1994 MAZDA MX-5 horn

T HORN TURN CLOCKWISE T RETURN 2.75 TURNS +I 2. Remove the air bag module and then remove the steer- ing wheel assembly. d 3. Before installation of the steering wheel reset the clock spring connector as follows: (1) Set the front wheels straight ahead. (2) Turn the clock spring connector clockwise until it stops. (3) Return 2.75 turns. (4) Align the marks (counterclockwise) on the clock spring connector and the outer housing. 4. Install the steering wheel and the air bag module. Verify that the air bag system is operating normally by monitor- ing the air bag warning light. Gartner Banana

SRS AIR BAG SYSTEM SYSTEM DIAGRAM PASSENGER-SIDE S-SENSOR AIR BAG MODULE I IG1 B+ HORN RELAY CLOCK SPRING BACK-UP BATTERY I AIR BAG SYSTEM WARNING LIGHT SENSOR -7 System Operation During collision When either of the D-sensors and the S-sensor are activated (closed) simultaneously by shock of a colli- sion, the circuit to the inflator is completed. The inflator creates nitrogen gas and the air bag is deployed. The air bag vents the nitrogen gas from the vent hole on the back side of the bag to reduce shock to the driver and to allow easier exit from the vehicle. During normal condition and malfunction The diagnostic module constantly monitors the components and wiring of the air bag system for malfunc- tion, open circuits, and short circuits. .J If a malfunction is detected, the diagnostic module illuminates or flashes the warning light. In the case of a short circuit in the sensors or sensor harnesses, the diagnostic module activates the warning light and shuts down the system to prevent accidental deployment of the air bag. Gartner Banana

T SRS AIR BAG SYSTEM GENERALPROCEDURES Before Servicing 1. Deactivate the audio antitheft system, if installed. (Refer to page T-120.) 2. Disconnect the negative battery cable. 3. Remove the lower panel. 4. Disconnect the orange and blue clock spring connec- tors. 5. Remove the glove compartment. 6. Disconnect the orange and blue passenger-side air bag module connectors. I , 46UOTXd21 TROUBLESHOOTING Troubleshootinn Procedure The air bag diagnostic module has a self-diagnosis function that flashes or illuminates the AIR BAG sys- tem warning light to indicate trouble in the air bag system. The trouble can be determined by the warning light illumination or flashing pattern. If the light does not illuminate but the system still has trouble, a warn- ing buzzer will sound 5 cycles of 5 times each. . . Flowchart I START Troubleshoot warning light circuit Does AIR BAG system warning light illuminate for 4-8 secs and I I Yes t Refer to service code table and troubleshoot system Press horn switch while turning steering wheel. Does horn sound? I I I Yes Reconnect connectors Are air bag module and horn switch connectors properly con- nected to clock spring connec- tor? Yes I I I I Troubleshooting horn circuit - Gartner Banana

SECTION NAME KEY SETS FRONT BUHPER REAR SUNPER WINDOW rlOULBIHG L COWL GRILLES HEAD LAMPS IIEAD LAHP RE 1 RACTORS FRONT COHBINATION LAWS REAR CUHBlNATIOH LAHPS L ICE HOE LAWS ORNhHENTS REAR F f Hf Ci+CR BONNET TRUNK 110 f RWT PANEL S FLHOEW & WHfkL APWOt4 P4NkL!$ LUSH & COWL PANELS SIDE PANELS FLOOR PANELS F LOOR ATTACHHENTS (HOLE COVERS ) HkTER HOOD SCf 600NC TCH CAB1.k RC 1 ER COMPONENTS SECTION nAnE ---------_L---_-----__________L_______I__________________L_______I__________________L_______I________-__________L_______I__________________L_______I__________________L_______I________ HEAI'ER Wit COMPONENTS HEATER CONTROLS COHPONENf S HEATER BLOWER COWPONENTS AIR CONBlTXOMR COHPRESSOR COHPONENTS (AIR CDh DITIONER) COOLING UNIT (AIR CO#DlTZONERI WINDOW GLASSES SUNRtOF SWiTCMES L RELAvC (ENGINE) DASMIOAWD SWITCHES CO~bfNAI~OH SWlfCiI RELAYS L UNIT i8OBV) DOOR SWITCH L HORNS AUTO CRUISE CONTROL C't SIGH AUDIO SYSTEHS (ANTENNA C WEAK ER MIWBSH2El.D YASHCK (U/U ANTI LUCI MAKC SYSICI) 7250 QUARTER WINCOW L TRIHS Gartner Banana

