1996 FORD BRONCO service

316
*
[SV34000(B FM)06/92]
quarter page art:0020372-E
Automatic transmission dipstick
[SV34400(B F )01/95]
Manual Transmission and
Transfer Case Fluid
[SV34600(B F )01/95]
Checking the fluid
*
[SV34700(B F )12/91]
Clean the filler plug on the side of the case.
Remove the filler plug. The fluid level should be
up to the bottom of the filler plug hole.
*
[SV34800(B F )03/91]
If additional fluid is required:
[SV34900(B F )01/95]
1. Add enough fluid through the filler plug
hole to bring the level up to the bottom of
the hole. Use only fluid certified to meet
Ford Motor Company lubricant specification
as listed underA Quick Reference for Refill
Capacities and Motorcraft Parts, later in this
section.
*
[SV35000(B F )03/91]
2. Replace the filler plug in its original
position, making sure it is fully seated.
%
*
[SV35100(B F )02/95]
The Clutch
*
[SV35200(B F )03/91]
The clutch on your vehicle is automatically
self-adjusting and should not require any routine
service.
*
[SV35301(B F )03/91]
During normal operation the fluid level in the
clutch reservoir will slowly rise. If for any
reason the fluid level drops, maintain the fluid
level at the step in the reservoir body.
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

339 [SV47750(B )03/91]
eight pica chart:0020791-A
%*
[SV48600( ALL)03/95]
Emission Control System
*
[SV48700(BEF )05/95]
Your vehicle is equipped with a catalytic
converter which enables your vehicle to comply
with applicable exhaust emission requirements.
*
[SV48725(B )05/95]
RWARNING
Exhaust leaks may result in the entry of
harmful and potentially lethal fumes into
the passenger compartment. Under
extreme conditions excessive exhaust
temperatures could damage the fuel
system, the interior floor covering, or
other vehicle components, possibly
causing a fire.
*
[SV48800(BEF )05/95]
To make sure that the catalytic converter and the
other emission control parts continue to work
properly:
*
[SV48900( ALL)01/95]
q
Use only unleaded fuel.
*
[SV49000( ALL)01/95]
q
Avoid running out of fuel.
*
[SV49100( ALL)01/95]
q
Do not turn off the ignition while your
vehicle is moving, especially at high speeds.
*
[SV49200( ALL)03/95]
q
Have the services listed in theMaintenance
Schedule and Recordbooklet performed
according to the specified schedule. The
scheduled maintenance services are required
because they are considered essential to the
life and performance of your vehicle and to
its emissions system.
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

340
*
[SV49250( ALL)03/95]
In general, maintenance, replacement, or service
of the emissions control devices or systems in
your new Ford Motor Company vehicle or
engine may be performed at your expense by
any automotive repair establishment or
individual using automotive parts equivalent to
those which your vehicle or engine was
originally equipped.
*
[SV49300( ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[SV49400(BEF )05/95]
RWARNING
On vehicles without original equipment
floor covering or insulation, do not let
passengers ride in your truck in a manner
that allows contact between skin and the
metal floor.
*
[SV49450( ALL)05/95]
If other than Ford or Motorcraft or Ford
authorized remanufactured parts are used for
maintenance, replacement, or for the service of
components affecting emissions control, the
owner should be assured that such parts are
warranted by their manufacturer to be
equivalent to genuine Ford Motor Company
parts in performance and durability. Please
consult your warranty information booklet for
complete warranty information.
*
[SV49500(BEF )05/95]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

341
*
[SV49600( ALL)01/95]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
*
[SV49700( ALL)01/95]
By law, anyone who manufactures, repairs,
services, sells, leases, trades vehicles, or
supervises a fleet of vehicles is not permitted to
intentionally remove an emission control device
or prevent it from working. In some of the
United States and in Canada, vehicle owners
may be liable if their emission control device is
removed or is prevented from working.
*
[SV49900( ALL)01/95]
Do not drive your vehicle if it does not operate
properly. See your dealer if the engine runs on
for more than five seconds after you shut it off
or if it misfires, surges, stalls, or backfires.
%*
[SV50000( ALL)05/95]
Information about your vehicle's emission
control system is on the Vehicle Emission
Control Information decal located on or near the
engine. This decal identifies engine displacement
and gives some tune-up specifications.
%*
[SV51456( ALL)05/95]
Readiness for Inspection/Maintenance
Testing
*
[SV51457( ALL)05/95]
In some localities it may become a legal
requirement to pass an
Inspection/Maintenance (I/M) test of the
On-Board Diagnostic (OBD) II system. If the
vehicle's powertrain system or its battery has
just been serviced, the OBD II system is reset to
a not ready for I/M testing condition. To
prepare for I/M testing, the law specifies a
ªneed for additional mixed city and highway
driving to complete the checkº of the OBD II
system. As soon as all of the OBD II system
checks are successfully completed, the OBD II
system is set to the ready condition. The amount
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

