1996 PONTIAC FIREBIRD suspension

A CAUTION:
A vehicle can fall from a car carrier if it isn’t
adequately secured. This can cause
a collision,
serious personal injury and vehicle damage. The
vehicle should be tightly secured with chains or
steel cables before it
is transported.
Don’t use substitutes (ropes, leather straps,
canvas webbing, etc.) that can be cut by sharp
edgeswderneath the towed vehicle. Always use
T-hooks inserted in the T-hook slots. Never use
J-hooks. They will damage drivetrain and
suspension components.
When your vehicle is being towed, have the ignition
key turned #to the
OFF position. The steering wheel
should be clamped in a straight-ahead position, with
a clamping device designed for towing service. Do not
use the vehicle’s steering column lock
for this. The
transmission should be in
NEUTRAL (N) and the
parking brake released.
Don’t have your vehicle towed on the drive wheels
unless you must. If the
vehicle must be towed on the
drive wheels, be sure to follow the speed and distance
restrictions later in this section
or your transmission will
be damaged. If these limits must be exceeded, then the
drive wheels have to be supported on a dolly.
5-8
ProCarManuals.com

NOTICE:
Do not attach winch cables or J-hooks to
suspension components when using car carrier
equipment. Always use T-hooks inserted in the
T-hook slots.
Attach a separate safety chain around outboard end of
each lower control arm.
NOTICE:
Take care not to damage the brake pipes and
hoses
or the ABS sensor and wiring.
NOTICE: 1
Towing a vehicle over rough surfaces could
damage
a vehicle. Damage can occur from
vehicle-to-ground or
vehicle-to-wheel-lift-equipment contact.
To help
avoid damage, install
a towing dolly and raise
vehicle until adequate clearance
is obtained
between the ground and/or wheel-lift equipment.
5-10
ProCarManuals.com

Rear Towing
NOTICE:
Do not tow with sling-type equipment or rear
bumper valance will be damaged.
Use wheel lift or car carrier equipment.
Additional ramping may be required for car
carrier equipment.
Use safety chains and wheel straps.
Towing a vehicle over rough surfaces could
damage a vehicle. Damage can occur from vehicle
to ground
or vehicle to wheel lift equipment
contact. To help avoid damage, install a towing
dolly and raise vehicle until adequate clearance is
obtained between the ground and/or wheel-lift
equipment.
Do not attach winch cables or J-hooks to
suspension components when using car carrier
equipment. Always use T-hooks inserted in the
T-hook slots.
ProCarManuals.com

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a Pontiac Service Manual. See “Service and
Owner Publications’’ in the Index.
Steering and Suspension Inspection
inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect
the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body near
the exhaust system. Look for broken, damaged, missing or
0~t~€-pii60n parts as well as open seams, holes, loose
connections or other conditions which could cause a heat
build-up in
the floor pan or could let exhaust fumes into
the vehicle. See “Engine Exhaust” in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen
or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding, and
for damage or missing parts. Replace parts as needed.
Replace any cables that have high effort
or excessive wear.
Do not lubricate accelerator and cruise control cables.
Rear Axle Service
Check the gear lubricabt level in the rear axle and add if I
needed. See “Rear Axle” in the Index. A fluid loss may
indicate a problem. Check
the axle and repair it if needed.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition.
Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc. The
parking brake is self-adjusting and no manual
adjustment
is required. You may need to have your
‘brakes inspected more often
if your driving habits or
conditions result in frequent braking.
7-43
ProCarManuals.com

1996 PONTIAC SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out
the Service Publication Order Form in this book and mailing it in with your check, money order,
or credit card information to Helm, incorporated (address below.)
CURRENT PUBLICATIONS FOR 1996 PONTIAC
SERVICE MANUALS OWNER’S INFORMATION
Service
Manuals have the diagnosis and repair information Owner
publications are written directly for Owner’s and
on engines, transmission, axle, suspension, brakes, intended to provide basic operational information
about the
electrical, steering, body, etc. vehicle.
The owner’s manual will include the Maintenance
RETAIL SELL PRICE:
$90.00 Schedule for all models.
TRANSMISSION, TRANSAXLE, TRANSFER CASE
UNIT REPAIR MANUAL
This manual provides information on unit repair service In-Portfolio: Includes
a Portfolio, Owner’s Manual and
Warranty Booklet. RETAIL SELL PRICE: $1 5.00
procedures, adjustments and specifications’for the Without Portfolio: Owner’s Manual only.
1996
GM transmissions, transaxles and transfer cases. RETAIL SELL PRICE: $1 0.00
RETAIL SELL PRICE: $40.00
SERVICE BULLETINS Service Publications are available for current and past
Service Bulletins give technical Sewice information needed model GM vehicles.
TO request an order form, please
to knowledgeably service General Motors cars and trucks. specify year and model name of the vehicle.
Each bulletin contains instructions
to assist in the
diagnosis
and service of your vehicle.
CURRENT & PAST MODEL ORDER FORMS
ProCarManuals.com

Gages Engine Coolant Temperature
. . ....... ... 2-81
Engine Oil Pressure
......... ............... 2-85
Fuel
....................................... 2-87
GAWR
....................................... 4-30
Gear Positions. Automatic Transmission
............. 2-28
Gear Positions. Manual Transmission
.......... 2.32. 2.33
GloveBox
.................................... 2-56
Graphic Equalizer
......................... 3.10. 3.15
Gross Axle Weight Rating ........................ 4-30
Gross Vehicle Weight Rating
...................... 4-30
Guide en Franqais
11
GVWR ....................................... 4-30
.. .................................
Halogen Bulbs ................................ 6-37
Hatch Release
.................................. 2- 10
Hatch Release. Remote
.......................... 2- 10
Hazard Warning Flashers
.......................... 5-1
Head Restraints
................................. 1-5
Headlamp Bulb Replacement
...................... 6-38
Headlamp
Doors ............................... 2-51
Headlamps
.................................... 2-50
HighLow Beam Changer
...................... 2-44
OnReminder
................................ 2-50
Wiring
..................................... 6-63
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
........................................ 3-3
High-Beam Headlamps
.......................... 2-44
Highway Hypnosis
.............................. 4-23
Hill and Mountain Roads ......................... 4-23
Hitches, Trailer
................................. 4-35
Hood
Checking Things Under .......... ............ 6-6
Release ...................................... 6-7
Horn
......................................... 2-42
Hydraulic Clutch
............................... 6-25
Hydraulic Clutch System Check
................... 7-40
Hydroplaning
.................................. 4-19
Ignition Switch
................................ 2-21
Inflation. Tire
.................................. 6-46
Inside Daymight Rearview Mirror
................. 2-55
Inspections
.................................... 7-43
Brakesystem
................................ 7-43
Exhaust Systems
............................. 7-43
Radiator and Heater Hose
...................... 7-43
RearAxle
................................... 7-43
Steering
.................................... 7-43
Suspension .................................. 7-43
Throttle Linkage
........ : ..................... 7-43
Instrument Panel
............................... 2-72
Brightness Control
............................ 2-53
Cleaning
.................................... 6-56
Cluster
............ ......... 2-74
Interior Lamps
. . ....... 2-53
Jack. Tire
.................................. 5-28
Jump Starting
................................... 5-2
Key Lock Cylinders Service
...................... 7-40
Key Release Button
............................. 2-22
Keys
.......................................... 2-1
9-5
ProCarManuals.com