1996 FORD AEROSTAR flat tire

241
*
[RE21400(ALL)06/95]
2. Remove the lug nuts with the lug nut
wrench.
*
[RE21500(ALL)06/95]
3. Replace the flat tire with the spare tire.
*
[RE21700(ALL)06/95]
4. Thread the lug nuts on the wheel studs with
the beveled face toward the wheel. Use the
lug nut wrench to screw the lug nut snug
against the wheel but do not tighten.
*
[RE22200(ALL)01/95]
5. Lower the vehicle by turning the jack handle
counterclockwise.
*
[RE22300(ALL)06/95]
6. Remove the jack and fully tighten the lug
nuts in the order shown in the following
illustration.
%*
[RE22400(ALL)12/89]
quarter page art:0020312-B
Lug nut tightening sequence
*
[RE23400(ALL)05/95]
RWARNING
Use of wheels or lug nuts other than
original equipment could cause damage to
the wheel or mounting system and allow
the wheels to come off while the vehicle
is in motion.
*
[RE23500(ALL)07/95]
7. Replace any wheel covers, ornaments, or hub
caps that your vehicle has. Make sure that
they are screwed or snapped into place.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

242 [RE23625(ALL)06/95]8. Put the tire, jack, and wrench away. Make
sure jack is securely fastened so it doesn't
rattle when you drive. The carrier is
designed to hold the temporary spare which
comes with your vehicle. The stowage of a
full size tire in the spare tire carrier may
damage the tire or the vehicle. The flat full
size tire should be stowed securely in the
vehicle until it can be repaired.
*
[RE23700(ALL)06/95]
9. Unblock the wheels.
*
[RE23800(ALL)06/93]
Retighten the wheel lug nuts to the specified
torque at 500 miles (800 km) of new vehicle
operation and at intervals specified in the
Maintenance Schedule and Recordbooklet.
*
[RE24200(ALL)10/89]
Also retighten to the specified torque at 500
miles (800 km) of operation after any wheel
change or any time the lug nuts are loosened.
*
[RE24301(ALL)05/95]
RWARNING
Failure to retighten wheel lug nuts at
mileages specified could allow wheels to
come off while the vehicle is in motion.
[RE24315(ALL)02/89]
eight pica chart:0020313-AFile:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

243
*
[RE24375(ALL)03/95]
If the Engine Cranks But Does
Not Start or Does Not Start After
a Collision
*
[RE24400(ALL)07/95]
The Fuel Pump Shut-off Switch
*
[RE24500(ALL)07/95]
If the engine cranks but does not start or if you
have had a collision, the fuel pump shut-off
switch may have been triggered. The shut-off
switch is a device that stops the fuel pump
when your vehicle has been involved in a
substantial jolt.
*
[RE24600(ALL)07/95]
For information on how to check and reset the
fuel pump shut-off switch, seeFuel pump shut-off
switchin the Index.
%
*
[RE24700(ALL)05/95]
Towing Your Vehicle
[RE24750(ALL)08/95]
The recommended method to tow your Aerostar
is with flatbed or wheel lift equipment.
However, slingbelt towing is acceptable. On
vehicles equipped with an under-vehicle spare
tire carrier, remove the tire assembly from the
carrier and store it in a secure area before
towing. For E-4WD vehicles, the 4-wheel drive
system must be disabled prior to towing. The
transmission must be in N (Neutral) and the
ignition switch must be in the OFF position to
disable the Electronic 4-Wheel Drive System.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

245
Customer Assistance
%*
[HS00205(ALL)06/94]
Roadside Assistance
*
[HS00210(ALL)08/95]
Ford Motor Company has set up a 24-hour,
seven-day-a-week hotline with trained operators
who put you in touch with the help you need if
you experience a problem with your vehicle.
This complimentary service is provided to you
throughout your warranty period of 3 years or
36,000 miles (60,000 km), whichever comes first.
To purchase Roadside Assistance coverages
beyond this period (available through Ford Auto
Club in the United States or Ford and
Lincoln-Mercury dealers in Canada), contact
your Ford or Lincoln-Mercury dealer.
*
[HS00215(ALL)06/94]
Roadside Assistance will cover the following:
*
[HS00220(ALL)06/94]
q
Mount your spare if you have a flat tire.
*
[HS00225(ALL)06/94]
q
Jump-start your battery if it is dead.
*
[HS00230(ALL)06/94]
q
Unlock your vehicle if you are locked out.
*
[HS00235(ALL)06/94]
q
Bring you fuel if you run out.
*
[HS00240(ALL)06/94]
q
Tow your vehicle if you are stranded. Even
non-warranty related tows, like accidents or
getting stuck in mud or snow, are covered
(some exclusions apply, such as impound
towing and repossession).
File:13cphsa.ex
Update:Tue Aug 29 17:46:53 1995

