1996 GMC SIERRA fuel filter

Con Tripmighway Maintenance Schedule -- Gasoline Engines
60,000 Miles (100 000 km)
0 Change engine
oil and filter (or every
12 months, whichever occurs first).
An. Emission Control Service.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add
fluid as needed. Check constant velocity
joints and axle seals for leaking.
‘w
For Two-Wheel-Drive vehicles only: Clean
and repack
the front wheel bearings (or at
each brake relining, whichever occurs first).
0 Inspect engine accessory drive belt.
c] Replace fuel filter. AII Emissiorz Control Service.
An En?.ission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect
fuel cap gasket for any
damage. Replace parts as needed.
An Etnission Control Service.
c] Vehicles With GVWR Above 8,500 lbs.
Only: Inspect shields and underhood
insulation for damage or looseness. Adjust
or replace
as required. This is a Noise Emission
Control Service. Applicdde
ouly to wkicles sold in
the United Stms.
0 If your engine has a thermostatically
controlled cooling fan, inspect all hoses
and ducts for proper hook-up (or every
12 months, whichever occurs first). Be sure
the valve works properly.
This is (7 Noise
Elnission Control Service. Applicable
only to
rvhiclps
snl~J in tlw Unitd Stms.
7-36
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines
0 Conduct Exhaust Gas Recirculation (EGR)
system inspection as described
in the
service manual.
An Emissiorz Control Service. 3‘
inspection. Check all fuel and vapor lines
and hoses for proper hook-up, routing and
condition. Check that
the purge valve works
properly, if equipped. Replace
as needed.
0 Conduct evaporative control system
At1 Emission Control Service. -f-
I DATE I ACTUAL MILEAGE ISERVICED BYI
67,500 Miles (112 500 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An E1uissim Control Service.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid
as needed. Check constant velocity joints and
axle seals for leaking. **
0 Rotate tires. See “Tire Inspection and Rotation“
in the Index for proper rotation pattern and
additional information. During tire rotation,
check brake calipers for freedom
of movement.
Refer
to the appropriate GM service manual for
proper caliper service procedures.
I DATE I ACTUAL MILEAGE I SERVICED BY:
7-37
ProCarManuals.com

1 Long Tripmighway Maintenance Schedule -- Gasoline Engines I
82,500 Miles (137 500 km)
Change engine oil and filter (or every
12 months, whichever occurs first).
AI? Emissiorz Control Service.
0 Lubricate chassis components; see footnote #
(or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add fluid
as needed. Check constant velocity joints and
axle seals for leaking.
**
0 Rotate tires. See ‘‘Tire Inspection and Rotation’’
in the Index for proper rotation pattern and
additional information. During tire rotation,
check brake calipers for freedom of movement. Refer to the appropriate
GM service manual for
proper caliper service procedures.
I DATE I ACTUAL MILEAGE lSERVICED BY I
90,000 Miles (150 000 km)
0 Change engine oil and filter (or every
12 months, whichever occurs first).
An Emission Cmsd Sesvice.
0 Lubricate chassis components;. see footnote #
(or every 12 months, whichever occurs first).
0 Check readfront axle fluid level and add
fluid
as needed. Check constant velocity
joints and axle seals
for leaking. **
0 For Two-Wheel-Drive vehicles only: Clean
and repack
the front wheel bearings (or at
each brake relining, whichever occurs first).
[7 Replace fuel filter. An E~zzission Corztrol Service.
(Continued)
7-39
ProCarManuals.com

Automatic Transmission Check
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages are
working properly. Look
for any other loose or damaged
safety belt system parts.
If you see anything that might
keep a safety belt system from doing its job, have
it
repaired. Have any torn or frayed safety belts replaced.
Also
look for any opened or broken air bag covers, and
have them repaired or replaced. (The air bag
system
does not need regular maintenance.)
Air Cleaner Filter Restriction Indicator Check
Your vehicle has an indicator on the engine that lets you
know when the air cleaner filter is dirty and needs to be
changed. Check indicator at least twice
a year or when
your
oil is changed. See “Air Cleaner” in the Index for
more information.
Manual Transmission Check
Check the transmission fluid level; add if needed. See
“Manual Transmission” in
the Index. A fluid loss may
indicate
a problem. Check the system and repair if needed. Check the transmission
fluid level; add if needed. See
“Automatic Transmission”
in the Index. A fluid loss
may indicate a problem. Check the system and repair
if needed.
Hydraulic Clutch System Check
Check the fluid level in the clutch reservoir. See
“Hydraulic Clutch Fluid”
in the Index. A fluid loss in
this system could indicate a problem. Have the system
inspected and repaired
at once.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified
in Part D.
Body Lubrication Service
Lubricate all fuel doors, body hood and body door
hinges, tailgate and tailgate handle pivot points, latches,
locks and folding seat hardware. Part
D tells you what to
use. More frequent lubrication may be required when
exposed to a corrosive environment.
ProCarManuals.com

