1994 TOYOTA CAMRY oil pressure

29
Position of Parts in Engine Compartment
[1MZ±FE]
I 1 Idle Air Control Valve (ISC Valve) N 1 Noise Filter (for Ignition System)
I 2 Igniter
I 4 Injector No. 1 O 1 Oil Pressure SW
I 5 Injector No. 2 O 6 O/D Direct Clutch Speed Sensor
I 6 Injector No. 3
I 7 Injector No. 4 P 1 Park/Neutral Position SW (Neutral Start SW) (A/T)
I 8 Injector No. 5
I 9 Injector No. 6 S 1 Solenoid Valve (for Hydrauric Motor)
I 15 Igniter S 3 Starter
I 16 Ignition Coil No. 1 S 4Starter
I 17 Ignition Coil No. 2
I 18 Ignition Coil No. 3 T 1 Throttle Position Sensor
I 19 Ignition Coil No. 4
I 20 Ignition Coil No. 5 V 1 VSV (for A/C Idle±Up)
I 21 Ignition Coil No. 6 V 2 VSV (for EGR System)
V 3 VSV (for Fuel Pressure Up)
J 6 Junction Connector V 4 VSV (for Intake Air Control)
V 5 Vehicle Speed Sensor (Speed Sensor)
K 1 Knock Sensor 1
K 2 Knock Sensor 2 W 1 Washer Motor
W 2 Water Temp. Sender
M 6 Mass Air Flow (Air Flow Meter)

31
Position of Parts in Engine Compartment
[5S±FE]
H 1 Headlight Hi LH O 1 Oil Pressure SW
H 2 Headlight Hi RH O 2 Oxygen Sensor (Sub)
H 3 Headlight Lo LH O 3 Oxygen Sensor (Main)
H 4 Headlight Lo RH
H 5 Horn LH P 1 Park/Neutral Position SW (Neutral Start SW) (A/T)
H 6 Horn RH
R 1 Radiator Fan Motor
I 1 Idle Air Control Valve (ISC Valve)
I 2 Igniter S 3 Starter
I 3 Ignition Coil S 4Starter
I 4 Injector No. 1
I 5 Injector No. 2 T 1 Throttle Position Sensor
I 6 Injector No. 3
I 7 Injector No. 4 V 1 VSV (for A/C Idle±Up)
I 10 Intake Air Temp. Sensor (In±Air Temp. Sensor) V 2 VSV (for EGR System)
V 3 VSV (for Fuel Pressure Up)
K 1 Knock Sensor V 5 Vehicle Speed Sensor (Speed Sensor)
M 1 Manifold Absolute Pressure Sensor (Vacuum Sensor) W 1 Washer Motor
W 2 Water Temp. Sender
N 1 Noise Filter (for Ignition System)

59
11 8
180
186
22480
J5 J6 K3
120
124
144
148168 198130
138
168168120
124
182
192198
204
210
214236
Junction Connector (W/G)
Junction Connector (1MZ±FE)
Key Interlock Solenoid
License Plate Light
Light Failure Sensor
Luggage Compartment Light
Luggage Compartment Light SW
Moon Roof Control RelayMoon Roof Control SW and Personal
Light (w/ Moon Roof) (EX. W/G)Moon Roof Limit SW (EX. W/G)
Moon Roof Motor (EX. W/G)
Mass Air Flow (Air Flow Meter)
(1MZ±FE)
Noise Filter (for Ignition System)
Oil Pressure SW
O/D Main SW and A/T Indicator
Light (Shift Lever)
Park/Neutral Position SW
(Neutral Start SW) (A/T)
Parking Brake SW (for 1MZ±FE)
Parking Brake SW (for 5S±FE)
J7 L1 L2 L4L3 M2 M3 M5M4 M6 N1 N2 N3 O1 O5 P1 P2 P3 P4 P5 P6 P7 P8 P9 P10 P11 P12
Junction Connector (1MZ±FE)
Noise Filter (for Stop Light)
Noise Filter (for Stop Light)
Power Seat Control SW
Power Seat Motor
(for Front Vertical Control)
Power Seat Motor
