1995 CHEVROLET CAVALIER brakes

Downloaded from www.Manualslib.com manuals search engine Parking Brake and Automatic "ransaxle PARK (P)
Mechanism Check
Park on a fairly steep hill, with the vehicle facing
downhill. Keeping your foot on the regular brake, set the
parking brake.
To check the parking brake: With the engine running
and transaxle in NEUTRAL
(N), slowly remove foot
pressure from the regular brake pedal.
Do this until
the vehicle is held by the parking brake only.
0 To check the PARK (P) mechanism's holding ability:
Shift to
PARK (P). Then release all brakes.
Underbody Flushing
At least every spring, use plain water to flush any
corrosive materials from the underbody. Take care to
clean thoroughly any areas where mud and other debris
can collect.
7-41

Downloaded from www.Manualslib.com manuals search engine Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your
GM dealer’s
service department or other qualified service center do
these
jobs. Make sure any necessary repairs are
completed at once.
Restraint Systems
Now and then, make sure all your belts, buckles, latch
plates, retractors, anchorages and reminder systems are
working properly. Look for any loose parts or damage.
If you see anything that might keep a restraint system
from doing its job, have it repaired.
Steering, Suspension and Front-Wheel-Drive
Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs
of
wear, or lack of lubrication. Inspect the power steering
lines and hoses for proper hookup, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body near
the exhaust system.
Look for broken, damaged, missing or
out-of-position
parts as well as open seams, holes, loose
connections, or other conditions which could cause a heat
build-up in the floor pan or could let exhaust fumes into
the vehicle. See “Engine Exhaust”
in the Index.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding, and f\
or
damaged or missing parts. Replace parts
as needed.
Accelerator and cruise control cables should not
be lubricated.
Manual Transaxle
Check the transaxle fluid level; add if needed. See
“Manual Transaxle” in the Index.
A fluid loss may
indicate a problem. Check the system and repair
if needed.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hookup, binding, leaks, cracks, chafing,
etc. Inspect disc brake pads for wear and rotors for
surface condition.
Also inspect drum brake linings for
wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc.
Check parking brake adjustment.
You may need to have
your brakes inspected more often if your driving habits
or conditions result in frequent braking.
7-42
~

Downloaded from www.Manualslib.com manuals search engine 0 Section 9 Index
Adding Automatic Transaxle Fluid
................ 6- 18. 6- 19
BrakeFluid ................................. 6-27
Electrical Equipment
.......... 2-1 1 , 2- 12, 3- 12, 6-5 1
Engine Coolant ......................... 5- 16, 6-22
Engineoil
.................................. 6-11
Hydraulic Clutch Fluid ........................ 6-20
Manual Transaxle Fluid
....................... 6- 19
Power Steering Fluid ......................... 6-24
SoundEquipment
............................ 3-12
Windshield Washer Fluid
................. 2-32, 6-25
AirBag
....................................... 1-18
How Does
it Restrain ......................... 1-22
Howitworks
............................... 1-20
Location
................................... 1-20
Servicing
................................... 1-24
What Makes
it Inflate ......................... 1-22
What Will You See After it inflates .............. 1-22
When Should
it Inflate ........................ 1-2 1
Air Bag Readiness Light .................... 1-20, 2-61
Aircleaner
.................................... 6-15
Air Conditioning ................................ 3-2
Air Conditioning Compressor Button
................ 3-2
Alignment and Balance, Tires
..................... 6-39
Aluminum Wheels, Cleaning ...................... 6-48
Antenna. Fixed Mast ............................ 3-14
Anti-Lock Brake System Warning Light
......... 2.63. 4.6
Anti-Lock Brakes
............................... 4-6
Anti-Theft Feature.
CD Player .................... 3-10
Antifreeze ..................................... 6-21
Adding
............................... 5.16. 6.22
Checking
................................... 6-23
Appearance Care
............................... 6-42
Appearance Care and Materials
.................... 6-50
Ashtray and Lighter ............................. 2-44
Audiosystems
.................................. 3-5
Auto Down Feature
............................. 2-27
Automatic Transaxle.
Four Speed
Automatic Overdrive
......................... 2-17
First(1)
.................................... 2-18
Neutral
(N) ................................. 2-15
Park(P) .................................... 2-14
Reverse(R)
................................. 2-15
Second(2)
.................................. 2-16
Shifting
.................................... 2-14
Third (3)
................................... 2-17
Drive(D)
................................... 2-16
First(1)
.................................... 2-16
Neutral (N)
................................. 2-15
Automatic Transaxle. Three Speed
9-1

