1996 PONTIAC FIREBIRD radiator

Windshield Washer Fluid
What to Use
When you need windshield washer fluid, be sure to read
the manufacturer’s instructions before use.
If you will be
operating your vehicle in an area where the temperature
may fall below freezing, use a fluid that has sufficient
protection against freezing.
Adding Washer Fluid
Open the cap labeled WASHER FLUID ONLY. Add
washer fluid until the tank is full.
NOTICE:
When using concentrated washer fluid,
follow the manufacturer’s instructions for
adding
water.
0 Don’t mix water with ready-to-use washer
fluid. Water can cause the solution to freeze
and damage your washer fluid tank and
other parts
of the washer system. Also,
water doesn’t clean as well as washer fluid.
three-quarters full when it’s very cold. This
allows for expansion, which could damage
the tank
if it is completely full.
windshield washer. It can damage your
washer system and paint.
Fill your washer fluid tank only
Don’t use radiator antifreeze m your
6-32
ProCarManuals.com

Replacement Parts Air Conditioning Refrigerants
Air Cleaner Filter Not all air conditioning refrigerants are the same.
VIN Engine Code P .................. A1163C refrigerant, be sure the proper refrigerant is used.
VIN Engine Code P (with WS6 Option) A1097C
Battery
............................... .75-60
Engine
Oil Filter
..... .;+ VIN Engine Code K .................. A1163C If the air conditioning system in your vehicle needs I . . '. .~ ,..I . ,. ,
If you're not sure, ask your Pontiac dealer. ...
. VIN Engine Code K ..................... PF47
VIN Engine Code
P .................... PF25
Fuel Filter
............................. GF578
PCV Valve
VIN Engine Code
K ................. CV892C
VIN Engine Code P ................. CV895C
Radiator Cap
........................... RC24
Spark Plug
VIN Engine Code K ....... -41-921 (0.060" Gap)
VIN Engine Code P ....... e41-943 (0.050" Gap)
Specification
................... 180°F (82°C)
Thermostat Temperature
I 6r't
ProCarManuals.com

1 Short TripKity Maintenance Schedule I
100,000 Miles (166 000 km)
Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
An Emission Control Service.
El Inspect spark plug wires.
An Emission Control Service.
Replace spark plugs.
An Emission Control Service. .
0 If you haven’t used your vehicle under
severe service conditions listed previously
and, therefore, haven’t changed your
automatic transmission fluid, change
both
the fluid and filter.
DATE ACTUAL MILEAGE SERVICED BY:
ProCarManuals.com

Long Trip/Highway Maintenance Schedule ~
100,000 Miles (166 000 km)
0 Drain, flush and refill cooling system
(or every 60 months since last service,
whichever occurs
first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test
the cooling system and pressure cap.
An Emission Control Sewice.
0 Inspect spark plug wires.
An Emission Control Service.
Replace spark .plugs.
0 If you haven’t used your vehicle under
severe service conditions listed previously
and, thereforle, haven’t changed your
automatic transmission fluid, change both
the fluid and filter.
An Emission Control Service.
I DATE ACTUAL MILEAGE SERVICED BY:
ProCarManuals.com

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a Pontiac Service Manual. See “Service and
Owner Publications’’ in the Index.
Steering and Suspension Inspection
inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect
the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body near
the exhaust system. Look for broken, damaged, missing or
0~t~€-pii60n parts as well as open seams, holes, loose
connections or other conditions which could cause a heat
build-up in
the floor pan or could let exhaust fumes into
the vehicle. See “Engine Exhaust” in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen
or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding, and
for damage or missing parts. Replace parts as needed.
Replace any cables that have high effort
or excessive wear.
Do not lubricate accelerator and cruise control cables.
Rear Axle Service
Check the gear lubricabt level in the rear axle and add if I
needed. See “Rear Axle” in the Index. A fluid loss may
indicate a problem. Check
the axle and repair it if needed.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition.
Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc. The
parking brake is self-adjusting and no manual
adjustment
is required. You may need to have your
‘brakes inspected more often
if your driving habits or
conditions result in frequent braking.
7-43
ProCarManuals.com

