1996 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS steering wheel

184 Severe Duty Schedule
*
[BK56400( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK56700( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK56800( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK56900( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK57000( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK57100( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
q
Inspect parking brake fluid (F-Super Duty
only).
*
[BK57450( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
*
[BK57520( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK57550( ALL)04/93]
four pica chart:0060627-A
*
[BK57600( ALL)01/95]
33,000 MILES (55,000 Kilometers)
*
[BK57700( ALL)01/95]
q
Change engine oil and replace oil filter.
*
[BK57750( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK58050( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

190 Severe Duty Schedule
*
[BK64200( ALL)94/93]
q
Rotate tires and adjust air pressure. (3)(5)(6)
*
[BK64400( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK64500( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK64550( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK64600( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK64900( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK65000( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK65100( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK65400( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK65500( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
*
[BK66025( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
*
[BK66030( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
*
[BK66035( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK66050( ALL)04/93]
four pica chart:0060627-A
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

196 Severe Duty Schedule
*
[BK72195( ALL)04/93]
q
Replace crankcase emission air filter. If operating
in dusty conditions consult your dealer and/or
follow severe duty maintenance schedule. (4.9L,
5.0L man. trans., and 7.5L only.) (1)
*
[BK72400( ALL)04/93]
q
Inspect and lubricate automatic transmission
shift linkage.
*
[BK72500( ALL)05/93]
q
Inspect exhaust system for leaks, damage or
loose parts. Remove any foreign material
trapped by exhaust system shielding.
*
[BK72550( ALL)05/94]
NOTE: It is normal for a certain amount of
moisture and staining to be present
around the muffler seams. The
presence of soot, light surface rust or
moisture does not indicate a faulty
muffler.
*
[BK72600( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK72800( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK72900( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK73000( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK73100( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK73200( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
*
[BK73650( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Severe Duty Schedule 203
*
[BK81200( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK81400( ALL)05/93]
q
Lubricate throttle kickdown or TV lever ball
studs.
*
[BK81600( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK81700( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK81800( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK81900( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK82000( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
*
[BK82450( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
[BK82502( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
[BK82504( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK82505( ALL)04/93]
four pica chart:0060627-A
*
[BK82510( ALL)05/93]
(1) Extremely dusty conditions will require more frequent
replacement of your air filter. check your air filter at
3,000 miles. If it is dirty replace it and then keep
replacing it at the same interval (every 3,000 miles). If
it's not dirty, check it again at 6,000 miles and again at
9,000 miles until you determine your unique
maintenance interval. Do not go beyond 30,000 miles as
described in the chart. If in doubt, see your dealer.
*
[BK82520( ALL)05/93]
(2) If you operate your vehicle ªoff roadº in water that is
deeper than the hubs (1/2 wheel height) then these
items must be serviced daily.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Owner Maintenance Checks 205
Owner Maintenance
Checks
*
[BK82700( ALL)04/93]
The following lists are vehicle checks and
inspections that should be performed by the
owner or qualified service technician at the
frequencies indicated to help ensure safe,
dependable operation of your vehicle.
*
[BK82800( ALL)01/95]
Any adverse conditions should be brought to the
attention of your dealer or qualified service
technician for service advice as soon as possible.
*
[BK82900( ALL)01/95]
These Owner Maintenance Checks are generally
not covered by warranties and you may be
charged for labor, parts and lubricants used.
*
[BK83000( ALL)01/95]
When You Stop for Fuel:
*
[BK83100( ALL)01/95]
q
Check the engine oil level.
*
[BK83200( ALL)01/95]
q
Check the windshield washer fluid level.
*
[BK83300( ALL)01/95]
q
Look for low or under-inflated tires.
*
[BK83400( ALL)01/95]
While Operating Your Vehicle:
*
[BK83500( ALL)01/95]
q
Note any changes in the sound of the exhaust
or any smell of exhaust fumes in the vehicle.
*
[BK83600( ALL)04/93]
q
Check for vibrations in the steering wheel.
Notice any increased steering effort or
looseness in the steering wheel, or change in
its straight ahead position.
*
[BK83700( ALL)04/93]
q
Notice if your vehicleconstantly turns
slightlyor ªpullsº to one side when traveling
on smooth, level road.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