342of driving required to reach the ready condition
varies with individual driving patterns. To
complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle
defined below. If the vehicle owner cannot or
does not want to do the additional driving
required by law, a service center can perform
this drive cycle as it would any other type of
repair work.
[SV51458( ALL)05/95]
OBD II Drive Cycle
[SV51459( ALL)04/95]
The engine must be warmed up and at
operating temperature before proceeding with
the drive modes of the following OBD II Drive
Cycle.
[SV51461( ALL)04/95]
1. Start the engine. Drive or idle (in neutral)
the vehicle for 4 minutes.
[SV51463( ALL)04/95]
2. Idle the vehicle in drive (neutral for manual
transmission) for 40 seconds.
*
[SV51465( ALL)05/95]
3. Accelerate the vehicle to 45 mph (72 km/h)
at 1/4 to 1/2 throttle for 10 seconds.
*
[SV51467( ALL)05/95]
4. Drive the vehicle with a steady throttle at
45 mph (72 km/h) for 30 seconds.
[SV51469( ALL)04/95]
5. Idle the vehicle in drive (neutral for manual
transmissions) for 40 seconds.
*
[SV51471( ALL)05/95]
6. Continue to drive the vehicle in city traffic at
speeds between 25 and 40 mph
(40-64 km/h) for 15 minutes. During the 15
minute drive cycle the following modes must
be achieved:
*
[SV51473( ALL)05/95]
a. at least 5 stop and idle modes at 10
seconds each
*
[SV51475( ALL)05/95]
b. acceleration from idles at 1/4 to 1/2
throttle position, and
*
[SV51477( ALL)05/95]
c. choose 3 different speeds to do 1.5
minute steady state throttle drives.
File:ltsvb.ex
Update:Tue Jun 20 16:56:22 1995

Index 363
Index
A
ABS warning light
(see Anti-lock brake system)....... 77
Accessory position on the ignition..... 60
Accessory power source,
power point outlet.......... 148
Additives, engine oil.......... 291
Air bag supplemental restraint system
description............... 25
disposal................ 32
driver air bag............. 25
indicator light............. 81
operation............... 27
proper seating............. 27
service and information labels...... 32
tone generator............. 29
wearing safety belts........... 26
Air conditioning, manual heating and air
conditioning system........... 90
Alarm, activating remote personal.... 122
Alcohol, in fuel............. 285
Ambulance packages........... 5
Antifreeze (see Engine coolant)...... 295
Anti-lock brake system (ABS)
description.............. 204
noise................ 205
see also Brake............ 203
warning light.............. 77
Assistance (see Customer assistance) . . . 255
Audio system
(see Electronic sound system)..... 149
Automatic transmission, fluid, refill capacities 344
Automatic transmission
driving an automatic overdrive.... 175
fluid, adding............. 315
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995

364 Index
Automatic transmission (continued)
fluid, checking............ 314
fluid, specification........... 347
Axle
lubricant specifications......... 347
traction lok............212, 305
B
Backing up............... 178
Basic vehicle warranty........... 4
Battery
acid, treating emergencies.....237, 312
battery saver............. 125
charging system warning light...... 81
how to service............ 311
jumping a disabled battery....... 237
maintenance-free........... 311
proper disposal, recycling....... 312
replacement, specifications....... 346
voltage gauge.............. 82
when storing your vehicle....... 352
Brake fluid
brake warning light........... 76
specifications............. 319
Brakelamp, high-mount brakelamp . . 101, 336
Brakes
adjustment.............. 203
anti-lock............... 204
anti-lock brake system (ABS)
warning light............. 77
applying the brakes.......... 207
brake warning light........... 76
fluid, checking and adding....... 318
fluid, refill capacities......... 344
fluid, specifications.......... 319
front disc............... 203
if brakes do not grip well....... 206
new brake linings............ 7
parking............... 208
stopping distances........... 207
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995

368 Index
Electrical system (continued)
power point outlet.......... 148
Electronic sound system
radio reception............ 171
tuning the radio.........151, 165
warranty and service information.... 174
Electronic stereo cassette radio
(see Electronic sound system)..... 163
Electronic stereo radio (see Electronic
sound system)............ 163
Emergencies, roadside
assistance............... 255
battery acid spills.........237, 313
jump-starting............. 237
towing................ 251
Emergency brake (parking brake)..... 208
Emission control system, catalytic
converter............... 339
Engine
check engine warning light....... 78
fuel injected engine, starting....... 63
fuel pump shut-off switch........ 69
preparing to start............ 64
service points............. 279
starting............... 59,65
starting after a collision......... 69
storing your vehicle.......... 352
Engine block heater............ 68
Engine coolant
checking and adding......... 295
checking hoses............ 299
disposal...........294, 298, 315
preparing for storage......... 352
proper solution............ 297
recovery reservoir........... 296
refill capacities............ 344
specifications............. 298
Engine coolant temperature gauge,
description............... 85
File:ltixb.ex
Update:Fri Jun 9 15:21:14 1995