1996 FORD AEROSTAR air condition

277 %
*
[SV09300(ALL)08/95]
Fuel quality
*
[SV09450(ALL)06/95]
If you are experiencing starting, rough idle or
hesitation problems when the engine is cold, it
may be caused by fuel with low volatility. Try a
different brand of fuel. If the condition persists,
see your dealer or a qualified service technician.
*
[SV09455(ALL)08/95]
Using a high-quality fuel makes your vehicle
more responsive and maintains its good fuel
economy and emissions by:
*
[SV09460(ALL)08/95]
q
minimizing deposits in fuel injectors,
combustion chambers and on intake valves.
*
[SV09465(ALL)08/95]
q
assuring quick starting and smooth warm-up.
*
[SV09470(ALL)08/95]
q
protecting the fuel system from vapor lock in
very hot weather, which causes the engine to
hesitate or stall and makes restarts difficult.
*
[SV09475(ALL)08/95]
q
protecting your fuel system from rusting.
*
[SV09480(ALL)08/95]
q
preventing the fuel lines from freezing.
*
[SV09485(ALL)08/95]
q
preventing the fuel system from ªgumming
upº when your vehicle is not used for long
periods of time.
*
[SV09500(ALL)06/95]
It should not be necessary to add any
aftermarket products to your fuel tank if you
continue to use a high-quality fuel.
%*
[SV09600(ALL)04/95]
Gasolines for clean air
*
[SV09900(ALL)06/95]
Fuels in certain areas of the country are required
to contain oxygenates to improve air quality.
Common oxygenates are ethanol or grain alcohol
(blended at no more than 10%), methanol or
wood alcohol (blended at no more than 5% with
cosolvents and additives), and MTBE or methyl
tertiary butyl ether (blended at no more than
15%).
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

295
*
[SV25900(ALL)05/95]
RWARNING
Driving too fast for conditions creates the
possibility of loss of vehicle control.
Driving at very high speeds for extended
periods of time may result in damage to
vehicle components.
%*
[SV26100(ALL)05/95]
At least once a month, check the pressure in all
your vehicle's tires, including the spare. Use an
accurate tire pressure gauge. Check the tire
pressure when tires are cold, after the vehicle
has been parked for at least one hour or has
been driven less than 3 miles (5 km). You can
find proper cold pressure and load limits of
recommended size tires on the Safety
Compliance Certification Label.
*
[SV26150(ALL)05/95]
RWARNING
Improperly inflated tires can affect vehicle
handling and can fail suddenly, possibly
resulting in loss of vehicle control.
%*
[SV26200(ALL)08/95]
Tire Inspection and Maintenance
*
[SV26300(ALL)02/95]
Inspect the tire treads, and remove stones, nails,
glass or other objects that may be wedged in the
tread grooves. Check for holes or cuts that may
permit air to leak from the tire, and make the
necessary repairs.
*
[SV26400(ALL)10/89]
Inspect the tire side walls for cuts, bruises and
other damage. If you suspect internal damage to
the tire, have it demounted and checked. You
may need to repair or replace it.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

332
*
[SV49600(ALL)01/95]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
*
[SV49700(ALL)01/95]
By law, anyone who manufactures, repairs,
services, sells, leases, trades vehicles, or
supervises a fleet of vehicles is not permitted to
intentionally remove an emission control device
or prevent it from working. In some of the
United States and in Canada, vehicle owners
may be liable if their emission control device is
removed or is prevented from working.
*
[SV49800(ALL)02/92]
Never use a metal exhaust collector when you
service your vehicle. If the metal collector
contacts any of your vehicle's plastic trim or
bumper parts they could melt or deform.
*
[SV49900(ALL)01/95]
Do not drive your vehicle if it does not operate
properly. See your dealer if the engine runs on
for more than five seconds after you shut it off
or if it misfires, surges, stalls, or backfires.
%*
[SV50000(ALL)05/95]
Information about your vehicle's emission
control system is on the Vehicle Emission
Control Information decal located on or near the
engine. This decal identifies engine displacement
and gives some tune-up specifications.
%*
[SV50010(ALL)07/95]
Readiness for Inspection/Maintenance
Testing
*
[SV50020(ALL)07/95]
In some localities it may become a legal
requirement to pass an
Inspection/Maintenance (I/M) test of the
On-Board Diagnostic (OBD) II system. If the
vehicle's powertrain system or its battery has
just been serviced, the OBD II system is reset to
a not ready for I/M testing condition. To
prepare for I/M testing, the law specifies a
ªneed for additional mixed city and highway
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

