1995 PONTIAC FIREBIRD cooling

1. You can remove the radiator pressure cap when the
cooling system, including the radiator pressure cap and upper radiator hose, is no longer hot.
Turn the
pressure cap slowly to the left until it first stops. (Don’t press down while turning the pressure cap.)
If you hear a hiss, wait for that to stop. A hiss means
there is still some pressure left.
2. Then keep turning the pressure cap, but now push
down as you
turn it. Remove the pressure cap. 3. After the engine cools, open the air bleed valves on
the heater return hose and water pump inlet.
5-27
ProCarManuals.com

Engine Coolant
The following explains your cooling system and how to
add coolant when it is low. If you have a problem with
engine overheating or if you need to add coolant to your
radiator, see “Engine Overheating” in the Index.
The proper coolant for your Pontiac will:
Give freezing protection down to -34°F (-37 O C).
Give boiling protection up to 262 “F ( 128 ” C).
Protect against rust and corrosion.
Help keep the proper engine temperature.
Let the warning lights work as they should.
What to Use
Use a mixture of one-half clean water (preferably
distilled) and one-half antifreeze that meets “GM
Specification
1825-M,” which won’t damage aluminum
parts.
You can also use a recycled coolant conforming to
GM Specification 1825-M with a complete coolant flush
and refill. If you use this mixture, you don’t need to add
anything else.
NOTICE:
If you use an improper coolant mix, your engine
could overheat and be badly damaged. The
repair cost wouldn’t be covered by your warranty.
Too much water in the mix can freeze
and crack the engine, radiator, heater core and
other parts.
I 6-30
ProCarManuals.com

NOTICE:
The wrong wheel can also cause problems with
bearing life, brake cooling,
speedometer/odometer calibration, headlamp
aim, bumper height, vehicle ground clearance,
and tire or tire chain clearance to the body and
chassis.
Used Replacement Wheels
Tire Chains
NOTICE:
If your Pontiac has P235/55R16, or P245/50ZR16
size tires, don’t use tire chains; they can dqpage
your vehicle.
If you have other tires, use tire chains only where
legal and only when you must. Use only
SAE
Class “S” type chains that are the proper size for
your tires. Install them on the rear tires and
tighten them as tightly
as possible with the ends
securely fastened. Drive slowly and follow the
chain manufacturer’s instructions.
If you can
hear the chains contacting your vehicle, stop and
retighten them.
If the contact continues, slow
down until
it stops. Driving too fast or spinning
the wheels with chains
on will damage your
vehicle.
6-55
ProCarManuals.com

Cleaning Your Convertible Top
NOTICE:
When using an automatic car wash, set your
heating or cooling system to “VENT” with the
fan speed set to the second highest speed. This
will prevent high pressure water from entering
around your top.
Your convertible top should be cleaned often. Use a
mild soap, lukewarm water and a soft brush. Don’t use
any harsh cleaners or bleaching agents on the top. They
can darnage the material.
When the top is really dirty, use a mild foam-type
cleaner. Use a cloth or sponge to remove the dirt.
Thoroughly rinse the top and dry it before lowering it.
A damp top causes wrinkles.
Aluminum Wheels (If So Equipped)
Your aluminum wheels have a protective coating similar
to the painted surface of your car. Don’t use strong
soaps, chemicals, chrome polish, abrasive cleaners
or
abrasive cleaning brushes on them because you could
damage this coating, After rinsing thoroughly, a wax
may be applied.
NOTICE:
If you have aluminum wheels, don’t use an
automatic car wash that has hard silicon carbide
cleaning brushes. These brushes can take the
protective coating
off your aluminum wheels.
Tires
To clean your tires, use a stiff brush with a tire cleaner.
When applying a tire dressing always take care to wipe
off any overspray or splash from painted surfaces.
Petroleum-based products may damage the paint finish.
6-62
ProCarManuals.com

5. PCM IGN: Powertrain Control Module; Fuel Pump
Re1ay;Theft Deterrent Module; Engine Mass Air
Flow Sensor (V8 Engine)
6. STOP/HAZARD: Brake Light/Cruise Release
Switch; Hazard Flasher
7. PWR ACCY: Power Door Locks; Power Mirrors;
Hatch Release Switch; Auxiliary Accessory Wire
8. COURTESY: Audio Alarm Module; Courtesy
Lamps: Console Compartment, Glove Box, Dome,
Trunk, Rear Courtesy, Rearview Mirror; Radio;
Theft Deterrent Module; SECURITY Indicator;
Hatch Release Relay; Keyless Entry Receiver
9. GAGES: Audio Alarm Module; Daytime Running
Lamps Module (Canada); Diagnostic Energy
Reserve Module; Instrument Cluster; Keyless Entry
Receiver; Brake Switch Assembly; Auxiliary
Accessory Wire
10. TAIL LTS: Exterior Lighting
11.
CIGAR/HORN: Cigarette Lighter; Horn Relay;
12. DEFOGBEATS: Power Seats; Rear Defogger
13.
IP DIMMER: Brightness Control
14.
WIPEWASH: Windshield Wipermasher
15. WINDOWS: Power Windows, Convertible Top
Data Link Connector
Switch (Circuit Breaker); Cooling Level Latching
Module
16. CRANK: Diagnostic Energy Reserve Module
17.
RADIO: Radio Amplifier; Steering Wheel Controls
ProCarManuals.com

