1994 CHEVROLET TRACKER lock

ITEM
NO. SERVICE
6 Wheel Bearin? InsDection -
Inspect for wear and proper
adjustment. Relubricate the
bearings if grease is
contaminated.
7 Transmission (All) and
Transfer Case Differential
(Four-wheel Drive) Service
-
For the manual transmission and
transfer case differential, check
the fluid level every time the
oil is changed. See “Manual
Transmission Fluid” and
“Transfer Case” in the Index.
Inspect for damage and leaks
and change the fluid every
15,000 miles
(25 000 km) or
15 months for Schedule
I
conditions and every 30,000
miles (50 000 km) or 30 months
for Schedule
II conditions.
For the automatic transmission,
check the fluid level every time
the oil is changed. See
“Automatic Transmission
Fluid” in the Index. Inspect for
damage and leaks and change
ITEM
NO. SERVICE
8
9
the fluid every 15,000 miles
(25 0o0 km) or 15 months for
Schedule
I conditions and
100,000 miles ( 166 000 km) for
Schedule
I1 conditions. Replace
the automatic transmission cooler hoses every
45,000 miles
(75 000 km).
Propeller Shafts and U-Joints
Inspection
- Inspect for
looseness and damage.
Do this
every,.l5 months, or at 15,000
mile
(25 000 km) intervals, more
frequently if used off-road
or for
pulling a trailer. Tighten U-joint
flange bolts if necessary.
Freewheeling Hubs InsDection
/If Equipped) - Inspect the
locking front hubs for correct
operation. Repair or replace if
necessary. (Both hubs must
operate correctly for the front
axle to power the front wheels.)
ITEM
NO. SERVICE
10
11
Spark Plug Replacement” -
Replace spark plugs with the
proper type. See “Replacement Pans” in the Index.
Spark Plup Wire Replacement”
-
Replace wires. Check the boot fit
at the distributor and
at the spark
plugs. Operation in extreme cold
and/or on salted roads may require
more frequent replacement.
* An Emission Control Service.
t The U.S. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to perform this
maintenance item will not null@ the emission
warranty
or limit recall liability prior to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be pegormed at the
indicated intervals and the maintenance be
recorded
in “Section E: Maintenance
Record.
’’
215 ...
ProCarManuals.com

At Least Once a Month
r
CHECK
OR SERVICE I
I
WHAT TO DO
Tire Inflation Check tire inflation. Make sure they are
inflated to the pressures specified on the Tire-Loading
Information label located on
the driver’s door lock pillar. See “Tires” in the Index for
further details.
Cassette Deck Clean cassette
deck. Cleaning should be done every
15 hours of tape play. See “Audio Systems”
in the Index for further details.
I At least Twice a Year
CHECK
OR SERVICE WHAT TO DO
Fluid Level Check Check
the transfer case, axle differential(s) and automatic or manual transmission fluid levels
and. add as needed. See “Transfer Case,” “Axle, Rear” “Axle, Front” and “Automatic Trans-
mission” or “Manual Transmission”
in the Index. A fluid loss in these systems could indicate a
problem. Have the system inspected and repaired
at once.
219 ...
ProCarManuals.com

Maintenance Schedule
Section B: Owner Checks and Services (Cont.)
At Least Once a Year
CHECK
OR SERVICE
Key Lock Cylinders
Body Lubrication
Starter Switch
1
WHAT TO DO
Lubricate the key lock cylinders with the lubricant specified in Section D.
Lubricate all body door hinges. Also lubricate all hinges and latches, including those for the hood,
rear compartment, glove box door, console door and any folding seat hardware. Section D tells
you what to use.
1. Before you start, be sure you have enough room around the vehicle.
2. Firmly apply both the parking brake (see “Parking Brake” in the Index if necessary) and the
NOTE:
Do not use the accelerator pedal, and be ready to turn off the engine immediately if it
starts.
3. On automatic transmission vehicles, try to start the engine in each gear. The starter should
work only in
“P” (Park) or “N” (Neutral). If the starter works in any other position, your
vehicle needs service.
On manual transmission vehicles, put the shift lever in “N” (Neutral), push the clutch down
halfway and try to start the engine. The starter should work only when the clutch is pushed
down all
the way to the floor. If the starter works when the clutch isn’t pushed all the way
down, your vehicle needs service.
regular brake.
- . .220
ProCarManuals.com

