1994 VOLKSWAGEN GOLF brake

Fuse arrangement from
15
11 -H igh beam,
12-High beam , right ............... .
164 N
o.
Amp
13-Horn ..........................
14 -Back -up lights ......... 15
15
-En g ine e lectro nic s ..... .........
16-Power sunroof , front map/
reading light ................. .. 15
17 -Emergency flashers . . . . . . . . . . . . . 1
19-Radiator fan, A/C ...............
-Brake lights ....................
21 -Dome and luggage compartment
lights, c igarette li ghter , ..... 15
22 -Radio, cigarette lighter ,
luggage compartment release . . . . 1
fuses
(located above the relays) Amp
Fuse for
Fuse for
Fuse for A/C ....................
the engine compartment above the brake
booster:
plugs 1 l ...
Co lor codes:
light brown :
........ 5 ampere
red: .............. . ampere
blue: ..... 15 ampere

Before a switch off the re­
spective circuit.
Do not touch the part of the new bare fingers. Fingerprints evaporate when the gets hot, th e
vapor on the it.
use the same type of The des­
ignation is marked on the
is to carry a box of spare
The box co ntain , at the ing
W (HB4 ) Low beam 12 V W (HB4 )
High beam
12
v 21 w Brake
1 2 v 21 w Rear turn
front marker
w
for be
the re­
quires and Front marker

Emergency starting
Starting by pushing or towing
with automatic transmission
cannot be started by pushing or towing.
Vehicles with
may Do not battery acid to
contact eyes or skin.
batteries generate
explosive gases.
Keep
sparks, cigarettes away from batteries.
Do not try to jump start any with a acid in the battery .
rating.
The capacity (Ah ) of the booster battery
or
Applying a high er
ra dio , etc.
with discharged battery:
Turn off
and set parking brake.
17 1

TABLE
Program
Limited New Warranty .................. 2-5
2 yea rs o r
1 years or (First owner) . . . . . . . . . . . . . 6
5 years or (Subsequent owner) . . . . . . . . 6
Limited Warranty Against Corrosion Perforation
6 yea rs without .................. 9
2 years or ....................... 11-12 8 years or
2 years or . 13
Emissions Warranties ........... ..... 16-21
Manufacturer's Warranty Coverage
3 years or . . . . . . . . . . . . . . . . . . . . . . . . . . 16 7 years or . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Emissions 3 years or . . . . . . . . . . . . . . . . . . . . . . . . . . 17
7 years or
.................... 23-24
Free Maintenance
............................. 23
............................. 23
Brake and Air ..... 23
2 years . . . . . . . . . . . . . . . . . . . . . . . . . . 23
Customer
........... ........
Tire Manufacturers ............................... 32

Service every
on page 4-
Emission Control Maintenance
Engine : Change
-filter : First replacement at
park/neutral safety switch (whe re
Brake pads: Check thickness (EuroVan and Diesel)
Whee ls: Rotate front
to rear
5

Vehicle Maintenance
Manual transmission : Check for
Battery : Check electrolyte add if necessary
Automatic transmission : Check
ATF1l
Automatic transmission ,
drive : Check
Check operation including neutral safety switch (where
Power steering: Check
Brake system : Check for damage and thickness of pads and brake
heating and ventilat ion syste ms, a ir conditioning and
power accessor i
es
On-board diagnosis : Check
Check condition and pressure
Water separator: Drain water (Diesel )
(
km, every ]
km and every 2 years regardless of (kilometers).
1 tra ffic conditions, it is necessary to change the ATF every be
7

Check condition ; on with semi -automatic tensioner (without tension adjust tension
- Brake
9

Brake fluid Service
Brake absorbs moisture which can be
to the entire brake system.
Therefo re , the brake
must be
every 2 years. Your
service is due in
month year
was performed
on
(dealer stamp )
The next brake service
is due in
month year ____ _
was performed
on
(dealer stamp )
The next brake
service
is due in
month year
was performed
on
(deale r sta m p)
13