Underhood Electrical Center
LJ
INJECTOR
D7.52 I INJECTOR I
Relays
B: Air Conditioning Compressor
C: Anti-Lock Brake System
D: Coolant Fan Number 1
E: Air Pump
F: Coolant Fan Number 2
G: Traction Control System
H: Fog Lamps
J: Cooling Fan Number 3
6-69
ProCarManuals.com

Capacities (Approximate)
The following approximate capacities are given in U.S.
and metric conversions.
Air Conditioning? See the refrigerant information label
under the hood.
Automatic Transmission
Drain and Refill .................. 10 pt. (4.7 L)*
VIN Engine Code S and K ....... 17.6 pt. (8.3 L)*
VIN Engine Code P ............ 21.6 pt. (10.2 L)*
VIN
Engine Code S
Overhaul
Cooling System
With Manual Transmission . . , . . 12.5 qt. (11.8 L)
With Automatic Transmission ... 12.3 qt. (11.6 L)
VIN Engine Code K
With Manual Transmission ..... 12.5 qt. (1 1.8 L)
With Automatic Transmission ... 12.3 qt. (11.6 L)
With Manual Transmission ..... 15.3 qt. (14.5 L)
With Automatic Transmission ... 15.1 qt. (14.3 L)
VIN Engine Code P
Crankcase
Without Filter Change ........... 4.0 qt. 1 (3.8 L)**
With Filter Change ............. 5.0 qt. (4.7 L)**
Fuel Tank ...................... 15,5 gal. (58.7 L)
Manual Transmission
Five-Speed
.................... 5.9 pt. (2.8 L)*
Six-Speed ..................... 8.0 pt. (3.8 L)*
Rear Axle Lubricant ................. 3.5 pt. (1.7L)
? Not all air conditioning refrigerants are the same. If the
air conditioning system in your vehicle needs refrigerant,
be sure the proper refrigerant is used.
If you’re not sure,
ask your Pontiac dealer.
* Recheck fluid level after filling. See “Automatic
Transmission Fluid” or “Manual Transmission Fluid”
in the Index.
** Recheck the oil level after filling. See “Engine Oil” in
the Index.
6-73
ProCarManuals.com

Maintenance Schedule
Schedule I Definition
Follow Maintenance Schedule I if any one of these is
true for your vehicle:
0 Most trips are less than 5 to 10 miles (8 to 16 km).
This is particularly important when outside
temperatures are below freezing.
Most trips include extensive idling (such as frequent
driving in stop-and-go traffic).
Most trips are through dusty areas.
0 You frequently tow a trailer or use a carrier on top of
Schedule I should also be followed if the vehicle is used
for delivery service, police, taxi, or other commercial
application.
your car.
Schedule I Intervals
Every 3,000 Miles (5 000 km) or 3 Months
Engine Oil and Filter Change
Every 6,000 Miles (10 000 km) or 6 months
Chassis Lubrication
At 6,000 Miles (10 000 km) - Then Every
12,000 Miles
(25 000 km)
Every 7,500 Miles (12 500 km)
At 7,500 Miles (12 500 km)
Every 15,000 Miles (25
000 km)
Tire Rotation
Rear Axle Fluid Change (Vehicles Towing Trailers)
Rear Axle Fluid Change (Limited Slip Differential)
Air Cleaner Filter Inspection, if driving in dusty conditions
Automatic Transmission Service (severe conditions)
Every 30,000 Miles (50 000 km)
Air Cleaner Filter Replacement
Spark Plug Replacement (Except 5.7L Code
P engine)
Spark Plug Wire Inspection
Fuel Tank, Cap and Lines Inspection
Engine Accessory Drive Belt Inspection (or every
Cooling System Service (or every 24 months)
Spark Plug Replacement
(5.7L Code P engine only)
Automatic Transmission Service (normal conditions)
24 months)
Every 100,000 Miles (166 000 km)
7-4
ProCarManuals.com