206 Owner Maintenance Checks
*
[BK83800( ALL)01/95]
q
When stopping, listen and check for strange
sounds,pulling to one side, increased brake
pedal travel or ªhard to pushº brake pedal.
*
[BK83900( ALL)04/93]
q
If any slipping or changes in the operation of
your transmission occur, check the
transmission fluid level.
*
[BK84000( ALL)04/93]
q
Check automatic transmission P (Park)
function.
*
[BK84100( ALL)04/93]
q
Check parking brake.
[BK84300( M)04/93]
q
Verify proper ªBrakeº bulb check response
when starting vehicle.
*
[BK84400( ALL)01/95]
At least monthly:
*
[BK84600( ALL)01/95]
q
Check coolant level in the coolant recovery
reservoir.
*
[BK84700( ALL)04/93]
q
Check the operation of all exterior lamps,
including the brakelamps, turn signals and
hazard warning flashers.
*
[BK84800( ALL)04/93]
q
Check for fluid leaks by inspecting the
surface beneath your vehicle for oil, coolant,
or other fluid drips. Clean water from the air
conditioning system is normal.
*
[BK84900( ALL)01/95]
At least twice a year:
(i.e., every Spring and Fall)
*
[BK85000( ALL)04/93]
q
Check power steering fluid level.
q
Check windshield washer spray and wiper
operation. Clean wiper blades with clean
cloth dampended with washer fluid.
*
[BK85200( ALL)01/95]
q
Check radiator, heater and air-conditioning
hoses for leaks or damage.
*
[BK85300( ALL)04/93]
q
Check for worn tires and loose wheel lugnuts.
*
[BK85400( ALL)04/93]
q
Clean body and door drain holes.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

218 Index
S
Safe driving tips.............. 59
Safety chains, when towing a trailer..... 74
Safety Compliance Certification Label.... 6
Safety defects, reporting.......... 99
Safety information relating to
automotive fuels........... 115
Serial number (VIN)............ 5
Service concerns.............. 93
Shift-lock system........... 14,49
Spare tire
changing the tire............ 84
conventional spare........... 83
Spark plugs, specifications........ 164
Special driving conditions......... 59
Specification chart, lubricants....... 165
Speed control
accelerating............... 43
canceling a set speed.......... 45
resetting................ 43
resuming a set speed.......... 45
when towing a trailer.......... 75
Speedometer............... 31
Starting your vehicle
preparing to start your vehicle...... 12
starting a cold engine.......... 13
starting after a collision......... 16
starting a warm engine......... 13
Steering, power.............. 53
Steering wheel
horn.................. 39
tilting................. 40
Storing your vehicle........... 168
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

Index 219
T
Tail lamps, bulb replacement....... 156
Tilt steering wheel............ 40
Tires
changing................ 83
checking the pressure......... 129
inspection and maintenance...... 130
replacing............... 132
rotating............... 131
spare tire............... 83
storing your vehicle.......... 170
treadwear.............. 132
wear bands............. 132
wheel and tire matching........ 136
Towing a trailer (see Trailer towing).... 62
Towing your vehicle........... 89
with a tow truck............ 89
Trailer towing.............. 62
calculating maximum trailer weight . . . 62
Transmission, fluid, refill capacities.... 164
Transmission
automatic operation........... 48
fluid, checking and adding
(automatic)............ 139
fluid, refill capacities......... 164
lubricant specifications........ 165
Transmission control switch........ 50
Tune-up specifications (VECI)...... 160
Turn signal, lever............. 35
U
Used engine oil, disposal....122, 126, 140
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995