1996 CHEVROLET TRACKER engine

I Short TriplCity Maintenance Schedule I
Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently if used off-road or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
I DATE I ACTUAL MILEAGE ISERVICED BY: I
93,000 Miles (155 000 km)
CI Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Sewice.
0 Inspect the locking front hubs (if equipped)
for correct operation
(or every 3 months,
whichever occurs first). Repair or replace
if necessary.
DATE
SERVICED BY: ACTUAL MILEAGE
'
ProCarManuals.com

I Short Trip/City Maintenance Schedule I
96,000 Miles (160 000 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and
Rotation’’ in the Index for proper rotation
pattern
and additional information. During
tire rotation, check brake calipers for
freedom
of movement. Refer to the
I 99,000 Miles (165 800 km)
0 Change engine oil and filter (or every
3 months, whichever occurs first).
An Emission Control Sewice.
17 Inspect the loclung front hubs (if equipped)
for correct operation (or every
3 months,
whchever occurs first). Repair or replace
if necessary.
appropriate
CM service manual for proper
caliper service procedures.
Inspect the locking front hubs (if equipped)
for correct operation (or every 3 months,
whchever occurs first). Repair or replace
if necessary.
DATE ACTUAL MILEAGE SERVICED BY SERVICED BY DATE ACTUAL MILEAGE -
7-30
ProCarManuals.com

Long Trip/Highway Maintenance Schedule
The services shown in this schedule up to 100,000 miles
(166 000 krn) should be performed after 100,000 miles
(166 000 km) at the same intervals.
Footnotes
The U.S. Environmental Protection Agency or the
California Air Resources Board has determined that the
failure to perform this maintenance item will not nullify
the emission
warranty or limit recall liability prior to the
completion of the vehicle’s useful life. We, however,
urge that all recommended maintenance services be
performed at the indicated intervals and the maintenance
be recorded.
7,500 Miles (12 500 km)
0 Change engine oil and filter (or every
7.5 months, whichever occurs first).
Rotate tires. See “Tire Inspection and
An Emission Control Service.
Rotation” in the Index for proper rotation
pattern
and additional information. During
tire rotation,
check brake calipers for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
0 Inspect the locking front hubs (if equipped)
for correct operation (or every 3 months,
whichever occurs first). Repair
or replace
7-32
ProCarManuals.com

Long TriplHighway Maintenance Schedule I
15,000 Miles (25 000 km)
Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and
Rotation”
in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom
of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
if necessary.
Inspect the valve lash and adjust if
necessary.
An Emission Control Service.
0 Check engine idle speed and adjust it to
underhood label specifications.
An Emission Control Service.?
0 Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently
if used off-road or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
DATE SERVICED BY ACTUAL MILEAGE
7-33
ProCarManuals.com

Long Trip/Highway Maintenance Schedule I
22,500 Miles (37 500 kmj
0 Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
Rotate tires. See “Tire Inspection and
Rotation’’ in the Index for proper rotation
pattern and additional infomation. During
tire rotation, check brake calipers for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
0 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs
first). Repair or replace
if necessarv.
30,000 Miles (50 000 kmj
0 Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
0 Clean and repack the front wheel bearings
(or at each brake relining, whichever
occurs first).
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
every
24 months, whichever occurs first).
An Emission Control Service.
0 Inspect engine accessory drive belts (or
7-34
ProCarManuals.com

I Long TriplHighway Maintenance Schedule I
Q Drain, flush and refill cooling system (or
every
30 months, whichever occurs first).
See “Engine Coolant” in the Index for
what to use. Inspect hoses. Clean radiator,
condenser, pressure cap and neck. Pressure
test the cooling system and pressure cap.
An Emission Control Service. 7
0 Replace spark plugs.
An Emission Control Service.
Replace air cleaner filter.
An Emission Control Service.
0 Inspect fuel tank, cap and lines for damage
or leaks. Inspect fuel cap gasket for any
damage. Replace parts as needed.
An Emission Control Service.
0 Change manual transmission fluid (or every
30 months, whxhever occurs first).
I7 Replace fuel filter (or every 30 months,
whichever occurs first, or sooner
if filter is
clogged).
An Emission Control Service.
17 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
if necessary.
0 Inspect the valve lash and adjust if
necessary.
An Emission Control Service.
(Continued)
7-35
ProCarManuals.com

1 Long Trip/Highway Maintenance Schedule
30,000 Miles (50 000 km) (Continued)
c] Check engine idle speed and adjust it to
underhood label specifications.
An Emission Control Service.?
0 Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently if used off-road or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
37,500 Miles (62 500 km)
0 Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
17 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional information. During
tire rotation, check brake calipers
for
freedom of movement. Refer to the
appropriate
GM service manual for proper
caliper service procedures.
0 Inspect the locking front hubs (if equipped)
for correct operation
(or every 3 months,
whichever occurs first). Repair
or replace
if necessarv.
I DATE I ACTUAL MILEAGE (SERVICED BY:(
7-36
ProCarManuals.com

1 Long Trip/Highway Maintenance Schedule I
45,000 Miles (75 000 km)
ll Change engine oil and filter (or every
7.5 months, whichever occurs first).
An Emission Control Service.
0 Rotate tires. See “Tire Inspection and
Rotation” in the Index for proper rotation
pattern and additional ,information. During
tire rotation, check brake calipers for
freedom of movement.
Refer to the
appropriate
GM service manual for proper
caliper service procedures.
0 Inspect the locking front hubs (if equipped)
for correct operation (or every
3 months,
whichever occurs first). Repair or replace
if necessary.
0 Inspect the valve lash and adjust if
necessary. An Emission Control Service.
0 Check engine idle speed and adjust it to
underhood label specifications.
An Emission Control Sewice.?
0 Inspect propeller shafts and u-joints for
looseness and damage (or every
15 months,
whichever occurs first). Inspect more
frequently
if used offlroad or for pulling
a trailer. Tighten u-joint flange bolts
if necessary.
DATE ACTUAL MILEAGE SERVICED BY:
7-37
ProCarManuals.com