1994 PONTIAC FIREBIRD transmission fluid

tNot all air conditioning refrigerants are the same. If the air con\
ditioning system in your
vehicle needs refrigerant, be sure the proper refrigerant is us\
ed. If you’re not sure, ask
your Pontiac dealer.
“Recheck fluid level after filling. See “Automatic Transmission Fluid” in the Index.
235. . .
ProCarManuals.com

Service and Appearance Care
Crankcase
VIN Engine Code S .................................... 4.0 qt. (3.8 L)**
Without Filter Change
................................ 4.0 qt. (3.8 L)**
With Filter Change ................................... 5.0 qt. (4.7 L)**
Fuel Tank ........................................... 15.5 gal. (58.7 L)
Five-Speed
........................................... 5.9 pt. (2.8 L)*
Six-Speed
............................................ 8.0 pt. (3.8 L)*
Rear Axle Lubricant
...................................... 3.5 pt. (1.7L)
VIN Engine Code
P
Manual
Transmission
Vehicle Dimensions
Tread Wheelbase
........................................... 101.1 I‘ (2 566 mm)
Front
.............................................. .60.7“ ( 1 542 mm)
Rear
.............................................. .60.6” (1 540 mm)
Length
............................................... 193.2“ (4 908 mm)
Firebird and Formula
................................. 195.6” (4 968 mm)
Trans Am .......................................... 197.0” (5 005 mm)
Width
............................................... 74.5” (1 893 mm)
Coupe
........................................... 52.0” (1 322 mm)
Convertible ....................................... .52.7” ( 1 340 mm)
Coupe
........................................... .51.7” (1 312 mm)
Convertible
....................................... .52.4“ (1 331 mm)
Height
Firebird and Formula
Trans Am
*Recheck fluid level after filling. See “ManualTransmission Fluid” in the Index.
**Recheck oil level after filling. See “Engine Oil” in the Index.
. . -236
ProCarManuals.com

Maintenance Schedule
C L Section A: Scheduled Maintenance Services
Schedule I
Follow Schedule I if your vehicle is
MAINLY driven under one or more of
the following conditions:
When most trips are less than
4 miles
(6 km).
When most trips are less than
10 miles
(16 km) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as in stop-and-go traffic.
When towing a trailer.
When operating in dusty areas.
Schedule
I should also be followed if the
vehicle is used for delivery service. police,
taxi or other commercial aqdications.
* An Emission Control Service.
t The U.S. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to perform this
maintenance item will not nullify the emission
warranty
or limit recall liability prior to the
completion ‘of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
ITEM NO.
-
1
3
-
4
6
-
7
9
11
WHAT TO SERVICE
See “Explanation of Scheduled
Maintenance Services” following
Schedules
I and II.
~
Engine Oil & Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt Inspection*
Cooling System Service*
Transmission Service
Spark Plug Replacement
(3.4L L32 (Code
S) Engine)*
Spark Plug Replacement
(5.7L LTl (Code P) Engine)*
Spark Plug Wire Inspection*?’
Air Cleaner Filter Replacement*
Fuel Tank, Cap
& Lines Inspeclion*t
Rear Axle Fluid Change (For Vehicles
Towing Trailers or for Vehicles with
Limited-Slip Differentials)
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occursfirst).
Every 3,000 miles (5 000 km) or 3 months.
Every other oil change.
At
6,000 miles (10 000 km) and every
15,000 miles (25 000 km) or as necessary.
Every
30,000 miles (50 000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services” following Schedules I and
II.
Every 30,000 miles (50 000 km).
Every 100,000 miles (166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules I and 11.
Every 30,000 miles
(50 000 km).
~ ~~ ~~~
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
. . .242
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Schedule lI
Follow Schedule II ONLY if none of
the driving. conditions specified in
Schedule
I apply.
* An Emission Control Service.
t The US. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to pedorm this
maintenance item will not nullify the emission
warranty or limit recall liability prior to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
WHAT TO SERVICE WHEN TO PERFORM
“Explanation of Scheduled Miles (kilometers) or Months ITEM NO. Maintenance Services” following (whichever occursfirst).
Schedules
I and I?.
Engine Oil Change* Every 7,500 miles (12 500 km) or 12 months.
Oil Filter Change* At
first and every other oil change. 1
2 Chassis Lubrication Every 7,500 miles (12 500 km) or 12 months. ~~~
3 I Tire and Wheel Rotation & Inspection I
At 7,500 miles (12 500 km) and then every
15,000 miles (25
000 km) or as necessarv.
4 I Engine Accessory Drive Belt Inspection* ~ Every 30,000 miles (50 000 km) or 24 months.
5 I Cooling System Service* !
6 I Transmission Service I
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Spark Plug Replacement
(3.4L L32 (Code
S) Engine)* Every 30,000 miles (50 000 km).
7
I
Spark Plug Replacement
(5.7L LTl (Code P) Ennine)* I Every 100,000 miles (166 000 km). \- I I, I
8 Spark Plug Wire Inspection*? Every 30,000 miles (50 000 km).
9 Air Cleaner Filter Replacement* I I
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and II.
10 Fuel Tank, Cap & Lines Inspection”? Every 30,000 miles (50 000 km).
, , Rear Axle Fluid Change (For Vehicles See “Explanation
of Scheduled Maintenance
with Limited-Slip Differentials) Services” following Schedules I and
11.
. . .244
ProCarManuals.com

Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Explanation of Scheduled
Maintenance Services
Following are explanations of the services
listed in Schedule I and Schedule
II.
The proper fluids and lubricants to use are
listed in Section
D. Make sure whoever
services your vehicle uses these. All parts
should be replaced and all necessary
repairs done before you or anyone else
drives the vehicle.
NOTE: To determine your engine’s
displacement and code, see
“Engine Identification” in the
Index.
ITEM
NO. SERVICE
1 Engine Oil and Filter Change* -
Always use SH or SG Energy
Conserving
I1 oils of proper
viscosity. The “SH” or “SG”
designation may be shown alone
or in combination with others,
such as “SH/CD,”
“SH, SG,
CD,” “SG/CD,” etc. To deter-
mine the preferred viscosity for
your vehicle’s engine (e.g., SAE
ITEM
NO.
2
3
4
SERVICE
5W-30 or SAE 10W-30), see
“Engine Oil” in the Index.
Chassis Lubrication
- Lubricate
the suspension and steering
linkage. Lubricate the
transmission
shift linkage.
Tire and Wheel Rotation and
InsDection
- For proper wear
and maximum tire life, rotate
your tires following the
instructions in this manual. See
“Tires, Inspection and Rotation”
in the Index. Check the tires for
uneven wear or damage. If you
see irregular or premature wear,
check the wheel alignment.
Check for damaged wheels also.
Engine Accessorv Drive Belt!s)
InsDection
- Inspect the belt(s)
for cracks, fraying, wear and
proper tension. Replace as
needed. (Belts can have many small cracks in individual ribs
without affecting performance.)
ITEM
NO. SERVICE
5 Cooling: System Service* -
Drain, flush and refill the system
with new or approved recycled
coolant conforming to GM
Specification 1825M. Keep
coolant at the proper mixture as specified. See “Coolant”
in the
Index. This provides proper
freeze and boil protection, corrosion inhibitor level and
maintains proper engine operating temperature.
Inspect hoses and replace if they
are cracked, swollen or deterior-
ated. Tighten screw-type hose
clamps. Clean the outside of the
radiator and air conditioning
condenser. Wash the pressure cap and neck.
To help ensure proper operation,
we recommend a pressure test of
both the cooling system and the
pressure cap.
* An Emission Control Service.
. . .246
ProCarManuals.com

