1996 FORD EXPLORER maintenance

Servicing Your Explorer
377
[SV35500(ALL)10/94]
10-1/2 pica art:0020376-E
Clutch fluid reservoir
%*
[SV35800(ALL)07/95]
Driveline Universal Joint and Slip Yoke
*
[SV36000(ALL)06/93]
The universal joints that come standard with your vehicle do
not require lubrication. If your original equipment universal
joints are replaced with universal joints equipped with grease
fittings, lubrication will be necessary at the intervals shown in
theMaintenance Schedule and Recordbooklet.
%*
[SV36300(ALL)03/95]
Brake Fluid
*
[SV36350(ALL)05/90]
Your vehicle is equipped with a brake fluid level indicator in
the master cylinder which lights the BRAKE warning light on
the instrument panel when the brake fluid level is low.
*
[SV36400(ALL)03/95]
Under normal circumstances, your vehicle should not use up
brake fluid rapidly. However, expect the level of the brake fluid
to slowly fall as you put more mileage on your vehicle and the
brake pads wear.
*
[SV36500(ALL)08/95]
Check the brake fluid at least once a year. You can do this by
looking at the fluid level in the plastic brake fluid reservoir on
the master cylinder. The fluid level should be at or near the
MAX mark.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

Servicing Your Explorer
399
[SV47875( X)04/94]
eight pica
chart:0020633-G*
[SV48400(ALL)10/90]
Rear lighting wire functions
[SV48500(ALL)04/94]
eight pica
chart:0021201-A%*
[SV48600(ALL)03/95]
Emission Control System
*
[SV48700(ALL)05/95]
Your vehicle is equipped with a catalytic converter which
enables your vehicle to comply with applicable exhaust emission
requirements.
*
[SV48800(ALL)05/95]
To make sure that the catalytic converter and the other emission
control parts continue to work properly:
*
[SV48900(ALL)01/95]
n
Use only unleaded fuel.
*
[SV49000(ALL)01/95]
n
Avoid running out of fuel.
*
[SV49100(ALL)01/95]
n
Do not turn off the ignition while your vehicle is moving,
especially at high speeds.
*
[SV49200(ALL)03/95]
n
Have the services listed in yourMaintenance Schedule and
Recordbooklet performed according to the specified schedule.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

Servicing Your Explorer
401
*
[SV49800(ALL)02/92]
Never use a metal exhaust collector when you service your
vehicle. If the metal collector contacts any of your vehicle's
plastic trim or bumper parts they could melt or deform.
*
[SV49900(ALL)01/95]
Do not drive your vehicle if it does not operate properly. See
your dealer if the engine runs on for more than five seconds
after you shut it off or if it misfires, surges, stalls, or backfires.
%*
[SV50000(ALL)05/95]
Information about your vehicle's emission control system is on
the Vehicle Emission Control Information decal located on or
near the engine. This decal identifies engine displacement and
gives some tune-up specifications.
%*
[SV51475(ALL)07/95]
Readiness for Inspection/Maintenance Testing
*
[SV51480(ALL)07/95]
In some localities it may become a legal requirement to pass an
Inspection/Maintenance (I/M) test of the On-Board Diagnostic
(OBD) II system. If the vehicle's powertrain system or its battery
has just been serviced, the OBD II system is reset to a not ready
for I/M testing condition. To prepare for I/M testing, the law
specifies a ªneed for additional mixed city and highway driving
to complete the checkº of the OBD II system. As soon as all of
the OBD II system checks are successfully completed, the OBD
II system is set to the ready condition. The amount of driving
required to reach the ready condition varies with individual
driving patterns. To complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle defined below.
If the vehicle owner cannot or does not want to do the
additional driving required by law, a service center can perform
this drive cycle as it would any other type of repair work.
*
[SV51485(ALL)09/95]
OBD II Drive Cycle
*
[SV51490(ALL)06/95]
The following steps must be run in the order shown. If any
steps are interrupted, repeat the preceding step. Any safe
driving mode is acceptable between steps.
*
[SV51495(ALL)06/95]
Always drive vehicle in safe manner according to traffic
conditions and obey all traffic laws.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

408
[SV54425( X)03/95]
twenty pica
chart:0090115-A%*
[SV56000(ALL)01/95]
Vehicle Storage
*
[SV56100(ALL)01/95]
Maintenance Tips
*
[SV56150(ALL)01/95]
If you plan on storing your vehicle for an extended period of
time (60 days or more), refer to the following maintenance
recommendations to ensure your vehicle stays in good operating
condition.
*
[SV56200(ALL)01/95]
General
*
[SV56300(ALL)01/95]
n
Store all vehicles in a dry, ventilated place.
*
[SV56400(ALL)01/95]
n
Protect from sunlight, if possible.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