(for Rear Vertical Control)
Power Seat Motor
(for Slide control)
Power Seat Motor
(for Reclining Control)
Power Window Control SW Front
RH
Power Window Control SW Rear
LH (EX. C/P)
Power Window Control SW Rear
RH (EX. C/P)
Power Window Master SW and
Door Lock control SW LH
182 144130
134
138
140130
134
138
140168 80 80120
124
182
192198
204
210
214126
198
204 68
72
152
198
204236 236 180 180 180 180 180 156 156 156156
160
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

61
186
R18 R19 R20 R21 S3 S8 S9 S10 V1 V2 V3 V468
72182226
23080
90
98
Rear Wiper Motor (W/G)
Rear Wiper Relay (W/G)
Remote Control Mirror LH
Remote Control Mirror RH
Shift Lock ECU
Stereo Component Amplifier
Stereo Component Amplifier
Stop Light SW
VSV (for A/C Idle±Up)
VSV (for EGR System) (1MZ±FE)
VSV (for Fuel Pressure Up)
VSV (for Intake Air Control)
(1MZ±FE)
Vehicle Speed Sensor
(Speed Sensor)
Vanity Light LH
Vanity Light RH
Washer Motor
Water Temp. Sender
Diode
Noise Filter
Defogger Relay (Coil Side)
Power Main Relay (Coil Side)
S5 V5 V8 V9 W1 W2
Starter (1MZ±FE)
Defogger Relay (Point Side)
Power Main Relay (Point Side)
Taillight Relay (Coil Side)
Taillight Relay (Point Side)
Starter Relay (Point Side)
Starter Relay (Coil Side)
EFI Main Relay (Coil Side)
EFI Main Relay (Point Side)
Headlight Relay (Coil Side)
186 154 154226
230120
192
204182
198
210
21480
9080
90
9880 80
98
198 90
192
236130
134
138130
134
138184
186236130
134
138190 190 190156
160
168156
160
16811 2
12612668
7268
72 80
90
98
198
204 80
90
98
198
204106
(4): R/B No. 4 (See page 20)(5): R/B No. 5 (See page 19)(6)R/B No. 6 (See Page )
2526 26

88
ENGINE CONTROL (5S±FE)
THIS SYSTEM UTILIZES AN ENGINE CONTROL MODULE (ENGINE ECU (M/T), ENGINE AND ELECTRONIC CONTROLLED
TRANSMISSION ECU (A/T)) AND MAINTAINS OVERALL CONTROL OF THE ENGINE, TRANSMISSION AND SO ON. AN OUTLINE OF THE
ENGINE CONTROL IS EXPLAINED HERE.
1. INPUT SIGNALS
(1) ENGINE COOLANT TEMP. (WATER TEMP.) SIGNAL SYSTEM
THE ENGINE COOLANT TEMP. SENSOR (EFI WATER TEMP. SENSOR) DETECTS THE ENGINE COOLANT TEMP. AND HAS A
BUILT±IN THERMISTOR WITH A RESISTANCE WHICH VARIES ACCORDING TO THE ENGINE COOLANT TEMP. (WATER TEMP.)
THUS THE ENGINE COOLANT TEMP. (WATER TEMP.) IS INPUT IN THE FORM OF A CONTROL SIGNAL TO TERMINAL THW OF
THE ENGINE CONTROL MODULE (ECU).
(2) INTAKE AIR TEMP. SIGNAL SYSTEM
THE INTAKE AIR TEMP. SENSOR (IN±AIR TEMP. SENSOR) IS DETECTS THE INTAKE AIR TEMP., WHICH IS INPUT AS A
CONTROL SIGNAL TO TERMINAL THA OF THE ENGINE CONTROL MODULE (ECU).
(3) OXYGEN SENSOR SIGNAL SYSTEM
THE OXYGEN DENSITY IN THE EXHAUST GASES IS DETECTED AND INPUT AS A CONTROL SIGNAL TO TERMINAL OX1 AND
OX2 OF THE ENGINE CONTROL MODULE (ECU).