2-C06 2-C07 2-E07 2-F07 2-60 7 2-107 2-LO7 2-CO8 2-EOB 2-E09 2-GO9 2- JOY 2-H09 2-El0 ncAn LunDlnmIAun ~~nra LICENSE LAHPS ORNAMENTS REAR FINISHER BONNET TRUNK LID FRONT PANELS FENDER 6 WHEEL APRON PANELS DASH 6 COWL PANELS SIDE PANELS FLOOR PANELS FLOOR ATTACHMENTS (HOLE COVERS ) FLOOR ATTACHHENTS DASHBOARD EOUIPUENTS METtK HOOD SPEEDOMETER CABLE METER COMPONENTS DASHBOARD L RELATED PARTS CONSOLE VENTILATUR SEATS SEAT BELTS AIR BAG FRONT DOORS FRONT DOOR MECHANISMS FRONT DOOR TRIMS L RELAIED PAR T S SUNROOF SWITCHES 6 RELAYS (ENGINE) DASHBOARD SWITCHES COMB l !?AT1 ON SWITCH RELAYS 6 UNIT (BODY) DOOR SWITCH & HORNS AUTO CRUISE CONTROL SYSTEM AUDIO SYSTEMS (RADIO & TAPE DE CK 1 AUDIO SYSTEMS (ANTENNA & SPEAK ER) WIRING HARNESSES(FR0NT & REAR 1 WIRING HARNESSES(ENG1NE 6 T/HI SSION) WIRING HARNESSES(DASuYGARD> WIRING HARNESSES(DOOR,FLOOR/CE ILING) WIRING HARNESS CLAMPS WINDSHIELD WASHER (W/O ANTI LOCK BRAKE SYSTEM) WINDSHIELD WASHER (ANTI LOCK BRAKE SYSTEM) WINDSHIELD WIPERS WIPER MOTOR COMPOHENTS(FR0NT) FRONT HEADER TRIK 6 PILLAR TRI ns TRIMS b SCUFF PLATES FLOOR MATS X PhDS SERVICE TOOLS VISORS,ASSiST HAHOCES 8 HIRROK S DATE. 1995-04 PAGE. 3 Gartner Banana

