tank and
other parts
of the washer system. Also,
water doesn’t clean
as well as washer fluid.
Fill your washer fluid tank only 3/4 full
when it’s very cold, This allows for
expansion, which could damage the tank
if
it is completely full.
windshield washer.
It can damage your
washer system and paint,
Don’t use radiator antifreeze in your
Brakes
Brake Fluid
Your brake master cylinder reservoir is here. It is filled
with
DOT-3 brake fluid.
There are only two reasons why the brake fluid level in
the reservoir might go down. The first is that the brake
fluid goes down to
an acceptable level during normal
brake lining wear. When new linings
are put in, the fluid
level goes
back up. The other reas’on is that fluid is
leaking out of the brake system, If it is, you should have
6-28
ProCarManuals.com

I Short Trip/City Maintenance Schedule I
99,000 Miles (145 000 km)
Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
DATE
SERVICED BY: ACTUAL MILEAGE .
I
100,000 Miles (146 000 km)
0 Drain, flush and refill cooling system (or
every 60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for
what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
An Emission Control
Service.
0 Inspect spark plug wires (except 2.4L
Code T engine). An Emission Control Service.
(Continued)
7-25
ProCarManuals.com

I Long Trip/Highway Maintenance Schedule
97,500 Miles (162 500 km)
Cbange engine oil and filter (or every
12 months, whichever occurs first).
An Emission Control Service.
and transaxle shift linkage (or every
12 months, whichever occurs first).
0 Lubricate the suspension, steering linkage
0 Rotate tires. See “Tire Inspection and
Rotation’’
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
DATE SERVICED BY ACTUAL MILEAGE
100,000 Miles (166 000 km)
0 Drain, flush and refill cooling system (or
every 6‘0 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test the cooling system and pressure cap.
An Emission
Control Service.
7
Inspect spark plug.wires (except 2.4L
Code T engine). An Emission Control Service.
(Continued)
7-35
ProCarManuals.com

Part C: -Periodic Maintenance
Inspections connections, or other conditions which could cause a heat
build-up in
the floor pan or could let exhaust fumes into
the vehcle. See “Engine Exhaust”
in the Index.
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
Radiator and Heater Hose Inspection
spxing and fall). You should let your GM dealer’+& ?::. Inspect the hoses and have them replaced if they are
service department or other qualified service center ,:5; 4
cracked, swollen or deteriorated. Inspect all pipes,
these jobs. Make sure any necessary repairs are fittings and clamps; replac\
e as needed.
completed at once.
Proper procedures to perform these services may be
found in a Pontiac service manual. See “Service and Inspect the throt\
tle linkage for interference or binding, and
. ..,..
Throttle Linkage Inspection
Owner Publications” in the Index.
Steering, Suspension and Front-Wheel-Drive
Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering system
for.damaged, loose or missing parts, signs of wear, or
.
lack of lubrication. Inspect the power steering lines and
hoses for proper hook-up, binding, leaks, cracks, chafing,
etc. Clean and then inspect the drive axle boot seals for
damage,
tears or leakage. Replace seals if necessary.
Exhaust System Inspection
Inspect the colillplee exhaust system. Inspect the body near
the exhaust system. Look for broken, damaged, missing or
out-o€-position
parts as well as open seams, holes, loose fordamage
or missing parts. Replace parts
as needed.
Replace any cables that have high effort or excessive wear.
Do not lubricate accelerator and cruise control cables.
Brake System Inspection
Inspect the complete system. Inspect brake lines and hoses for proper
hookup, binding, leaks, cracks, chafhg, etc.
Inspect disc brake pads for wear and rotors for surface
condition.
Also inspect drum brake linings for. wear and
cracks. Inspect other brake parts, including
drums, wheel
cylinders, capers, parking brake, etc. The parking brake
is
self-adjusting and no manual adjustment is required. You
may need to have your brakes inspected more often if your
driving habits or conditions result
in fi-equent braking.
7-41
ProCarManuals.com

Halogen Bulbs ................... .... 6-33
Hazard Warning Flashers
................... ... 5-1
Head Restraints ................................. 1-5
Headlamps ..................................... 2-39
Bulb Replacement
............................ 6-33
HighLow Beam Changer
...................... 2-32
Hearing Impaired, Customer Assistance .............. 8-4
High-Beam Headlamps
.......................... 2-32
Highway Hypnosis
.............................. 4-23
Hill
and Mountain Roads ......................... 4-23
Hitches, Trailer
................................. 4-37
Checking Things Under
......................... 6-6
Hydraulic Clutch
............................... 6-21
Hydraulic Clutch Fluid
........................... 6-22
Hydraulic Clutch System Check
................... 7-38
OnReminder
................................ 2-40
Wiring
...................................... 6-54
.Heating
.................. ; ..................... 3-5
Hood Prop
........................................ 6-7
Release
........................................ 6-6
Horn ......................................... 2-30
Hydroplaning .............................. : .... 4-19
Ignition Switch
................................ 2- 11
Illuminated Entry
............................... 2-42
Inside Daymight Rearview Mirror
................. 2-44
Exhaust Systems
............................. 7-41
Front-Wheel-Drive Axle Boot
.................. 7-41,
Inflation. Tire
.................................. 6-38
Inspections
BmkeSystem ................................ 7-41
Front-Wheel-Drive Axle
Seal .................... 7-41 Radiator and Heater Hose
...................... 7-41
Suspension
................................... 7-41
Steering .................................... 7-41
Throttle Linkage
............................... 7-41
Instrument Panel
............................... 2-50
Brightness Control ............................ 2-41
Fuse Block
.................................. 6-55
Interior Lamps ................................. 2-41
Cleaning
.................................... 6-48
Cluster
2-52 .....................................
Jack. Tire .................................... 5-23
Jump Starting
................................... 5-2
Key Lock Cylinders Service ..................... 7-38
Key Release Button
............................. 2-13
Keyless Entry System
............................ 2-6
Keys .......................................... 2-1
Labels Certification/”ire ............................. 4-32
Service
Parts Identification ..................... 6-53
Tire-Loading Information
...................... 4-32
Vehicle Identification Number
: .................. 6-53
Lamps ........................................ 2-39
Fog
........................................ 2-41
Interior
..................................... 2-41
On Reminder ................................ 2-40
Latches, Seatback
................................ 1-5
Leaving Your Vehicle ............................. 2-5
Leaving Your Vehicle with the Engine Running ....... 2-26
Lighter
....................................... 2-47
9-5
ProCarManuals.com