281
*
[SV12225(ALL)08/95]
4. Use these equations to calculate your fuel
economy:
*
[SV12250(ALL)08/95]
q
English: MPG = (total miles driven)v
(gallons used)
[SV12275(ALL)08/95]
q
Metric: L/100k = (100 x liters used)v(total
kilometers driven)
%*
[SV12300(ALL)08/95]
Comparisons With Environmental
Protection Agency (EPA) and Transport
Canada (TC) Fuel Economy Estimates
*
[SV12400(ALL)08/95]
EPA and TC fuel economy figures are obtained
from laboratory tests under simulated road
conditions and thus are estimates which may not
reflect the actual conditions you experience or
your personal style of driving. The EPA or TC
fuel economy estimate is not a guarantee that
you will achieve the fuel economy shown.
*
[SV12675(ALL)05/95]
The following decrease fuel economy:
*
[SV12720(ALL)08/95]
q
Lack of regular, scheduled maintenance
*
[SV12740(ALL)05/95]
q
Excessive speed
*
[SV12760(ALL)03/95]
q
Rapid acceleration
*
[SV12780(ALL)05/95]
q
Driving with your foot on the brake
*
[SV12820(ALL)05/95]
q
Sudden stops
*
[SV12840(ALL)05/95]
q
Extended engine idling
*
[SV12860(ALL)05/95]
q
Using speed control in hilly terrain
*
[SV12880(ALL)05/95]
q
Extended use of the A/C, defroster, rear
window defroster and other accessories
*
[SV12920(ALL)05/95]
q
Underinflated tires
*
[SV12940(ALL)05/95]
q
Heavy loads
*
[SV12960(ALL)05/95]
q
Aftermarket add-ons such as bike, ski or
luggage racks, bug deflectors, etc.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

294
*
[SV24900(ALL)03/01]
Wiper blade replacement
*
[SV25000(ALL)07/95]
If the wiper blades still do not work properly
after you clean them, you may need to replace
the wiper blade assembly or the blade element.
When replacing the wiper blade assembly, blade
refill, or wiper arm always use a Motorcraft part
or equivalent. To replace the blades, follow the
instructions that come with them.
%
*
[SV25200(ALL)03/95]
Tires
*
[SV25300(ALL)03/95]
Look at your tires each time you fill your fuel
tank. If one tire looks lower than the others,
check the pressure in all of them. Always follow
these precautions:
*
[SV25400(ALL)03/95]
q
Keep your tires inflated to the recommended
pressures.
*
[SV25500(ALL)02/95]
q
Stay within the recommended load limits (see
Load limitsin the Index).
*
[SV25600(ALL)02/95]
q
Make sure the weight of your load is evenly
distributed.
*
[SV25700(ALL)10/89]
q
Drive at safe speeds.
[SV25750(ALL)08/95]
q
Make sure the spare tire is mounted and
anchored properly in the tire carrier without
contacting functional parts such as brake
tubes, fuel lines, exhaust pipes, etc.
*
[SV25800(ALL)01/95]
If you do not take these precautions, your tires
may fail or go flat.
*
[SV25890(ALL)07/95]
Ford Motor Company recommends obeying
posted speed limits.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

295
*
[SV25900(ALL)05/95]
RWARNING
Driving too fast for conditions creates the
possibility of loss of vehicle control.
Driving at very high speeds for extended
periods of time may result in damage to
vehicle components.
%*
[SV26100(ALL)05/95]
At least once a month, check the pressure in all
your vehicle's tires, including the spare. Use an
accurate tire pressure gauge. Check the tire
pressure when tires are cold, after the vehicle
has been parked for at least one hour or has
been driven less than 3 miles (5 km). You can
find proper cold pressure and load limits of
recommended size tires on the Safety
Compliance Certification Label.
*
[SV26150(ALL)05/95]
RWARNING
Improperly inflated tires can affect vehicle
handling and can fail suddenly, possibly
resulting in loss of vehicle control.
%*
[SV26200(ALL)08/95]
Tire Inspection and Maintenance
*
[SV26300(ALL)02/95]
Inspect the tire treads, and remove stones, nails,
glass or other objects that may be wedged in the
tread grooves. Check for holes or cuts that may
permit air to leak from the tire, and make the
necessary repairs.
*
[SV26400(ALL)10/89]
Inspect the tire side walls for cuts, bruises and
other damage. If you suspect internal damage to
the tire, have it demounted and checked. You
may need to repair or replace it.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

366 Index
Engine coolant temperature gauge..... 85
Engine fan............... 266
Engine idle speed control......... 67
Engine knocking............. 276
Engine oil............... 282
checking and adding......... 283
dipstick............... 283
disposal............... 266
engine oil pressure gauge........ 83
filter, specifications.......... 337
refill capacities............ 335
specifications...........282, 338
synthetic oil............. 282
ªbreak-inº oils............. 7
viscosity............... 282
Entry system, illuminated........ 107
Exhaust fumes.............. 71
Extended Service Plan, Ford........ 4
F
Fan, engine fan, avoiding injury..... 266
Federal Communications Commission . . . 184
Federal Highway Administration
Regulation............... 6
Flashers, hazard............. 113
Flashing the lamps........... 110
Flat tire................. 229
Fluid refill capacities........... 335
Ford Customer Assistance Center..... 247
Ford Dispute Settlement Board...... 248
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 253
Ford of Canada Customer
Assistance Centre........... 253
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995