1996 FORD ESCORT coolant level

126 [LG08800(ALL)08/95]Under certain conditions, the Check Engine
Warning Light may come on if the fuel cap is
not properly installed. If the Check Engine
Warning Light comes on and you suspect that
the fuel cap is not properly installed, pull off the
road as soon as it is safely possible and turn off
the engine. Remove and replace the fuel cap,
making sure it is properly seated.
[LG08900(ALL)08/95]
After completing three (3) consecutive warm up
cycles and on the fourth engine start up, the
Check Engine Warning light should turn off. If
the light does not go off after the fourth engine
restart, have your vehicle serviced by your
dealer or a qualified technician.
[LG10324(ALL)08/95]
Check Coolant Light
[LG10326(ALL)01/92]
This light indicates that the level of the engine
coolant is low and that you should add more
coolant. This light comes on when you turn the
ignition key to START and remains on for a few
seconds after the engine starts, then normally
goes out. SeeEngine coolantin the Index.
[LG10330(ALL)10/89]
one inch art:0000860-A
The check coolant light
[LG10338(ALL)10/91]
If the CHECK COOLANT warning light stays
on, turn the ignition key to OFF and fill the
recovery bottle to the FULL HOT mark. If the
CHECK COOLANT warning light comes on and
stays on after the recovery bottle has been filled,
have your vehicle serviced as soon as possible.
File:05ctlge.ex
Update:Tue Sep 19 14:44:43 1995

130 %
*
[LG20187(ALL)01/95]
Engine Coolant Temperature Gauge
*
[LG20188(ALL)03/95]
This gauge indicates the temperature of the
engine coolant, not the coolant level. If the
coolant is not at its proper level or mixture, the
gauge indication will not be accurate.
[LG20189(ALL)06/94]
The pointer moves from C (Cold) into the
normal band as your vehicle warms up. Under
most driving conditions, the pointer should stay
in the normal band. If you are driving in heavy
traffic or uphill in hot weather, the pointer may
reach to the top of the normal band.
[LG20190(ALL)06/94]
one third page art:0070160-B[LG20191(ALL)10/89]
Under any circumstances, if the pointer moves
past the upper limit of the normal band, the
engine is overheating and may result in engine
damage.
File:05ctlge.ex
Update:Tue Sep 19 14:44:43 1995

131
*
[LG20192(ALL)01/95]
If your engine coolant overheats:
*
[LG20193(ALL)03/95]
1. Pull off the road as soon as it is safely
possible.
*
[LG20194(ALL)01/95]
2. Turn off the engine.
*
[LG20195(ALL)05/95]
3. Let the engine cool.
*
[LG20196(ALL)03/95]
4. Check the coolant level following the
instructions on checking and adding coolant
to your engine. (SeeEngine coolantin the
Index.) If you do not follow these
instructions, you or others could be injured.
*
[LG20197(ALL)05/92]
5. Add as much coolant as your engine needs.
If the engine continues to overheat, have the
coolant system serviced.
[LG20200(E )12/89]The Sport Cluster
*
[LG20300(E )04/94]
The sport cluster has basically the same standard
warning lights and gauges as the standard
cluster, with the following additional features:
File:05ctlge.ex
Update:Tue Sep 19 14:44:43 1995

297 [SV17200(ALL)06/95]
10-1/2 pica art:0060618-C
*
[SV17275(ALL)07/95]
RWARNING
Continuous contact with USED motor oil
has caused cancer in laboratory mice.
*
[SV17280(ALL)07/95]
Protect your skin by washing with soap and
water.
%
*
[SV17300(ALL)03/95]
Engine Coolant
%*
[SV17350(ALL)09/95]
Checking the Engine Coolant
*
[SV17360(ALL)01/95]
NOTE: Be sure to read and understand
Precautions When Servicing Your
Vehicleat the beginning of this chapter.
*
[SV17400(ALL)05/95]
RWARNING
The cooling fan is automatic and may
come on at any time. Always disconnect
the negative terminal of the battery before
working near the fan.
[SV17450(ALL)09/95]
Check the engine coolant level in the engine
coolant recovery reservoir at least once a month.
The coolant should be between the Full Hot and
Full Cold marks on the reservoir. To locate the
reservoir, see the diagram of your vehicle's
engine underEngine compartmentin this chapter.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