USAGE
Windshield
Washer Solvent
Propeller Shaft
SplineRJniversal
Joint and
Propeller Shaft
Hood Latch
Assembly,
Pivots, Spring
Anchor
and
Release Pawl ~~
Hood and Door
Hinges
FLUIDLUBRICANT ~~
GM Optikleen@ Washer Solvent
(GM Part No. 105 15 15) or
equivalent.
Chassis lubricant (GM Part
No. 1052497 or equivalent) or
lubricant meeting requirements
of
NLGI Grade 2, Category LB or
GC-LB.
Lubriplate lubricant aerosol (GM
Part No. 12346293 or equivalent)
or lubricant meeting requirements
of NLGI Grade 2, Category LB or
GC-LB.
Multi-pu ose lubricant,
Superlube
% (CM Part
No. 1234624 1 or equivalent).
USAGE
Body Door
Hinge Pins,
Tailgate Hinge
and Linkage,
Folding Seat,
Fuel Door Hinge
Tailgate Handle
Pivot Points,
Hinges, Latch
Bolt and Linkage
Weatherstrip Conditioning
Weatherstrip Squeaks
Gas Line
FLUIDLUBRICANT
~~ ~~ ~
Multi-pu ose lubricant,
Superlube
(GM Part
No. 1234624 1 or equivalent). I%
Multi-pu ose lubricant,
Superlube (GM Part
No. 12346241 or equivalent).
~~
%
Dielectric Silicone Grease (GM
Part No. 12345579 or equivalent).
Multi-pu ose lubricant,
Superlube (GM Part
No. 12346241 or equivalent).
%
Gas Line De-Icer (GM Part
No. 105 1516).
See “Replacement Parts”
in the Index for recommended
replacement filters, valves and spark plugs.
I
7-50 ..
ProCarManuals.com

Engine ................................... 6.8. 6.10
Coolant
..................................... 6-26
Coolant Heater
............................... 2- 12
Coolant Level Check
.......................... 7-42
Coolant Temperature Gage
..................... 2-62
Cooling System Capacity
....................... 6-76
Exhaust
..................................... 2-30
Fuse Blocks
............................ 6.69. 6.71
Identification
................................ 6-67
OilLevelCheck
.............................. 7-42
Overheating
................................. 5- 10
Running While Parked ......................... 2-30
Specifications
................................ 6-74
StartingYour
................................ 2-11
Underhood Fusemelay Center
................... 6-7 I
Engine Oil .................................... 6- 12
Adding
..................................... 6-13
Additives
................................... 6-15
Checking
................................... 6-12
Pressure Gage
................................ 2-65
Used
....................................... 6-16
Whentochange
.............................. 6-15
Exhaust. Engine
................................ 2-30
Fabric Cleaning
............................... 6-59
Fan Control. Climate Control System
............ 3.1. 3.2
Fender Marker Lamp Bulb Replacement
............. 6-42
FillingYourTank
................................ 6-4
Filter. Air
..................................... 6-16
Finish Care
.................................... 6-63 Finish Damage
................................. 6-64
Flashers. Hazard Warning
......................... 5-1
Flat Tire. Changing
............................. 5-21
Fluid Capacities
................................ 6-76
Fluids and Lubricants
............................ 7-48
FogLamps
.................................... 2-41
Foreign Countries. Fuel
........................... 6-4
Four-wheel Drive
......................... 2-21. 6-25
French Language Manual
11
FrontAxle .................................... 6-26
Front Axle Locking Feature
....................... 2-21
FrontTowing
................................... 5-9
Front Turn Signal Lamp Bulb Replacement
..... 6.40. 6.41
Fuel
.......................................... 6-2
Filling Your Tank
.............................. 6-4
Gage
....................................... 2-68
In Foreign Countries
........................... 6-4
Tankcapacity
............................... 6-76
Fuses and Circuit Breakers
....................... 6-69
Fusible Links
.................................. 6-69
.. ...........................
Gages Engine Coolant Temperature
.................... 2-62
Engine Oil Pressure
........................... 2-65
Fuel
....................................... 2-68
Tachometer
.................................. 2-57
Voltmeter
................................... 2-60
Garage Door Opener
............................ 2-46
GAWR
....................................... 4-42
Speedometer
................................. 2-57
9-4 ..
I
ProCarManuals.com