1994 GMC SIERRA check engine

Steering and Suspension Inspection? - Inspect front and rear suspension
and steering system for damaged, loose
or missing parts, signs of wear or
lack
of lubrication. Inspect power steering lines and hoses for proper
hook-up, binding, leaks, cracks, chafing, etc. Lubricate the steering linkage.
Accelerator Control System - On gasoline engines, lubricate the pivot at
the
TBI throttle lever stud with engine oil. Do not oil any accelerator or
cruise control cables. Replace any cables that have high effort
or excessive
wear.
Exhaust System Inspection - Inspect the complete system including the
three-way catalytic converter. Inspect the body near the exhaust system.
Look for broken, damaged, missing or out-of-position parts,
as well as,
open seams, holes, loose connections or other conditions which could cause
a heat buildup in
the floor pan or could let exhaust fumes seep into the
passenger compartments.
Drive Axle Service? - Check readfront axle fluid level and add as needed.
Check constant velocity joints and axle seals for leaking.
I-- ~ lsfer Case (Four-wheel Drive) Inspection? - Every 12 months or at
oil change intervals, check front axle and transfer case and add lubricant
when necessary. Oil the control lever pivot point and all exposed control
linkage. Check vent hose at transfer case for kinks and proper installation.
More frequent lubrication may be required
on heavy-duty or off-road use.
?'A fluid loss in these systems may indicate a problem. Have them inspected
and repaired at once.
7-25
ProCarManuals.com

Service Station Checks
It is important for you or a service station attendant to perform these
under-hood checks at each fuel fill.
Check the engine oil level and add if necessary.
Check the engine coolant level in the recovery bottle and add \
if
necessary.
Check the windshield washer fluid level and add if necessary.
See these items in the Index for information on how to check them.
7-30
ProCarManuals.com

Secondary
Hood Release
See Page 6-15.
Fluid
See Page 6-45.
engines, use 87
octane (or higher)
unleaded gasoline
only.
For diesel engines,
use at least
1 D
diesel fuel. For fuel
tank capacity
See Page 6-93.
Cold Tire /
Pressure
See the
Certificationflire
label on the
inside rear edge
of the driver's
door.
See Page 6-65,6-71.
, Battery
Your vehicle's
Delco Freedom
battery never
needs to have water added.
See Page 6-52.
Cooling System
coolant only at
the coolant
recovery tank
(gasoline engine)
or
only at the
coolant surge
tank (diesel engine). The
fluid
level should be at
the COLD mark.
See Page 6-38.
3 Check and add

Transmission
Fluid
See Page 6-30.
- Spare Tire
Pressure
See the
Certificatisnflire
label on the inside
rear edge
of the
driver's door.
See Page 6-71.
7-31
ProCarManuals.com

F
FanNoise ...................................................... 5-25
Filter Replacement Chart
.......................................... 6-94
Finish Care
........................................................ 6-85
Damage
..................................................... 6-86
Automatic Transmission
........................................ 6-30
Brake
....................................................... 647
Coolant
..................................................... 5-17
Capacities .............................................. 6-92, 6-93
FrontAxle
................................................... 6-37
Hydraulicclutch
.............................................. 6-35
LeakCheck
............................................. 6-47. 6-51
ManualTransmission .......................................... 6-33
Power Steering
............................................... 6-43
Radiator
..................................................... 5-17
Rear Axle ................................................... 6-39
Recommended Fluids
.......................................... 7-25
Transfer Case
................................................ 6-36
Windshield Washer
............................................ 6-45
Four-WheelDrive ............................................... 244
Transfer Case
........................................... 2-35, 6-36
Front Axle ................................................... 6-37
Fuel (Diesel Engines)
............................................. 6-11
Cold Weather Operation ......................................... 6-6
Filter Replacement ............................................ 6-11
Fuel Requirements ............................................. 6-4
Gage
....................................................... 2-78
RunningOutOf
.............................................. 6-10
Tankcapacity ................................................ 6-93
WaterinFuel
................................................. 2-71
Fuel (Gasoline Engines)
............................................ 6-4
FillingYourTank
............................................. 6-13
Foreign Countries
............................................. 6-12
Gage
....................................................... 2-78
Gasolines for Cleaner Air
........................................ 6-5
Tankcapacity
................................................ 6-93
Fuses and Circuit Breakers
................................... 6-64. 6-96
FuseBlock ............................................. 6-63, 6-95
Headlights
.............................................. 6-62-6-97
Trailer Wiring Harness
......................................... 6-62
Windshield Wipers
....................................... 6-45, 6-96
Fluid
Power Windows and Other
Power Options ......................... 6-62
Gages ......................................................... 2-78
Coolant Temperature Gage
...................................... 2-79
FuelGage
................................................... 2-78
Odometer
................................................... 2-68
Oil Pressure Gage ............................................. 2-80
Speedometer
................................................. 2-68
4
ProCarManuals.com