333
driving to complete the checkº of the OBD II
system. As soon as all of the OBD II system
checks are successfully completed, the OBD II
system is set to the ready condition. The amount
of driving required to reach the ready condition
varies with individual driving patterns. To
complete this requirement in the minimum
amount of time, refer to the OBD II Drive Cycle
defined below. If the vehicle owner cannot or
does not want to do the additional driving
required by law, a service center can perform
this drive cycle as it would any other type of
repair work.
*
[SV50030(ALL)07/95]
OBD II Drive Cycle
*
[SV50040(ALL)06/95]
The following steps must be run in the order
shown. If any steps are interrupted, repeat the
preceding step. Any safe driving mode is
acceptable between steps.
*
[SV50050(ALL)06/95]
Always drive vehicle in safe manner according
to traffic conditions and obey all traffic laws.
[SV50055(ALL)08/95]
NOTE: When instructions read ªin drive,º use
the standard Overdrive gear. It is not
necessary to turn Overdrive off with
the OVERDRIVE OFF button. For more
information on Overdrive, refer to the
Automatic Overdrive Transmission
section of theDriving Your Aerostar
chapter.
*
[SV50060(ALL)07/95]
The engine must be warmed up and at
operating temperature before proceeding with
the drive modes of the following OBD II Drive
Cycle.
*
[SV50070(ALL)06/95]
1. Start the engine. Drive or idle (in neutral)
the vehicle for 4 minutes.
*
[SV50080(ALL)06/95]
2. Idle the vehicle in drive for 40 seconds.
*
[SV50090(ALL)07/95]
3. Accelerate the vehicle to 45 mph (70 km/h)
at 1/4 to 1/2 throttle for 10 seconds.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

Index 359
Index
A
Accessory position on the ignition..... 61
Additives, engine oil.......... 282
Air bag supplemental restraint system . . . 26
and child safety seats.......... 34
description............. 26,28
disposal................ 32
driver air bag........... 26,28
indicator light............. 81
operation............... 28
proper seating............. 27
service and information labels...... 28
tone generator............. 31
wearing safety belts........... 27
Air cleaner filter
location............... 269
specifications............. 337
Air conditioning
auxiliary heater and air conditioner . . . 98
manual heating and air conditioning
system............... 92
Alcohol, in fuel............. 277
Antenna, radio
(see Electronic sound system) . . . 149, 182
Antifreeze (see Engine coolant)...... 284
Anti-lock brake system (ABS)
description.............. 193
see also Brake............ 193
Appeals (see Dispute settlement board) . . 248
Assistance (see Customer assistance) . . . 245
Audio system
(see Electronic sound system)..... 149
Autolamp system (see Headlamps) . . 102, 104
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

Index 363
Cleaning your vehicle (continued)
rustproofing.............. 9
safety belts............... 23
tail lamps.............. 102
upholstery and interior trim...... 142
washing................ 8
waxing................ 8
wheels................ 303
windows............... 100
Climate control system.......... 91
air conditioning............ 92
heating only system........... 95
Clock...............155, 171
Clutch, specifications.......... 338
Cold engine starting............ 65
Combination lap and shoulder belts . . 11, 13
Compact disc player
(see Electronic sound system)..... 156
Compact disc radio
(see Electronic sound system)..... 150
Console, description........... 145
Controls
instrument panel............ 89
mirrors............... 144
steering column........... 109
Coolant (see Engine coolant)....... 284
checking and adding......... 284
drain and flush............ 289
preparing for storage......... 344
proper solution............ 286
refill capacities..........289, 335
specifications............. 338
temperature gauge........... 85
warnings............... 284
Cruise control (see Speed control).... 115
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

Index 369
H
Hazard flashers............. 113
Headlamps
aiming................ 322
autolamp system........... 102
checking alignment.......... 323
cleaning............... 102
daytime running lights........ 104
flashing............... 110
high beam.............. 110
replacing bulbs............ 322
turning on and off.......... 101
warning chime............. 84
Heating
heating and air conditioning system . . . 92
rear seat controls............ 98
standard heater system......... 95
High beams.............. 110
indicator light............. 84
operation............101, 110
High-mount brakelamp, description.... 106
Hitch................. 218
Hood................. 268
latch location............. 268
lubrication specifications........ 338
release lever............. 268
working under the hood....... 266
Horn.................. 114
Hoses, checking............. 288
I
Identification Number, Vehicle (VIN).... 5
Idle
relearning.............. 305
speed................. 67
Ignition
chime................. 62
positions of the ignition......... 61
removing the key............ 62
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995