1996 FORD EXPLORER warning lights

295
Roadside Emergencies
%*
[RE00400(ALL)03/95]
Jump-Starting Your Vehicle
*
[RE00500(ALL)08/95]
Your vehicle's battery may die if you leave the lights on or any
electrical equipment on after you turn the engine off. If this
happens, you may be able to jump-start your vehicle with a
booster battery.
*
[RE00600(ALL)02/95]
RWARNING
The gases around the battery can explode if exposed to
flames, sparks, or lit cigarettes. An explosion could result
in injury or vehicle damage.
*
[RE00700(ALL)02/95]
RWARNING
To protect yourself when charging a battery, always
shield your face and eyes. Make sure that you can
breathe fresh air.
%*
[RE00800(ALL)06/95]
RWARNING
Applying too much pressure on the ends when lifting a
battery could cause acid to spill. Lift the battery with a
carrier or with your hands on the opposite corners.
%*
[RE00900(ALL)07/95]
RWARNING
Batteries contain sulfuric acid which burns skin, eyes,
and clothing.
*
[RE00910(ALL)07/95]
If the acid touches someone's skin, eyes, or clothing,
immediately flush the area with water for at least 15 minutes. If
someone swallows the acid, have him or her drink lots of milk
or water first, then Milk of Magnesia, a beaten egg, or vegetable
oil. Call a doctor immediately.
File:12unrex.ex
Update:Thu Feb 29 09:14:34 1996

296
*
[RE00950(ALL)06/95]
RWARNING
Do not push-start your vehicle. You could damage the
catalytic converter. For further information, seeJumper
Cablesin the Index.
*
[RE01000(ALL)05/95]
RWARNING
To avoid damage or injury, follow these directions in the
order they are given. If in doubt, call for road service.
*
[RE01100(ALL)03/95]
Preparing Your Vehicle
*
[RE01200(ALL)03/95]1.
Your vehicle has a 12-volt starting system, so you need to
use a 12-volt jumper system. You will damage your starting
motor, ignition system, and other electrical parts if you
connect them to a 24-volt power supply (either two 12-volt
batteries in series or a 24-volt generator set).
*
[RE01300(ALL)03/95]2.
Do not disconnect the battery of the disabled vehicle. You
could damage the vehicle's electrical system.
*
[RE01400(ALL)04/95]3.
Park the booster vehicle close to the hood of the disabled
vehicle.Make sure the vehicles do not touch each other.Set
the parking brake on both vehicles and stay clear of the
engine cooling fan and other moving parts.
*
[RE01500(ALL)03/95]4.
Check all battery terminals and remove any excessive
corrosion before you attach the jumper cables.
*
[RE01600(ALL)02/95]5.
Turn on the heater fan in both vehicles. Turning on the fan
helps protect the electrical system from voltage surges. Turn
off all other switches and lights in both vehicles to prevent
possible damage to either vehicle's electrical systems.
File:12unrex.ex
Update:Thu Feb 29 09:14:34 1996

314
[RE28400(ALL)05/91]
n
Disconnect the driveshaft at the rear differential and properly
support it under the vehicle.
[RE28500(ALL)01/95]
n
Mark the driveshaft and axle flanges to ensure proper
position when reconnecting the driveshaft. Refer to service
manual for proper driveshaft fastener torque specification.
(See theAccessorieschapter for information on ordering
service manuals.)
[RE28600(ALL)05/95]
RWARNING
When disconnecting/installing the driveshaft, the parking
brake must be set and the wheels blocked to ensure the
vehicle does not roll.
[RE28700(ALL)06/94]
n
Maximum speed is 55 mph (88 km/h), unlimited distance.
[RE28720(ALL)12/91]
4x2ÐManualtransmission
*
[RE28740(ALL)03/95]
n
Release the parking brake.
[RE28750(ALL)01/95]
n
Place the transmission gearshift in the neutral position.
[RE28770(ALL)12/91]
n
Maximum speed is limited by towing equipment
manufacturer's recommendation, unlimited distance.
[RE29450( X)10/94]
CONTROL TRAC transfer case
*
[RE29500(ALL)03/95]
n
Release the parking brake.
[RE29600(ALL)01/95]
n
Place the transmission gearshift in the neutral position.
[RE29750( X)10/94]
n
Ensure the transfer case is in 2WD.
[RE29800(ALL)10/94]
NOTE: Both the 4WD and 4WD Low indicator lights in the
instrument panel will be off when the 4WD switch is
in 2WD.
[RE29850(ALL)10/92]
For automatic transmissions:
[RE29900(ALL)10/94]
n
Maximum speed is 35 mph (56 km/h).
[RE30000(ALL)10/94]
n
Maximum distance is 50 miles (80 km).
File:12unrex.ex
Update:Thu Feb 29 09:14:34 1996