Servicing Your Explorer
409
*
[SV56500(ALL)01/95]
n
If vehicles are stored outside, they require regular
maintenance to protect against rust and damage.
*
[SV56600(ALL)01/95]
Body
*
[SV56700(ALL)01/95]
n
Wash vehicle thoroughly to remove dirt, grease, oil, tar or
mud from exterior surfaces, rear wheel housing and
underside of front fenders.
*
[SV56800(ALL)01/95]
n
Periodically wash vehicles stored in exposed locations.
*
[SV56900(ALL)01/95]
n
Touch-up raw or primed metal to prevent rust.
*
[SV57000(ALL)01/95]
n
Cover chrome and stainless steel parts with a thick coat of
auto wax to prevent discoloration. Re-wax as necessary when
the vehicle is washed.
*
[SV57100(ALL)04/95]
n
Lubricate all hood, door and trunk lid hinges and latches
with a light grade oil.
*
[SV57200(ALL)01/95]
n
Cover interior soft trim to prevent fading.
*
[SV57300(ALL)01/95]
n
Keep all rubber parts free from oil and solvents.
%*
[SV57350(ALL)01/95]
Engine
*
[SV57400(ALL)01/95]
n
Start engine every 15 days. Run at fast idle until it reaches
normal operating temperature.
*
[SV57500(ALL)01/95]
n
With your foot on the brake, shift through all the gears
while the engine is running.
%*
[SV57600(ALL)01/95]
Fuel system
%*
[SV57700(ALL)07/94]
n
Fill fuel tank with high-quality unleaded fuel until the first
automatic shutoff of the fuel pump nozzle.
*
[SV57900(ALL)03/95]
NOTE: During extended periods of vehicle storage (60 days or
more), fuel may deteriorate due to oxidation. This can
damage rubber and other polymers in the fuel system
and may also clog small orifices.
File:15unsvx.ex
Update:Thu Feb 29 09:20:34 1996

422
Anti-theft system (continued)
triggering..................... 167
warning light..................... 88
Appeals (see Dispute settlement board)......... 319
Assistance (see Customer assistance).......... 317
Audio system (see Electronic sound system)....... 207
Autolamp system (see Headlamps).........128, 132
Autolock (see Keyless entry).............. 159
Automatic transaxle, fluid, specification......... 406
Automatic transmission
driving an automatic overdrive............ 248
fluid, adding.................... 375
fluid, checking................... 374
fluid, specification.................. 406
Axle
lubricant specifications................ 406
traction lok...................269, 363
B
Backing up...................... 248
Basic vehicle warranty.................. 3
Battery
acid, treating emergencies..........295, 372±373
battery saver.................... 166
charging system warning light............. 87
disconnecting.................... 298
how to service................... 371
jumping a disabled battery.............. 295
maintenance-free.................. 371
proper disposal, recycling.............. 372
replacement, specifications.............. 405
servicing...................... 371
voltage gauge.................. 87,89
when storing your vehicle.............. 410
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

434
Lamps (continued)
interior lamps.................127, 132
replacing bulbs................... 392
trailer....................... 290
Lane change indicator (see Turn signal)......... 135
Lights, warning and indicator
airbag........................ 83
anti-theft....................... 88
brake........................ 81
charging system................... 87
check engine..................... 84
engine oil pressure.................. 90
hazard warning light................ 139
high beam...................... 91
low washer fluid.................. 104
oil pressure...................... 90
overdrive off..................... 86
safety belt...................... 82
service engine soon.................. 84
theft system..................... 88
turn signal indicator................. 135
Load limits
GAWR....................... 271
GVWR....................... 271
trailer towing.................... 272
Lubricant specifications................ 406
Lug nuts
standard...................... 307
tightening sequence................. 304
M
Maintenance schedule and record (see separate Maintenance
Schedule and Record booklet)........... 3
Maintenance (see Servicing).............. 333
Manual transmission
clutch.....................251, 376
fluid, checking and adding.............. 376
lubricant specifications................ 406
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996

438
Safety restraints (continued)
for infants.................... 32,52
for pregnant women................. 9
lap and shoulder belts................ 9,11
maintenance..................... 22
proper use...................... 9
replacement................... 22,24
warning light and chime................ 82
Safety seats for children
and air bags.................. 27,52±53
attaching with tether straps.............. 64
automatic locking mode (retractor)......... 13,52
built-in child seat................... 34
in front seat..................... 52
in rear outboard................... 52
in rear seat...................... 52
tether anchorage hardware............... 64
Seat belts (see Safety restraints).............. 9
Seats
adjusting the seat, manual.............. 174
adjusting the seats, power.............. 183
child safety seats................... 52
cleaning upholstery................. 186
reclining the seat.................. 174
seatback release................... 174
Serial number (VIN).................. 318
Service concerns.................... 318
Servicing your vehicle
precautions when servicing............. 334
servicing when you tow............... 311
Shift-lock system................... 247
Shift positions (see Gearshift)............246, 251
Shoulder and lap belts (see Safety restraints)....... 9,11
Shoulder belts (see Safety restraints)......... 11,14
Side mirrors
adjusting...................... 191
Sliding moon roof (see Moon roof)........... 192
File:unixx.ex
Update:Thu Feb 29 09:21:09 1996