(4) RPM SIGNAL SYSTEM
CRANKSHAFT POSITION AND ENGINE RPM ARE DETECTED BY THE PICK±UP COIL INSTALLED INSIDE THE DISTRIBUTOR.
CRANKSHAFT POSITION IS INPUT AS A CONTROL SIGNAL TO TERMINALS G+ AND G2 (CALIFORNIA), OF THE ENGINE
CONTROL MODULE (ECU), AND RPM IS INPUT TO TERMINAL NE+.
(5) THROTTLE SIGNAL SYSTEM
THE THROTTLE POSITION SENSOR DETECTS THE THROTTLE VALVE OPENING ANGLE, WHICH IS INPUT AS A CONTROL
SIGNAL TO TERMINAL VTA OF THE ENGINE CONTROL MODULE (ECU), OR WHEN THE VALVE IS FULLY CLOSED, TO
TERMINAL IDL
(6) VEHICLE SPEED SIGNAL SYSTEM
THE VEHICLE SPEED SENSOR (SPEED SENSOR), INSTALLED INSIDE THE COMBINATION METER, DETECTS THE VEHICLE
SPEED AND INPUTS A CONTROL SIGNAL TO TERMINAL SPD OF THE ENGINE CONTROL MODULE (ECU).
(7) PARK/NEUTRAL POSITION SW (NEUTRAL START SW) SIGNAL SYSTEM (A/T)
THE PARK/NEUTRAL POSITION SW (NEUTRAL START SW) DETECTS WHETHER THE SHIFT POSITION ARE IN NEUTRAL AND
PARKING OR NOT, AND INPUTS A CONTROL SIGNAL TO TERMINAL NSW OF THE ENGINE CONTROL MODULE (ECU).
(8) A/C SW SIGNAL SYSTEM
THE A/C AMPLIFIER INPUTS THE A/C OPERATIONS TO TARMINAL ACA OF THE ENGINE CONTROL MODULE (ECU) AS A
CONTROL SIGNAL.
(9) BATTERY SIGNAL CIRCUIT
VOLTAGE IS CONSTANTLY APPLIED TO TERMINAL BATT OF THE ENGINE CONTROL MODULE (ECU). WHEN THE IGNITION SW
TURNED ON, THE VOLTAGE FOR ENGINE CONTROL MODULE (ECU) START±UP POWER SUPPLY IS APPLIED TO TERMINALS
+B AND +B1 OF ENGINE CONTROL MODULE (ECU) VIA EFI MAIN RELAY. THE CURRENT FLOWING THROUGH THE IGN FUSE
FLOWS TO TERMINAL IGSW OF THE ENGINE CONTROL MODULE (ECU).
(10) INTAKE AIR VOLUME SIGNAL SYSTEM
INTAKE AIR VOLUME IS DETECTED BY THE MANIFOLD ABSOLUTE PRESSURE SENSOR (VACUUM SENSOR) (FOR MANIFOLD
PRESSURE) AND IS INPUT AS A CONTROL SIGNAL TO TERMINAL PIM OF THE ENGINE CONTROL MODULE (ECU).
(11) STA SIGNAL CIRCUIT
TO CONFIRM WHETHER THE ENGINE IS CRANKING, THE VOLTAGE APPLIED TO THE STARTER MOTOR DURING CRANKING IS
DETECTED AND THE SIGNAL IS INPUT INTO TERMINAL STA OF THE ENGINE CONTROL MODULE (ECU) AS A CONTROL
SIGNAL.
(12) ENGINE KNOCK SIGNAL CIRCUIT
ENGINE KNOCKING IS DETECTED BY KNOCK SENSOR AND THE SIGNAL IS INPUT INTO TERMINAL KNK AS A CONTROL
SIGNAL.
(13) ELECTRICAL LOAD SIGNAL SYSTEM
THE SIGNAL WHEN SYSTEMS SUCH AS THE REAR WINDOW DEFOGGER, HEADLIGHTS, ETC. WHICH CAUSE A HIGH
ELECTRICAL BURDEN ARE ON IS INPUT TO TERMINAL ELS AS A CONTROL SIGNAL.
