1996 FORD AEROSTAR ignition

237
*
[RE15100(ALL)05/95]
RWARNING
Make sure the spare tire and jacking
equipment are stowed and secured in the
proper storage location.
%*
[RE15200(ALL)03/95]
Preparing to Change the Tire
*
[RE15250(ALL)12/91]
NOTE: To lift your vehicle by other than the
front or rear jacking points, be sure to
use only hoist adapters with a wide
contact surface.
*
[RE15325(ALL)03/95]
1. Make sure that your vehicle will not move
or roll. Put the gearshift in P (Park). Set the
parking brake and block the wheel that is
diagonally opposite the tire that you are
changing.
*
[RE15335(ALL)12/91]
NOTE: Make sure the ignition is in the OFF
position.
*
[RE15420(ALL)06/95]
When one of the back wheels is off the ground,
the transmission alone will not prevent the
vehicle from moving or slipping off the jack,
even if the vehicle is in P (Park). To prevent the
vehicle from moving when you change a tire, be
sure the parking brake is set, then block the
wheel (both directions) that is diagonally
opposite (other side and end of the vehicle) to
the tire being changed.
*
[RE15430(ALL)05/95]
RWARNING
If the vehicle slips off the jack, you or
someone else could be seriously injured.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

243
*
[RE24375(ALL)03/95]
If the Engine Cranks But Does
Not Start or Does Not Start After
a Collision
*
[RE24400(ALL)07/95]
The Fuel Pump Shut-off Switch
*
[RE24500(ALL)07/95]
If the engine cranks but does not start or if you
have had a collision, the fuel pump shut-off
switch may have been triggered. The shut-off
switch is a device that stops the fuel pump
when your vehicle has been involved in a
substantial jolt.
*
[RE24600(ALL)07/95]
For information on how to check and reset the
fuel pump shut-off switch, seeFuel pump shut-off
switchin the Index.
%
*
[RE24700(ALL)05/95]
Towing Your Vehicle
[RE24750(ALL)08/95]
The recommended method to tow your Aerostar
is with flatbed or wheel lift equipment.
However, slingbelt towing is acceptable. On
vehicles equipped with an under-vehicle spare
tire carrier, remove the tire assembly from the
carrier and store it in a secure area before
towing. For E-4WD vehicles, the 4-wheel drive
system must be disabled prior to towing. The
transmission must be in N (Neutral) and the
ignition switch must be in the OFF position to
disable the Electronic 4-Wheel Drive System.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

267
*
[SV02100(ALL)08/95]
q
Never get under a vehicle while it is
supported only by a jack. If you must work
under a vehicle, use safety stands.
*
[SV02200(ALL)06/95]
q
Keep all lit cigarettes and other smoking
materials away from the battery and all
fuel-related parts.
*
[SV02500(ALL)03/95]
If you disconnect the battery, the engine must
ªrelearnº its idle conditions before your vehicle
will drive properly. To find out how the engine
does this, seeBatteryin this chapter.
*
[SV02600(ALL)03/95]
Working with the engine off:
*
[SV02650(ALL)03/95]
1. Set the parking brake fully and make sure
that the gearshift is securely latched in P
(Park).
*
[SV02700(ALL)06/95]
2. Remove the key from the ignition after you
turn the engine off.
*
[SV02725(ALL)06/95]
3. Block the wheels. This will prevent your
vehicle from moving unexpectedly.
*
[SV02750(ALL)03/95]
Working with the engine on:
*
[SV02785(ALL)03/95]
1. Set the parking brake fully and make sure
that the gearshift is securely latched in P
(Park).
*
[SV02800(ALL)03/95]
2. Block the wheels. This will prevent your
vehicle from moving unexpectedly.
*
[SV02900(ALL)02/95]
RWARNING
Do not start your engine with the air
cleaner removed and do not remove it
while the engine is running.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

293 [SV24450(ALL)12/91]
one third page art:0020362-B
Liftgate window washer reservoir
%*
[SV24500(ALL)03/95]
Wiper Blades
*
[SV24600(ALL)03/95]
Check the windshield wiper blades at least twice
a year. Also check them whenever they seem
less effective than usual. Substances such as tree
sap and some hot wax treatments used by
commercial car washes reduce the effectiveness
of wiper blades.
*
[SV24700(ALL)03/95]
If the blades do not wipe properly, clean both
the windshield and the wiper blades. Use
undiluted windshield washer solution or a mild
detergent. Rinse thoroughly with clear water. Do
not use fuel, kerosene, paint thinner, or other
solvents to clean your wiper blades. These will
damage your blades.
*
[SV24800(ALL)03/95]
To make reaching the wiper blades easy, simply
turn the ignition to the ACC position and turn
your wipers on. Wait for them to reach a
vertical position and turn the ignition to the OFF
position. Do not move the wipers manually.
Manually moving the wipers across the
windshield may damage them.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