298
*
[SV17455(ALL)09/95]
RWARNING
Do not put engine coolant in the container
for the windshield washer fluid.
*
[SV17460(ALL)09/95]
If sprayed to clean the glass, engine coolant or
antifreeze could make it difficult to see through
the windshield.
[SV17475(ALL)05/94]
NOTE: Additional illumination may be needed
to see the coolant reservoir markings
clearly.
[SV17500(ALL)06/94]
one third page art:0070033-D
The engine coolant reservoir
[SV17560(ALL)08/95]
If the engine coolant has not been checked for a
long period of time the engine coolant reservoir
may eventually empty. If the engine coolant
reservoir empties, check the engine coolant level
in the radiator. Read the following instructions
before removing the radiator cap. If it is
necessary to fill the radiator, refer to theRefill
Capacitieschart later in this chapter.
*
[SV17565(ALL)09/95]
RWARNING
Failure to follow these instructions could
result in serious personal injury from hot
engine coolant or steam blowout and/or
damage to the engine cooling system or
engine.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

301
*
[SV19480(ALL)04/93]
Leave the engine coolant in all year. Make sure
that the coolant will not freeze at the
temperature level in which you drive during
winter months. Keep an engine coolant in your
engine that has a protection rating of at least
-20ÊF (-29ÊC), orwhatever protection rating is
appropriate for the climate in which you live.
*
[SV19900(ALL)02/95]
You may add water by itself only in an
emergency, but you should replace it with a
50/50 mixture as soon as possible.
*
[SV20000(ALL)01/95]
Have your dealer check the engine cooling
system for leaks if you have to add a quart
(liter) of engine coolant more than once a month.
%*
[SV20210(ALL)08/95]
Checking Hoses
*
[SV20220(ALL)01/93]
Inspect all engine and heater system hoses for
deterioration, leaks and loose clamps before
adding or replacing engine coolant. Make
whatever repairs or replacements are necessary
using Motorcraft parts or their equivalents.
%
*
[SV21700(ALL)03/95]
Windshield Washer Fluid and
Wipers
%*
[SV21800(ALL)03/95]
Washer Fluid
[SV22100(ALL)01/95]
The windshield washer reservoir is located in
the engine compartment.
*
[SV22350(ALL)05/95]
RWARNING
Do not put windshield washer fluid in the
container for the engine coolant.
%*
[SV22500(ALL)01/95]
Use specially formulated windshield washer
fluid rather than plain water, because specially
formulated washer fluids contain additives that
dissolve road grime. For safety reasons, washer
fluids containing an appropriate antifreeze such
as methanol should be used in freezing weather
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995

319
*
[SV31100(ALL)01/95]
RWARNING
Do not let the reservoir for the master
cylinder run dry. This may cause the
brakes to fail.
%*
[SV31200(ALL)02/95]
Power Steering Fluid
*
[SV31300(ALL)01/95]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
%*
[SV31400(ALL)03/95]
Checking and Adding Power Steering
Fluid
*
[SV31500(ALL)02/95]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[SV31600(ALL)01/95]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[SV31700(ALL)05/95]
3. Turn the engine off.
[SV31850(ALL)02/94]
4. Check the fluid level in the reservoir. The
fluid level should be in between the F (Full)
and L (Low) markings on the reservoir.
[SV32100(ALL)02/94]
5. If the power steering fluid is low, add fluid
in small amounts, continuously checking the
level until you reach the F (Full) range. Do
not overfill. To find out how much fluid
your vehicle's reservoir for the power
steering fluid will hold, seeRefill capacitiesin
the Index.
[SV32150(ALL)03/95]
6. When you are finished, put the reservoir cap
back on and make sure that it fits snugly.
File:15ctsve.ex
Update:Tue Sep 19 14:37:50 1995