SYSTEM OUTLINE

91
*
2 : EX. CALIFORNIA
* 4 : FOR CANADA IN TMM MADE * 1 : CALIFORNIA
* 5 : EX. * 4
B C
I18B 11 B 1B12
R
B
L R
VC VTA IDL
THROTTLE POSITION
SENSOR T11 2
1 2
1 2 E20
E20
E18 E17 E17 1234
2 3
32 112
A 13 A2C 18 C 17 C 5 C 4
B 2 A
4B3B10 B16 B9 PIM THW THA THG E21 E2 NE NE±(
*2)
G± G+B B± O W±R W±R
B±O
B± O
BR BR BR
B±Y
BR BR
BR
BR
BR
BRGR L±BLGB±R G G
W± R W±R
R
L
B
Y
B±O
D6
I3
D2
E7 ,E8 , E10 +B1 ELSW± R
NE+ NE± G± G+(
*2)
VC E2PIM
(
*2)
M1
E4
I10
E1
MANIFOLD ABSOLUTE
PRESSURE SENSOR
(
VACUUM SENSOR)
ENGINE COOLANT TEMP. SENSOR
(
EFI WATER TEMP. SENSOR)
INTAKE AIR TEMP. SENSOR
(
IN±AIR TEMP. SENSOR)
EGR GAS TEMP.
SENSOR
ENGINE CONTROL MODULE(
ENGINE AND ELECTRONIC CONTROLLED TRANSMISSION ECU)(
A/T)
B
DIODE
(
FOR IDLE±UP)
IGNITION COIL
DISTRIBUTOR FROM
I18 E18
4321BR
BR I18
L
L FROM CRUISE
CONTROL ECU 1
P
E19
C 3C20 534
12
W± R
WBW±R
B
W±R
(
SHIELDED)
IGF IGT COIL± +B IG±
IGF IGTIGNITER I2
TO TACHOMETER
[COMB. METER]
C 8
FPU 1 2 B±O
(
*1)
B±O
(
*1) B±RV3
VSV
(
FOR PRESSURE UP)
1342G2(
*1)
(
*1)
(
*2)
NE G2 G± G1(
*1)
B E11 , E12CA,E14ENGINE CONTROL MODULE(
ENGINE ECU)(
M/T) ONE BODY ASSEMBLY
EX. CALIFORNIA
R
BRB±R
1D 1415A
TAIL
1A 1010A
MIR±HTR
3C 53D 5
POWER SOURCESYSTEM(
SEE PAGE 64)

99
AB
1 2
1 2
1 2 E20
E20
E18 E17 E171234
32 112
C 1A 5 A 18 A 17 A 4
B 2C
4B3B13 B9 B 16 IP116
PIM THW THA THG E2E21 NE NE± G± G+
(
SHIELDED) B B±O W±R W± R
B±O
B±O
R
BRBR BR BR BR
B±Y
BR
BR
BR
BR
BRGR L±BLGW±R W±R
R
L
B
Y
B±O
D6
I3
D2
E11 , E12 , E14 +B1W±R
NE+ NE± G± G+
VC E2PIM
M1
E4
I10
E1
MANIFOLD ABSOLUTE
PRESSURE SENSOR
(
VACUUM SENSOR)
ENGINE COOLANT
TEMP. SENSOR
(
EFI WATER TEMP.
SENSOR)
INTAKE AIR
TEM P. SE NSOR
(
IN±AIR TEMP.
SENSOR)
EGR GAS TEMP.