Downloaded from www.Manualslib.com manuals search engine Park(P) .................................... 2-14
Reverse(R)
................................. 2-15
Second(2)
.................................. 2-16
Shifting
.................................... 2-14
Automatic Transaxle Fluid ................... 6- 16. 6- 19
Adding
............................... 6- 18. 6- 19
Checking .............................. 6.16. 6.19
Battery.
LOW Maintenance ....................... 6-29
Battery Rundown Protection
...................... 2-4 1
Battery Warnings ............................ 5.2. 5.4
BBB Auto Line
................................. 8-3
Brake Adjustment
.............................. 6-28
Brake Fluid. Adding
............................. 6-27
Brake Master Cylinder
........................... 6-26
BrakePedalTravel
.............................. 6-28
Brake System Parts. Replacing
.................... 6-28
Brake System Warning Light
...................... 2-62
Brake-Transaxle Shift Interlock
............... 2-24. 7-40
BrakeWear
.................................... 6-27
Brake. Parking
................................. 2-21
Brakes. Anti-Lock
............................... 4-6
Brakes. Trailer
................................. 4-33
Braking
........................................ 4-5
Braking
in Emergencies ........................... 4-8
BTSI (Brake-Transaxle Shift Interlock)
......... 2-24. 7-40
Bulbs, Replacement
............................. 6-56
Headlamps
................................. 6-29
Taillamps
................................... 6-31 Canadian
Roadside Assistance
.................... 8-8
Capacities and Specifications ...................... 6-55
Carbon Monoxide .................... 2.25.4.25. 4.33
Cassette Tape Player Care
........................ 3-13
CDErrors
...................................... 3-9
CD Player Anti-Theft Feature
..................... 3- IO
Center Console Compartment ..................... 2-46
Center Passenger Position
........................ 1-31
Certification/TIre Label
.......................... 4-28
Chains. Safety
................................. 4-33
Chains. Tire
................................... 6-41
Changing a Flat Tire
............................. 5-20
Charging System Light
.......................... 2-66
Check Engine Light
............................. 2-68
Check Gages Light
.............................. 2-64
CheckOilLight
................................ 2-66
Checking Automatic Transaxle Fluid
................ 6- 16. 6- 19
BrakeFluid ................................. 6-26
Enginecoolant
.............................. 6-23
Engineoil
.................................. 6-10
Hydraulic Clutch Fluid
........................ 6-20
Manual Transaxle Fluid
....................... 6-19
Power Steering Fluid
......................... 6-24
Things Under the Hood
........................ 6-6
Checking Your Restraint Systems
.................. 1-45
Chemical Paint Spotting
.......................... 6-49
Child Restraints
................................ 1-34
Securing
in a Rear Outside Seat Position .......... 1-36
Securing
in the Center Rear Seat Position ......... 1-38
Securing
in the Right Front Seat Position .......... 1-40
9-2