ALPHABETICAL INDEX *%* ENGLISH *** GASKET'A' ,DUST COVER----- 1-114 GAUGEIFUEL TANK---------- 1-J14 GAUGE,OIL LEVEL---------- 1-DB 1 -H3 GEAR------..-------------- GEAR SET,DRlVEN-SPEED---- 1-M7 GEAR SET,FINAL----------- 1-H11 T -1 11 A-LAA GEAR,ADJUST-------------- l-Fll GEAR, COUNTER-- ----------- 1-H6 GEAR,COUNTER REVERSE----- 1-66 GEAR,COUNl'ER SHAFT------- 1-G6 GEAR,DIFF.SIDE----------- GEAR,DRIVEN-------------- 1-111 1-06 GEAR,INNER----.----------- 1-N4 GEAR,INTERNAL------------ 1 -D9 1 -H9 GEAR,INTERNAL-STARTER---- 1-67 GEAR,MAIN DRIVE---------- GEAR,OUTER--------------- 1-E6 1-N4 GEAR,OVER DRIVE---------- 1-G9 GEAR,OLER TOP------------ 1-H6 GEAR,REVERSE--.---------- 1-66 GEAR ,REVERSE IDLE-------- 1 -H6 GEAR ,RING-FLY WHEEL------ GEAR,SHAFT--------------- 1-K3 2-J15 GEAR,SPEEDO.DRIVE-------- 1 -H6 1 -H9 GEAR,STEERING------------ 1-J12 1-L12 GEPR,suN----------------- 1 -D9 GEAR,~s~----------------- 1 -F6 GEAR,zND----------------- 1-F6 OEAR,SRD----------------- 1-E6 G€NERATOR,PULSE---------- 1 -E8 GLASS(L1,DOGR-FRT-------- 2-K9 GLASS(L1,VENTJLATOR------ 2-K9 GLASS(R1,DOOR-FRT-------- 2-J9 GLASS(R1,VENTILATOR------ 2 -K 9 GLASS,BACK WINDOW-------- 2-Nll GLASS,WINDSHIELD--------- 2-N11 GRILLE(L),OEMISTER------- 2-C8 GRILLE(R),DEMISTER-------- 2-C8 GRlLLE,COWL-------------- 2-J3 GRIPtL1,ASSIST----------- 2-HI0 GRIP(R1,ASSIST----------- 2-H10 GROMMET------------------ 1 -H4 1 - I1 2 2-Cll 2-F14 2-Jll 2- Jl3 2-N14 GROHMET,BRAKE PEDAL------ 1-M14 GROMMETIDRAIN HOSE-TOP--- 2-H12 GROMMET,KNOB-METER SET--- 2-67 GROMHET,SCREW------------ 2-E5 2-F10 GROMMET,SCREW-BAFFLE----- GROMMET,SCREW-DOOR GLASS- GROMMET,SCREW-RETAIhkU--- GROMMET,WASHER TANK------ GUIDE~B~(L),GI.AZS-------- ;-KG i GU1DE1B'(RIJGLASS-------- 2-K9 ' GUSSET N0.3(L),C.FLOOR PA 2-15 GUSSET NO.J(R),C.FLOOR PA 2-K5 ! GUS5ET( L 1 ,REAR FENDER-RR- 2- I5 I GUSSET(L1,SIDE SILL OUTER 2-15 1 GUSSET(R1,REAR FENDER-RR- 2-H5 ! GUSSET(R),SIDE SILL OUTER 2-65 ' . .-- i_ CAT .AUNA04-03 - GUSSET,FRONT FLOOR PAN--- 2-L5 HANDLE(L1,INNER---------- HANDLE(L1,OUT.----------- HANDLE(R1,INNER---------- HANDLE(R1,OUT.----------- HANDLEIJACK-------------- HANDLE,REGULATOR--------- HANDLE,SOFT TOP---------- HANGER,ENGINE------------ HANGER,ENGINE-REAR------- HANGER,SILENCER-. -------- HARNESS N0.2,REAR-------- HARNESS, DOOR-------- -----. HARNESS,ENGINE----------- HARNESS,FRONT------------ HARNESSIINSTRUFENT------- HARNESS, REAR-- -- ---- -.---- HARNESS,WIRE------------- HARNESS'NO.?' ,FRONT- ----- HEAD,CYL.-COMPRESSOR----- HEAD,CYLLNDER------------ HEAD, ZIPPER-BACK I-""QOW-- HEADER,FRONT--- .--- HEADER,FRONT-Uf --- HEATER UNIT---- .---- HINGE-----------------.--- HINGE(L1,BONNET---------- HJNGE(L),DOOR-LOWER------ HINGE(L1,DOOR-UPPER------ HINGE(L1,LID-LAMP-------- HINGE(L),TRUNK LID------- HlNGE(R1,BOHNET---------- HINGE(R1,DOOR-LOWER------ HINGE(R),DPOH-UPPER------ HINGE(R1 ,GLOVE LID---- .-- HINGE(R).LID-LAMP-------- --. HOSE NO.1,UATER---------- HOSE N0.2,BREAlHER------- 1-114 HOSE NO.2,WATER---------- 2-Cll HOSE(C1,DEFROSTER-------- 2-D8 HOSE(L1,FLEXIBLE-FRT----- 1-115 1-K15 HOSE(L1,FLEXIBLE-RR------ 1-115 1-K15 HOSE(R1,FLEXIBLE-FRT----- 1-115 1-K15 HOSE(R1,FLEXIBLE-RR------ 1-115 HOSE,AIR----------------- 1-K15 1-14 HOSE,CLUTCH FLEXIBLE----- 1-F14 HOSE,DRAIN------..-------- 1-~4 HOSE,FUEL PUMP-IN TANK--- HOSE,FUEL-€GI------------ HflSE,OIL----------------- HOSE,P,C.V.-------------- HOSE,PRESSURE------------ HDSE,REfURN-------------- HOSE, WATER BY-.PASS------- tIOSE,WATER-OIL COOLER IN. 1-C5 HOSE'C',WASH€.:----------- 2- F15 HOUSING(L1,LAMP-LID HINGE 2-H3 HOUSING(L1,LAMP-RR FENDER 2-J5 HOUSING(R1,LAMP-LID HINGE 2-M3 HOUSING(R),LAMP-!?R FENOER 2-H5 HUB SET,CLlJTCH-O.T. 8 REV 1-H6 HUB SET,CLUTCH-1ST 8 2ND- 1-F6 HUB SET,CLUTCH-3RD 8 4TH- 1-c6 HUB ,CLUTCH- ---.-- - ----- --- I 1-E6 1 1 -F6 1-H6 -- INSULATOR,DASHBOARD------ 2-N15 INSULATOR,EX.MANIFOLD---- 1-E4 INSULATOR,FRONT---------- 2-D6 INSLLATOR,FUEL D1ST.----- 1-H4 INSULATOR ,HEAT----------- 1 - E4 JACK--------------------- 1-NlZ JET,OIL------------------ JOINT-------------------- 1 -H3 1-H3 1-17 2-El5 2-M9 JOINT SET.BALL----------- 1-K12 1-Ml2 JOINT SET,INNER--------a*- 1-Dl1 JOINT SET,OUTER---------- 1-Dl1 JOINT,BACK WINDOU MOULD-- 2-Nll JOINT,BALL--------------- l-Kl2 1-M12 JOINT,ELBOW-W.TANK------- 2-C15 2-Fl! KEY SET------------------ 2-C3 KEY SUB SET(C),DOOR------ 2-C3 KEY SUB SETCR)JDOOR------ 2-C3 KEY SUB SET,GLOVE-------- 2-D3 KEY SUB SET,ST.LOCK------ 2-D3 KEY SUB SET,TRUNK-------- 2-C3 KEY,BLANK-PRIMARY-------- 2-03 KEYJBLANK-SECONDARY------ KEY,PRIWARY-------------- 2-D3 2-C3 KEY ,SECONDARY-------- ---- 2-C3 KEY,SYNCHRONILER--------- 1-E6 KEY,WOODRUFF-PULLEV------ 1-K3 KNOB---------- ----a- ----.. 2-NI! KNOB ~0.1..--------------- 2-Ell KNOB(L>,KNUCKLE---------- 2- J8 KHOB