SENSOR
ENGINE CONTROL MODULE(
ENGINE ECU)
B
DIODE
(
FOR IDLE±UP)
IGNITION COIL
DISTRIBUTOR
I18 E18
BR
BRBR 2 3
C 12
B±R G G
ELS FRO E 64)
1
P
E19
A 3A22
W±R
WB±R
W±R
BB
B
W± R
B± R
12 534
COIL± +B
IG F IGT
IG F IGTIGNITER I2
TO
TACHOMETER
[COMB. METER]
W±R
(
*
2)B±O
B±O
NE+
1D 1415A
TAIL
1A 1010A
MIR±HTR
3C 53D 5
M POWER SOURCE SYSTEM(
SEE PAG

239
B 2 BRAKE FLUID LEVEL SW1±2 : CLOSED WITH FLOAT DOWN
C 8(A), C 9(B), C10(C)
COMBINATION METER(A)2, (B)6, (B)9±GROUND : APPROX. 12 VOLTS WITH IGNITION SW AT ON POSITION
(A)3, (B)14, (C)8±GROUND : ALWAYS CONTINUITY
F15
FUEL SENDER2±3 : APPROX. 3
WITH FUEL FULL
APPROX. 110.0
WITH FUEL EMPTY
O 1
OIL PRESSURE SW1±GROUND : CLOSED WITH OIL PRESSURE BELOW 0.2 KG/CM2 (2.84 PSI, 19.61 KPA)
P 2
PARKING BRAKE SW (1MZ±FE A/T)1±GROUND : CLOSED WITH PARKING BRAKE PEDAL DEPRESSED
P 3
PARKING BRAKE SW (EX. 1MZ±FE A/T)1±GROUND : CLOSED WITH PARKING BRAKE LEVER PULLED UP
: PARTS LOCATION
CODESEE PAGECODESEE PAGECODESEE PAGE
B 228 (1MZ±FE), 30 (5S±FE)D 432P 233
C 8A32F1534 (S/D), 35 (C/P), 36 (W/G)P 333
C 9B32I 228 (1MZ±FE), 30 (5S±FE)V 528 (1MZ±FE), 30 (5S±FE)
C10C32J 233W 228 (1MZ±FE), 30 (5S±FE)
C1432O 128 (1MZ±FE), 30 (5S±FE)
: RELAY BLOCKS
CODESEE PAGERELAY BLOCKS (RELAY BLOCK LOCATION)
125R/B NO. 1 (LEFT KICK PANEL)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CODESEE PAGEJUNCTION BLOCK AND WIRE HARNESS (CONNECTOR LOCATION)
1B
1C
1D20COWL WIRE AND J/B NO 1 (INSTRUMENT PANEL LEFT)1F20COWL WIRE AND J/B NO. 1 (INSTRUMENT PANEL LEFT)
1L
1M
2G22COWL WIRE AND J/B NO. 2 (ENGINE COMPARTMENT LEFT)
3A
3B24COWL WIRE AND J/B NO 3 (BEHIND COMBINATION METER)3C24COWL WIRE AND J/B NO. 3 (BEHIND COMBINATION METER)
3D
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CODESEE PAGEJOINING WIRE HARNESS AND WIRE HARNESS (CONNECTOR LOCATION)
II142COWL WIRE AND INSTRUMENT PANEL WIRE
IJ142FLOOR NO. 1 WIRE AND COWL WIRE
IP144ENGINE WIRE AND COWL WIREIP344ENGINE WIRE AND COWL WIRE
46 (S/D)
BX148 (C/P)FUEL GAUGE WIRE AND FLOOR NO. 1 WIREBX1
50 (W/G)
FUEL GAUGE WIRE AND FLOOR NO. 1 WIRE
: GROUND POINTS
CODESEE PAGEGROUND POINTS LOCATION
ED38 (1MZ±FE)INTAKE MANIFOLD LHED40 (5S±FE)INTAKE MANIFOLD LH
IE42LEFT KICK PANELIF42LEFT KICK PANEL
IG42INSTRUMENT PANEL BRACE LH
: SPLICE POINTS
CODESEE PAGEWIRE HARNESS WITH SPLICE POINTSCODESEE PAGEWIRE HARNESS WITH SPLICE POINTS
I 644INSTRUMENT PANEL WIREI1344COWL WIRE
I 944COWL WIREI1844ENGINE WIRE
SERVICE HINTS