1996 FORD F SERIES MOTORHOME AND COMMERCIAL CHASSIS fuel filter

Severe Duty Schedule 203
*
[BK81200( ALL)08/94]
q
Lubricate steering linkage suspension,
driveshaft U-joint if equipped with grease
fittings and lubricate slip yoke (if equipped).
(2)
*
[BK81400( ALL)05/93]
q
Lubricate throttle kickdown or TV lever ball
studs.
*
[BK81600( ALL)05/93]
q
Inspect disc brake system and lubricate
caliper slide rails. (2)
*
[BK81700( ALL)04/94]
q
Inspect drum brake systems, hoses and lines.
*
[BK81800( ALL)04/94]
q
Change fuel filter (Recommended but not
required for California Certified Vehicles).
*
[BK81900( ALL)05/93]
q
Inspect and lubricate front wheel bearings. (2)
*
[BK82000( ALL)04/93]
q
Inspect parking brake system for damage and
operation.
*
[BK82450( FM)06/94]
q
Change rear axle lube (F-Super Duty only).
(4)
[BK82502( FM)02/95]
q
Inspect parking brake fluid (F-Super Duty).
[BK82504( FM)02/95]
q
Check spring U-bolt torque (F-Super Duty).
*
[BK82505( ALL)04/93]
four pica chart:0060627-A
*
[BK82510( ALL)05/93]
(1) Extremely dusty conditions will require more frequent
replacement of your air filter. check your air filter at
3,000 miles. If it is dirty replace it and then keep
replacing it at the same interval (every 3,000 miles). If
it's not dirty, check it again at 6,000 miles and again at
9,000 miles until you determine your unique
maintenance interval. Do not go beyond 30,000 miles as
described in the chart. If in doubt, see your dealer.
*
[BK82520( ALL)05/93]
(2) If you operate your vehicle ªoff roadº in water that is
deeper than the hubs (1/2 wheel height) then these
items must be serviced daily.
File:ltbkm.ex
Update:Tue Jun 20 16:42:47 1995

Index 209
Index
A
Accessory position on the ignition..... 10
Additives, engine oil.......... 119
Air cleaner filter, specifications...... 164
Alcohol, in fuel............. 114
Antifreeze (see Engine coolant)...... 122
Appeals (see Dispute settlement board) . . . 95
Assistance (see Customer assistance) . . 91±92
Automatic transmission, fluid, refill capacities 164
Automatic transmission
driving an automatic overdrive..... 47
fluid, adding............. 140
fluid, checking............ 139
fluid, refill capacities......... 164
fluid, specification.......... 165
Axle
lubricant specifications........ 165
refill capacities............ 164
B
Backing up................ 50
Basic vehicle warranty........... 4
Battery
acid, treating emergencies...... 79,137
charging system warning light...... 26
disconnecting.............. 82
how to service............ 136
jumping a disabled battery....... 79
maintenance-free........... 136
proper disposal, recycling....... 137
replacement, specifications....... 164
voltage gauge............. 27
when storing your vehicle....... 169
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

Index 213
Engine knocking............ 113
Engine oil
changing oil and oil filter....... 121
checking and adding......... 120
dipstick............... 120
disposal...........122, 126, 140
engine oil pressure gauge........ 28
filter, specifications.......... 164
refill capacities............ 164
specifications............. 119
synthetic oil............. 119
ªbreak-inº oils............. 7
Exhaust fumes.............. 18
Extended Service Plan, Ford........ 4
F
Federal Highway Administration
Regulation............... 7
Flashers, hazard.............. 38
Flashing the lights............. 36
Flat tire................. 83
Fluid refill capacities.......... 164
Ford Customer Assistance Center...... 94
Ford Dispute Settlement Board....... 95
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 101
Ford of Canada Customer
Assistance Centre........... 101
Foreign registration........... 100
Four-Wheel Drive vehicles, special notice . . 5
French owner guides, how to obtain.... 3
Fuel
calculating fuel economy....... 117
capacity............... 164
choosing the right fuel........ 112
filling your vehicle with fuel...... 111
filter, specifications.......... 164
fuel gauge............... 29
improving fuel economy....... 118
octane rating............. 112
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995

214 Index
Fuel (continued)
quality................ 113
running out of fuel.......... 117
safety information relating to
automotive fuels.......... 115
storing your vehicle.......... 169
treating emergencies.......... 115
Fuel cap
removing............... 111
replacing.............111, 117
Fuel filter, specifications......... 164
Fuel gauge................ 29
Fuel pump shut-off switch, starting after
a collision............... 16
Fuse panel, instrument panel....... 148
Fuse panels, power distribution box.... 150
Fuses
checking and replacing........ 153
circuit breakers............ 155
G
Gas cap (see Fuel cap).......... 111
Gas mileage (see Fuel economy) . . . 112, 117
Gasoline (see Fuel)............ 111
Gauges, Mechanical
battery voltage gauge.......... 27
charging system gauge......... 27
engine coolant temperature gauge.... 30
engine oil pressure gauge........ 28
fuel gauge............... 29
speedometer.............. 31
GAWR (Gross Axle Weight Rating)
calculating............... 67
definition................ 65
Gearshift
automatic operation........... 48
locking the gearshift........... 9
positions................ 48
shifting the gears............ 48
shift-lock.............. 14,49
File:ltixm.ex
Update:Tue Jun 20 16:42:52 1995