Downloaded from www.Manualslib.com manuals search engine Fuel .................
Fuel Gage .............
Fuel. Filling Your Tank . .
Fuel. In Foreign Countries
Fuse Block. Inside Vehicle
Fuse Block. Under Hood
.
Fuses and Circuit Breakers
......................... 6-4
......................... 6-4
........................ 6-53
........................ 6-54
....................... 6-52
Gages
Y Engine Coolant Temperature ................... 2-64
Fuel
....................................... 2-67
Gasolines for Cleaner
Air ......................... 6-3
GAWR (Gross Axle Weight Rating)
................ 4-29
GearPositions
................................. 2-14
Glass, Cleaning
................................ 6-45
GVWR (Gross Vehicle Weight Rating)
.............. 4-29
Halogen Bulbs
................................ 6-29
Hazard Warning Flashers
.......................... 5- 1
Head Restraints ................................. 1-4
Headlamp High-Low Beam Changer ............... 2-30
Headlamp. Wiring
.............................. 6-54
Headlamps
.................................... 2-37
Headlamps. Bulb Replacement
.................... 6-29
Hearing or Speech Impaired. Customer Assistance
...... 8-2
Heating
........................................ 3-3
Heritage Pages
................................... 111
High Beam Lamps. How to Change ................ 2-30
Highway Hypnosis
.............................. 4-20
...
Hill and Mountain Roads ......................... 4-20
Hitches. Trailer
................................. 4-33
HoodProp
..................................... 6-7
Hood Release ................................... 6-6
Horn
......................................... 2-28
Hydraulic Clutch
............................... 6-20
Adding Fluid
................................ 6-20
Checking Fluid
.............................. 6-20
Hydroplaning
.................................. 4-16
If You’re Stuck: In Sand. Mud. Ice or Snow ......... 5-28
Ignition Key Positions
............................ 2-8
Ignition Switch
.................................. 2-8
Illuminated Entry
............................... 2-41
Inside Daymight Rearview Mirror
................. 2-42
Inside Vehicle Fuse Block
........................ 6-53
Inspections Brakesystem
............................... 7-42
Manual Transaxle
............................ 7-42
Restraint Systems
............................ 7-42
Steering. Suspension and Frt-Whl-Drive Axle Boot and
Seal
...................................... 7-42
InstrumentPanel
............................... 2-56
Instrument Panel Clusters
........................ 2-58
Gagecluster ................................ 2-59
Standard Cluster
............................. 2-58
Instrument Panel Intensity Control
................. 2-38
Instrument
Panel. Cleaning ....................... 6-45
Exhaust
Systems
............................. 7-42
Throttle Linkage
............................. 7-42
9-5

Downloaded from www.Manualslib.com manuals search engine Tachometer .................................. 2-60
Taillamps. Bulb Replacement
..................... 6-3 1
Tamper Resistant Odometer ....................... 2-59
TapePlayerCare
............................... 3-13
Theft
.......................................... 2-6
Theft Deterrent. Passlock
.......................... 2-7
Thermostat
.................................... 6-24
Third
(3). 4 Speed Automatic Transaxle ............. 2- 17
Third Gear. Manual Transaxle
..................... 2- 19
Tilt Steering Wheel
............................. 2-28
Time. Setting the
................................ 3-5
Tire Chains
.................................... 6-41
Tire Inspection and Rotation
...................... 6-35
TireLoading
................................... 4-28
Tires
.................................... 5-20. 6-33
Alignment and Balance
........................ 6-39
BuyingNew
................................ 6-37
ChangingaFlat
.............................. 5-20
Compact Spare .............................. 5-27
Inflation .................................... 6-34
Inspection and Rotation
....................... 6-35
Temperature
................................ 6-39
Traction
.................................... 6-38
Treadwear
.................................. 6-38
Uniform Quality Grading
...................... 6-38
Wear Indicators
.............................. 6-36
Wheel Replacement
......................... 6-40
When It’s Time for New
....................... 6-36 Top
Strap
..................................... 1-35
TorqueLock ................................... 2-24
Torque. Wheel
Nut ......................... 5.25. 6.55
Towing
a Trailer ........................... 4.30. 4.36
Towing Your Vehicle
............................. 5-7
Towing. Front ................................... 5-9
Towing. Rear .................................. 5-11
Towing. Recreational Vehicle
..................... 4-26
Trailer
Brakes
.................................... 4-33
Driving on Grades ............................ 4-35
DrivingWitha
.............................. 4-34
Hitches
.................................... 4-33
Maintenance When Towing
a ................... 4-36
Parking on Hills
............................. 4-35
Safety Chains
............................... 4-33
Total Weight on Your Vehicle’s Tires
............. 4-33
Towinga
.............................. 4-30. 4-36
Turn Signals
................................ 4-35
Weightof
................................... 4-32
Trailer Tongue. Weight
of ........................ 4-32
Transaxle Fluid
Checking
.............................. 6-16. 6.19
Manual
.................................... 6-19
Trip Odometer ................................. 2-60
Trunk Release. Remote
........................... 2-5
Turn Signal and Lane Change Indicator ............. 2-29
Turn SignalMultifunction Lever
................... 2-28
Turn Signals When Towing
a Trailer ................ 4-35
9-10