Gages Engine Coolant Temperature
. . ....... ... 2-81
Engine Oil Pressure
......... ............... 2-85
Fuel
....................................... 2-87
GAWR
....................................... 4-30
Gear Positions. Automatic Transmission
............. 2-28
Gear Positions. Manual Transmission
.......... 2.32. 2.33
GloveBox
.................................... 2-56
Graphic Equalizer
......................... 3.10. 3.15
Gross Axle Weight Rating ........................ 4-30
Gross Vehicle Weight Rating
...................... 4-30
Guide en Franqais
11
GVWR ....................................... 4-30
.. .................................
Halogen Bulbs ................................ 6-37
Hatch Release
.................................. 2- 10
Hatch Release. Remote
.......................... 2- 10
Hazard Warning Flashers
.......................... 5-1
Head Restraints
................................. 1-5
Headlamp Bulb Replacement
...................... 6-38
Headlamp
Doors ............................... 2-51
Headlamps
.................................... 2-50
HighLow Beam Changer
...................... 2-44
OnReminder
................................ 2-50
Wiring
..................................... 6-63
Hearing Impaired. Customer Assistance
.............. 8-4
Heating
........................................ 3-3
High-Beam Headlamps
.......................... 2-44
Highway Hypnosis
.............................. 4-23
Hill and Mountain Roads ......................... 4-23
Hitches, Trailer
................................. 4-35
Hood
Checking Things Under .......... ............ 6-6
Release ...................................... 6-7
Horn
......................................... 2-42
Hydraulic Clutch
............................... 6-25
Hydraulic Clutch System Check
................... 7-40
Hydroplaning
.................................. 4-19
Ignition Switch
................................ 2-21
Inflation. Tire
.................................. 6-46
Inside Daymight Rearview Mirror
................. 2-55
Inspections
.................................... 7-43
Brakesystem
................................ 7-43
Exhaust Systems
............................. 7-43
Radiator and Heater Hose
...................... 7-43
RearAxle
................................... 7-43
Steering
.................................... 7-43
Suspension .................................. 7-43
Throttle Linkage
........ : ..................... 7-43
Instrument Panel
............................... 2-72
Brightness Control
............................ 2-53
Cleaning
.................................... 6-56
Cluster
............ ......... 2-74
Interior Lamps
. . ....... 2-53
Jack. Tire
.................................. 5-28
Jump Starting
................................... 5-2
Key Lock Cylinders Service
...................... 7-40
Key Release Button
............................. 2-22
Keys
.......................................... 2-1
9-5
ProCarManuals.com

Methanol ...................................... 6-3
Mirrors
....................................... 2-55
Convex Outside
.............................. 2-56
Inside Daymight Rearview
..................... 2-55
Manual
..................................... 2-55
Manual Remote Control
........................ 2-55
Power Remote Control
......................... 2-56
Visor Vanity
.................................. 2-60
MountainRoads
................................ 4-23
Multifunction Lever
. . ............... 2-43
Neutral. Automatic Transmission
................. 2-28
Neutral. Manual Transmission
................ 2.32. 2.33
New Vehicle “Break-In”
......................... 2-21
Nightvision
................................... 4-16
Odometer
.................................... 2-75
Odometer. Trip .................................. 2-75
Off-Road Recovery ............................. 4- 12
Oil. Engine
.................................... 6-10
.... Overheating Engine ............................. 5- 13
.... ................ .. Overdrive. Automatic Transmission 2-29
... .. L ... Owner Checks and Services ....................... 7-39
.. Owner Publications, Ordering ..................... 8- 11 .- . ..
Paint Spotting. Chemical . . ................. 6-60
Park Automatic Transmission
........................ 2-27
Shifting
Into ................................. 2-37
Shifting Out of
................................ 2-39 Parking
At Night
.... .... 2-11
Brake
....................... ......... 2-36
Brake Mechanism Check
....................... 7-42
Lots
....................................... 2-11
Over Things That Burn
........................ 2-40
WithaTrailer
................................ 4-37
Parking Your Vehicle, Manual Transmission
.......... 2-39
Passenger Position
......................... 1-26. 1-27
Passing
....................................... 4-13
PASS-Key
II ................................. 2-14
Periodic Maintenance Inspections
.................. 7-43
Pontiac Cares Information
......................... 8-1
Power Antenna Mast Care
............................ 3-23
DoorLocks
................................... 2-4
Option Fuses
................................ 6-63
Remote Control Mirror
........................ 2-56
Retained Accessory
........................... 2-54
Seat
......................................... 1-2
Steering
.................................... 4-10
Steering Fluid
................................ 6-30
Windows
................................... 2-42
Pregnancy. Use of Safety Belts
.................... 1-26
Problems
on the Road ............................ 5-1
Publications, Service and Owner
................... 8-11
Radiator
................................ 5.20. 5.23
Radiator Pressure Cap
........................... 6-30
Radio Reception ................................ 3-20
Radios
........................................ 3-6
9-7
ProCarManuals.com