L
Labels Certificatioflire
.............................................. 6-65
Truck-Camper
............................................... 6-68
Lights
......................................................... 2-70
BrakeSystemWarning
......................................... 2-70
Bulb Replacement
................................... 2-52.6-53. 6-98
Cargo Lamp
............................................ 2.58. 6.60
Charging System Light
......................................... 2-73
Check Gages Light
............................................ 2-75
CHMSL
..................................................... 2-82
DomeLights
................................................. 2-51
Fender
...................................................... 6-58
Front Parking/Turn Signal
....................................... 6-55
GlowPlugsLight
............................................. 2-72
Headlights (See “Headlights”)
Indicator
.................................................... 2-77
Low Coolant Warning
.......................................... 2-73
Malfunction Indicator
..................................... 2.74. 6.66
Reading
..................................................... 2-51
Service Engine
Soon ........................................... 2-74
Service Throttle Soon
.......................................... 2-72
SideMarker
.................................................. 6-58
Rear .................................................... 6-60. 6-61
Replacementchart
............................................ 6-98
RoofMarker
................................................. 6-59
TailgateMarker
................................................ 6-59
Underhood Reel Lamp
......................................... 2-53
WaterInFuel
................................................. 2-71
LoadingYourVehicle
............................................ 6-65
Lubrication
..................................................... 6-51
Accelerator Control System
..................................... 6-51
Body
....................................................... 6-51
Constant Velocity Joints
........................................ 6-51
FrontAxle
................................................... 6-37
Front Shock Absorbers
......................................... 6-49
Front Suspension and Steering Linkage
............................ 6-49
FrontWheelBearings
.......................................... 6-49
TailgateHandle
............................................... 6-52
Hood Latches and Hinge ........................................ 6-51
Hydraulic Clutch Grease Fitting
.................................. 6-35
Lockcylinders
............................................... 6-52
Propeller Shaft Slip Splines
..................................... 6-51
RearAxle ................................................... 6-35
Recommended Lubricants
...................................... 7-25
Transfer Case
................................................ 6-36
Operation
................................................... 249
6
ProCarManuals.com

I
Service Do-It-Yourself
.......
Parts Identification Label
Publications
..........
Replacement Parts and Fj
Service Engine Soon Light
Service Station Checks
....
11
........................................ 6-3
....................................... 6-90
.................................... 8.6, 8.8
ter Recommendations
..................... 6-94
.................................. 2.74. 6-65
....................................... 7-28
Shift Indicator Light
......................................... 2.26, 2.76
ShiftingIntoPark
................................................ 2-30
Sliding Rear Window
............................................. 2-38
SpareTire
...................................................... 5-29
Pickup Bed Mounting
..................................... 5.31. 5-40
Specification Charts .............................................. 6-91
Speedometer
.................................................... 2-68
Starting your Diesel Engine
........................................ 2-16
Starting your Gasoline Engine
...................................... 2-12
Removal
.................................................... 5-29
Storage
..................................................... 5-39
Steering
........................................................ 4-8
Column Shift Lever
............................................ 2-30
InEmergencies
................................................ 4-9
Console
................................................ 2-59. 2-61
GarageDoorOpener
........................................... 2-61
GloveBox
................................................... 2-58
Other
....................................................... 2-65
SunVisors
..................................................... 2-55
Swing-Outwindows
............................................. 2-38
Storage Compartments
............................................ 2-58
T
Tachometer ..................................................... 2-69
Tailgate
......................................................... 2-8
Theft
........................................................... 2-9
Tiltwheel
...................................................... 2-39
Tires
.......................................................... 6-71
Chains
...................................................... 6-79
Flat
........................................................ 5-26
Balancing
................................................... 6-78
Changing a Flat
.......................................... 5.25, 5.32
Hub CapsNVheel Nut Caps
...................................... 5-32
InspectionRotation
....................................... 6-73. 6-75
Loading
..................................................... 2-39
New
........................................................ 6-76
Pressure
..................................................... 6-71
Spare (See “Spare Tire”)
Underbodycarrier
............................................ 5-29
Uniform Tire Quality Grading
................................... 6-77
TorqueLock
............................................... 2.29. 2.31
Towing
ATrailer
............................................... 4-38. 6.67
Maintenance
................................................. 4-44
Recommendations
............................................. 6-70
Turnsignals
................................................. 4-42
Following Distance
............................................ 4-42
9
ProCarManuals.com