331
%*
[SV48600(ALL)03/95]
Emission Control System
*
[SV48700(ALL)05/95]
Your vehicle is equipped with a catalytic
converter which enables your vehicle to comply
with applicable exhaust emission requirements.
*
[SV48800(ALL)05/95]
To make sure that the catalytic converter and the
other emission control parts continue to work
properly:
*
[SV48900(ALL)01/95]
q
Use only unleaded fuel.
*
[SV49000(ALL)01/95]
q
Avoid running out of fuel.
*
[SV49100(ALL)01/95]
q
Do not turn off the ignition while your
vehicle is moving, especially at high speeds.
*
[SV49200(ALL)03/95]
q
Have the services listed in yourMaintenance
Schedule and Recordbooklet performed
according to the specified schedule.
*
[SV49300(ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[SV49400(ALL)05/95]
RWARNING
On vehicles without original equipment
floor covering or insulation, do not let
passengers ride in your truck in a manner
that allows contact between skin and the
metal floor.
*
[SV49500(ALL)05/95]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

Index 359
Index
A
Accessory position on the ignition..... 61
Additives, engine oil.......... 282
Air bag supplemental restraint system . . . 26
and child safety seats.......... 34
description............. 26,28
disposal................ 32
driver air bag........... 26,28
indicator light............. 81
operation............... 28
proper seating............. 27
service and information labels...... 28
tone generator............. 31
wearing safety belts........... 27
Air cleaner filter
location............... 269
specifications............. 337
Air conditioning
auxiliary heater and air conditioner . . . 98
manual heating and air conditioning
system............... 92
Alcohol, in fuel............. 277
Antenna, radio
(see Electronic sound system) . . . 149, 182
Antifreeze (see Engine coolant)...... 284
Anti-lock brake system (ABS)
description.............. 193
see also Brake............ 193
Appeals (see Dispute settlement board) . . 248
Assistance (see Customer assistance) . . . 245
Audio system
(see Electronic sound system)..... 149
Autolamp system (see Headlamps) . . 102, 104
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

362 Index
Changing a tire............. 229
Charging system gauge.......... 82
Charging system warning light....... 81
Child safety restraints........... 32
built-in child seat............ 48
child safety belts............ 58
child safety seats............ 34
Child safety seats............. 34
attaching with tether straps....... 46
automatic locking mode (retractor) . . 15, 34
built-in child seat............ 48
in front seat.............. 34
in rear outboard seat.......... 34
in rear seat............... 34
tether anchorage hardware........ 46
Chime
headlamps on.............. 84
key in ignition............. 62
safety belt............... 77
Circuit breakers
checking and replacing........ 322
see also fuses............. 313
Cleaning your vehicle
built-in child seat............ 57
CD player and discs.......... 160
chrome and aluminum parts....... 9
engine compartment.......... 272
exterior................ 8
exterior lamps............ 102
fabric................ 142
headlamps.............. 102
instrument panel............ 91
instrument panel lens......... 108
interior lamps............. 105
mirrors................ 144
plastic parts.............. 9
polishing................ 8
rear windows............. 100
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

Index 369
H
Hazard flashers............. 113
Headlamps
aiming................ 322
autolamp system........... 102
checking alignment.......... 323
cleaning............... 102
daytime running lights........ 104
flashing............... 110
high beam.............. 110
replacing bulbs............ 322
turning on and off.......... 101
warning chime............. 84
Heating
heating and air conditioning system . . . 92
rear seat controls............ 98
standard heater system......... 95
High beams.............. 110
indicator light............. 84
operation............101, 110
High-mount brakelamp, description.... 106
Hitch................. 218
Hood................. 268
latch location............. 268
lubrication specifications........ 338
release lever............. 268
working under the hood....... 266
Horn.................. 114
Hoses, checking............. 288
I
Identification Number, Vehicle (VIN).... 5
Idle
relearning.............. 305
speed................. 67
Ignition
chime................. 62
positions of the ignition......... 61
removing the key............ 62
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995