1996 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS four wheel drive

184 Severe Duty Schedule
*
[BK56400( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK56700( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK56800( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK56900( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK57000( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK57100( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
q
Inspect parking brake fluid (F-Super Duty
only).
*
[BK57450( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
*
[BK57520( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK57550( ALL)04/93]
four pica chart:0060627-A
*
[BK57600( ALL)01/95]
33,000 MILES (55,000 Kilometers)
*
[BK57700( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK57750( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK58050( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

190 Severe Duty Schedule
*
[BK64200( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK64400( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK64500( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK64550( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK64600( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK64900( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK65000( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK65100( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK65400( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK65500( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
*
[BK66025( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
*
[BK66030( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK66035( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK66050( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Severe Duty Schedule 203
*
[BK81200( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK81400( ALL)05/93]
q
Lubricate throttle kickdown or TV lever ball
studs.
*
[BK81600( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK81700( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK81800( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK81900( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK82000( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
*
[BK82450( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
[BK82502( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
[BK82504( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK82505( ALL)04/93]
four pica chart:0060627-A
*
[BK82510( ALL)05/93]
(1) Extremely dusty conditions will require more frequent
replacement of your air filter. check your air filter at
3,000 miles. If it is dirty replace it and then keep
replacing it at the same interval (every 3,000 miles). If
it's not dirty, check it again at 6,000 miles and again at
9,000 miles until you determine your unique
maintenance interval. Do not go beyond 30,000 miles as
described in the chart. If in doubt, see your dealer.
*
[BK82520( ALL)05/93]
(2) If you operate your vehicle ªoff roadº in water that is
deeper than the hubs (1/2 wheel height) then these
items must be serviced daily.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Index 213
Engine knocking............ 113
Engine oil
changing oil and oil filter....... 121
checking and adding......... 120
dipstick............... 120
disposal...........122, 126, 140
engine oil pressure gauge........ 28
filter, specifications.......... 164
refill capacities............ 164
specifications............. 119
synthetic oil............. 119
ªbreak-inº oils............. 7
Exhaust fumes.............. 18
Extended Service Plan, Ford........ 4
F
Federal Highway Administration
Regulation............... 7
Flashers, hazard.............. 38
Flashing the lights............. 36
Flat tire................. 83
Fluid refill capacities.......... 164
Ford Customer Assistance Center...... 94
Ford Dispute Settlement Board....... 95
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 101
Ford of Canada Customer
Assistance Centre........... 101
Foreign registration........... 100
Four-Wheel Drive vehicles, special notice . . 5
French owner guides, how to obtain.... 3
Fuel
calculating fuel economy....... 117
capacity............... 164
choosing the right fuel........ 112
filling your vehicle with fuel...... 111
filter, specifications.......... 164
fuel gauge............... 29
improving fuel economy....... 118
octane rating............. 112
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995