Servicing Your Explorer
377
[SV35500(ALL)10/94]
10-1/2 pica art:0020376-E
Clutch fluid reservoir
%*
[SV35800(ALL)07/95]
Driveline Universal Joint and Slip Yoke
*
[SV36000(ALL)06/93]
The universal joints that come standard with your vehicle do
not require lubrication. If your original equipment universal
joints are replaced with universal joints equipped with grease
fittings, lubrication will be necessary at the intervals shown in
theMaintenance Schedule and Recordbooklet.
%*
[SV36300(ALL)03/95]
Brake Fluid
*
[SV36350(ALL)05/90]
Your vehicle is equipped with a brake fluid level indicator in
the master cylinder which lights the BRAKE warning light on
the instrument panel when the brake fluid level is low.
*
[SV36400(ALL)03/95]
Under normal circumstances, your vehicle should not use up
brake fluid rapidly. However, expect the level of the brake fluid
to slowly fall as you put more mileage on your vehicle and the
brake pads wear.
*
[SV36500(ALL)08/95]
Check the brake fluid at least once a year. You can do this by
looking at the fluid level in the plastic brake fluid reservoir on
the master cylinder. The fluid level should be at or near the
MAX mark.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

431
Index
GAWR (Gross Axle Weight Rating)
calculating..................... 277
definition....................271, 276
driving with a heavy load.............. 271
location....................271, 276
Gearshift
automatic operation................. 246
column-mounted.................. 246
floor-mounted.................... 251
gearshift override.................. 247
locking the gearshift.................. 67
positions....................246, 251
shifting the gears................246, 251
shift-lock...................... 247
Gearshift:shifting the gears.............246, 251
GVWR (Gross Vehicle Weight Rating)
calculating..................... 277
definition....................271, 275
driving with a heavy load.............. 271
location...................... 276
H
Hazard flashers.................... 139
Headlamps
aiming....................... 392
autolamp system.................. 128
checking alignment................. 392
cleaning...................... 132
daytime running lights................ 132
flashing...................... 136
high beam..................... 136
replacing bulbs.................392±393
turning on and off................. 127
warning chime.................... 91
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

434
Lamps (continued)
interior lamps.................127, 132
replacing bulbs................... 392
trailer....................... 290
Lane change indicator (see Turn signal)......... 135
Lights, warning and indicator
airbag........................ 83
anti-theft....................... 88
brake........................ 81
charging system................... 87
check engine..................... 84
engine oil pressure.................. 90
hazard warning light................ 139
high beam...................... 91
low washer fluid.................. 104
oil pressure...................... 90
overdrive off..................... 86
safety belt...................... 82
service engine soon.................. 84
theft system..................... 88
turn signal indicator................. 135
Load limits
GAWR....................... 271
GVWR....................... 271
trailer towing.................... 272
Lubricant specifications................ 406
Lug nuts
standard...................... 307
tightening sequence................. 304
M
Maintenance schedule and record (see separate Maintenance
Schedule and Record booklet)........... 3
Maintenance (see Servicing).............. 333
Manual transmission
clutch.....................251, 376
fluid, checking and adding.............. 376
lubricant specifications................ 406
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

442
Ventilating your vehicle (see Climate control)...... 110
Viscosity (see Engine oil)................ 348
Voltmeter (see Battery voltage gauge)......... 87,89
W
Warm engine, starting.................. 72
Warning chimes
headlamps on.................... 91
key in ignition.................... 68
safety belt...................... 82
Warning lights (see Lights)................ 79
Warranties
basic......................... 3
Canada....................... 3
radio........................ 243
Warranty Information Booklet.............. 3
Washer fluid
rear window reservoir................ 358
reservoir...................... 358
warning light.................... 104
windshield..................... 358
Weight limits (GAWR, GVWR)............. 271
Wheel and tire matching................ 369
Wheel bearings, lubricant specifications......... 406
Wheel bearings lubricant specifications......... 406
Wheel dollies (see Towing)............... 311
Wheels
cleaning...................... 370
covers.....................304, 307
inspection and maintenance............. 362
lug nuts...................... 304
replacement.................... 369
Windows
manual windows, operating............. 171
one-touch down.................. 172
power windows, operating............171±172
rear, defrosting................... 126
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996