1995 VOLKSWAGEN GOLF brake pads

6 -Glow plug*
the warning comes on when the key is turned to the
mediately .
As the
does not up. The engine can be started
right away.
When the engine is
warm, the not
come on.
7 -BRAKE or
comes on the is cranking. goes out after the eng1ne started and the parking brake is This is your assurance that the
brake warning is functioning
the brake warn ing when the engine is cranking or the park!ng
brake is
in the
or while you are the the brake fluid reservoir is too low.
Proceed immediately to the nearest
a u thorized Volkswagen dealer or
qualified workshop and have the
brake system inspected .
Please note, however , that after
several brake applications , greater
pressure on the brake
The brake wear indicator
the does not go
out , or if it driving , the
front brake pads are worn . See your
rized Volkswagen
dimmer
switch
-High beam
The indicator up when the high
beams are switched on or when the
flasher is used.
Refer to
dimmer
switch on page 78 for
71

Braking
General notes
automobiles are
still subject to wear depending largely on op­
erating conditions and driving habits. ve­hicles which are driven mostly in stop-and ­
go city traffic or which are driven hard, the brake linings should be checked by your au­
thorized authorized dealer
more often than specified in the Mainte­
nance booklet.
steep slopes you should use the
b raking effect of th e engine. T his way , you pr event wearing d ow n the brake s ystem . yo u must use your brakes , do not hold the brakes down contin uous ly. Pump the brakes in intervals.
Under certain conditions , for example,
when driving through water or a very heavy
rain , or even after washing your vehicle, the braking effect can be reduced due to the wet
brake pads or pads which are iced-up in the
winter. A few cautious brake applications
should dry off the brake pads or remove ice
coatings.
The effectiveness of the brakes can be reduced when the vehicle is driven on a salt ­
covered road and the brakes are not used.
Clean off accumulated
or if you sure the air
brake circuit impair the braking capability
resulting in an increased stopping distance .
Avoid driving the vehicle and have it towed to the nearest authorized
Volkswagen dealer or qualified
workshop.
Brake booster
WARNING
to a stop with
the engine shut off.
the brake booster is not working, for example when towing your vehicle, or because the brake booster
has somehow been damaged, the
brake pedal
must be pressed harder to make up for the missing effect of the brake booster.
Always heed

Conditions affecting braking
efficiency
Moisture or road salt
WARNING
dry and ice coatings
Driving for an extended period of time on salt-covered roads without using your brakes can also affect
braking efficiency. Clean off accumulated salt coating from brake discs and pads with a few cautious
brake applications. Overheating
the brak es
WARNING
the brakes " by resting your foot on the pedal when you do not intend to brake. This may cause
the brakes to overheat , premature
wear and increased stopping distance .
Before descending a steep grade,
reduce speed and shift transmission into a lower gear or lower driving position. Do not ride the brakes or hold the pedal down too long or too often . This could cause the brakes to get hot and diminish braking
efficiency .

Brake fluid
The brake fluid reservo ir is located in the en­
gi ne compa rtment o n th e left side .
136
----------------
Checking
The correct fluid level is importa nt for the
proper functioning of the brake system. The
fluid level
in the brake fluid reservoir should
always be between the and markings.
The fluid level may drop slightly
some
time due to the automatic adjustment of the
brake pads. This is no cause for alarm.
mark , the brake warning light come o n. Do not continue to operate the
v ehicle . The comp le te brake system shou ld
be thoroughly checked by an authoriz ed
Volk sw age n dea l
er or any other qualified
workshop and the cause corr ecte d.
The brake warning lamp lights up
to indicate
a low fluid leve l in the reservoir.
Use only 4 brake fluid that meets SAE specification J and conforms to Federal Motor Vehicle
Standard 116.
The brake
fluid must be new .
Do not add or mix
Brake fluid is poisonous. Therefore , it must only be stored in the closed original container out of the reach of children.
J

Service every
on page 4-
Emission Control Maintenance
Engine : Change
-filter : First replacement at
park/neutral safety switch (whe re
Brake pads: Check thickness (EuroVan and Diesel)
Whee ls: Rotate front
to rear
5

Vehicle Maintenance
Manual transmission : Check for
Battery : Check electrolyte add if necessary
Automatic transmission : Check
ATF1l
Automatic transmission ,
drive : Check
Check operation including neutral safety switch (where
Power steering: Check
Brake system : Check for damage and thickness of pads and brake
heating and ventilat ion syste ms, a ir conditioning and
power accessor i
es
On-board diagnosis : Check
Check condition and pressure
Water separator: Drain water (Diesel )
(
km, every ]
km and every 2 years regardless of (kilometers).
1 tra ffic conditions, it is necessary to change the ATF every be
7