ITEM
NO. SERVICE
6 Transmission Service - For
manual transmissions, fluid
doesn’t require changing. See
“Periodic Maintenance
Inspections.”
For automatic transmissions,
change both the fluid and filter
every 15,000 miles
(25 000 km)
if the vehicle is mainly driven
under one
or more of these
conditions:
In heavy city traffic where the
outside temperature regularly
reaches
90°F (32°C) or
higher.
In hilly or mountainous
terrain.
When doing frequent trailer
towing.
Uses such as found in taxi,
police car or delivery service.
If you do not use your vehicle
under any of these conditions,
change both the fluid and
filter every
100,000 miles
(166 000 km).
ITEM
NO. SERVICE
7
8
9
10
Spark Plug Replacement* -
Replace spark plugs with the
proper type. See “Replacement
Parts” in the Index.
Spark Plug Wire InsPection*t
-
Inspect for burns, cracks or other
damage. Check the boot fit at the
distributor and at the spark plugs.
Replace wires as needed.
Air Cleaner Filter Replacement”
- Replace every 30,000 miles
(50 000 km) or more often under
dusty conditions. Ask your
dealer for the proper replacement
intervals for your driving
conditions.
Fuel Tank. Cap and Lines
Inspection*-/-
- Inspect fuel tank,
cap and lines (including fuel rails
and injection assembly) for
damage or leaks. Inspect fuel cap
gasket for an even filler neck
imprint or any damage. Replace
parts as needed. Periodic
replacement of the fuel filter is
not required.
ITEM
NO. SERVICE
11 Rear Axle Fluid Change - If your
vehicle is used to pull a trailer,
have the rear axle gear lubricant
changed every
7,500 miles
(12 500 km).
If your vehicle is not used to pull
a trailer, but has a limited-sli,p
differential, have the rear axle
gear lubricant changed once, after
the first
7,500 miles (12 500.h).
* An Emission Control Service.
j- The US. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to pe$orm this
maintenance item will not nullify the emission
warranty
or limit recall liability prior to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in “Section E: Maintenance Record.”
247. . .
ProCarManuals.com

Maintenance Schedule
Section C: Periodic Maintenance Inspections (Cont.)
I INSPECTION
F Manual Transmission
I
Rear Axle Service
Brake System
Inspection
WHAT SHOULD BE DONE
Check the transmission fluid level; add if needed. See “Manual Transmission” in the Index.
A fluid
loss may indicate a problem. Check the system and repair if needed.
Check the gear lubricant level in the rear axle and add if needed. See “Rear Axle” in the Index.
A fluid loss may indicate a problem. Check the axle and repai\
r it if needed.
If your vehicle
is used to pull a trailer, have the rear axle gear lubricant changed every
7,500 miles
(12 500 km).
Inspect the complete system. Inspect brake lines and hoses for \
proper hookup, binding, leaks,
cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also
inspect drum brake linings for wear and cracks. Inspect other \
brake parts, including drums,
wheel cylinders, calipers, parking brake, etc. The parking brake\
is self-adjusting and no manual
adjustment is required. You may need to have your brakes inspected more often if your driving
habits or conditions result in frequent braking.
NOTE: A low brake fluid level can indicate worn disc brake pads which may need to be serv-
iced. Also, if the brake system warning light stays on or comes on, something may be wrong
with the brake system.
See “Brake System Warning Light” in the Index. If your anti-lock brake \
system warning light stays on, comes on or flashes, something may be wrong with the anti-lock
brake system. See “Anti-Lock Brake System Warning Light’’ in the Index.
~~
. . .252
ProCarManuals.com

Section D: Recommended Fluids & Lubricants
JOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM Dealer.
USAGE
Engine Oil
Engine Coolant
Hydraulic Brake System
FLUID/LUBRICANT
API service SH or SG Energy Conserving I1 oils of the proper viscosity. The “SH” designation
may be shown alone or in combination with others, such as “SH/CD,”
“SH, SG, CD,”
“SG/CD,” etc. To determine the preferred viscosity for your vehicle’s engine, see “Engine
Oil”
in the Index.
50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM Part No. 1052753 or equivalent) conforming to GM Specification 1825M or approved
recycled coolant conforming to
GM Specification 1825M.
Delco-Supreme
ll@ Brake Fluid (GM Part No. 1052535 or equivalent DOT-3 Brake Fluid).
Hydraulic Clutch Hydraulic Clutch Fluid (GM Part.
No. 12345347 or equivalent).
System
Power Steering System
~~
GM Hydraulic Power Steering Fluid (GM Part No. 1052884 or equivalent).
Manual Transmission DEXRON@-IIE Automatic Transmission Fluid.
Automatic DEXR0N’-III or DEXRON@-IIE Automatic Transmission Fluid.
Transmission
I
Key Lock Cylinders I Lubricate with Multi-Purpose Lubricant (GM Part No. 12345120) or synthetic SAE 5W-30
253. . .
ProCarManuals.com