At Least Once a Year (CONT.)
CHECK
OR SERVICE
Brake Transmission
Shift Interlock
- BTSI
(Automatic Transmis-
sion)
Steering Column Lock
WHAT TO DO
1. Before you start, be sure you have enough room around the vehicle. It should be parked on a
2. Firmly apply the parking brake. (See “Parking Brake” in the Index if necessary).
NOTE: Be ready to apply the regular brake immediately if the vehicle begins to move.
3. With the engine off, turn the key to the “ON” position, but don’t start the engine. Without
level surface.
applying the regular brake, try
to move the shift lever out of “P” (Park) with normal effort,
If the shift lever moves out
of “P” (Park) , your vehicle’s BTSI needs service.
While parked, and with the parking brake set, try
to turn the key to “LOCK” in each shift lever
position.
0 With an automatic transmission, the key should turn to “LOCK” only when the shift lever is
With a manual transmission, the key will turn to “LOCK” only if you push the key in farther,
On vehicles with
the key release lever, try to turn the key to “LOCK” without pressing the lever.
The key should
turn to “LOCK” only with the key lever depressed. On all vehicles, the key
should come out only
in “LOCK”.
in
“P” (Park).
while turning
it towards “LOCK.”
!
I
I
I’
LLI . . . ProCarManuals.com

Maintenance Schedule
Section C: Periodic Maintenance Inspections (cont.)
INSPECTION
OR SERVICE
Rear Axle (All) and
Front Axle (Four-
Wheel Drive) Service
Brake System
Inspection
Clutch System Service
WHAT SHOULD BE DONE
Check the gear lubricant level and add if needed. See “Rear Axle” and “Four-Wheel Drive” in
the Index. A fluid loss may indicate a problem. Check the system(s), and repair the system(s) if
needed. Refer to “Scheduled Maintenance Services,” earlier in
this part, to determine when to
change the lubricant.
Inspect the complete system. Inspect brake lines and hoses for proper hookup, binding, leaks,
cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also
inspect
drum brake linings for wear and cracks. Inspect other brake parts, including drums,
wheel cylinders, calipers, parking brake, etc. Check parking brake adjustment. You may need to
have your brakes inspected more often if your driving habits or conditions result in frequent
braking.
NOTE: A low brake fluid level can indicate worn disc brake pads which may need to be serv-
iced. Also,
if the brake system warning light stays on or comes on, something may be wrong
with either the regular or rear wheel anti-lock brake system, or both systems. See “Brake System
Warning Light” in the Index.
Check clutch pedal free travel and adjust
as necessary. See “Clutch Adjustment” in the Index. ..
. . .224
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids & Lubr
USAGE
Key Lock Cylinders Manual Transmission
Shift Linkage
Automatic
Transmission
Shift Linkage
Clutch Linkage Pivot Points
Floor Shift Linkage
Chassis Lubrication
*icants (Cont.)
FLUID/LUBRICANT
Lubricate with Multi-Purpose Lubricant (GM Part No. 12345120) or synthetic SAE 5W-30
engine oil.
Chassis lubricant
(GM Part No. 1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade 2, Category LB or GC-LB.
Engine oil.
Lithium base grease.
Engine oil.
Chassis lubricant (GM Part No.
1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade
2, Category LB or GC-LB.
. .226
ProCarManuals.com

w Chevrolet/Geo
Roadside Assistance
Program
To enhance Chevrolet/Geo's strong
commitment to customer satisfaction,
Chevrolet/Geo is excited to provide the
services of the Chevrolet/Geo Roadside
Assistance Center.
Roadside Assistance is available 24 hours
a day,
365 days a year, by calling
This toll-free number will provide you
over-the-phone roadside assistance with
minor mechanical problems. If your
problem cannot be resolved over the
phone,
our advisors have access to a
nationwide network
of dealer
1 -800-CHEV USA (1 -800-243-8872). recommended service
providers. The
following services are available:
0 Towing
0 Locksmith
0 Tire Repair
0 Rental car or taxi
0 Additional services as necessary
The Roadside Assistance Center uses
companies that will provide you with
quality and priority service. When
roadside services are required, our advisors will explain any payment
obligations that may be incurred for
utilizing outside services.
For prompt assistance when calling,
please have the following available to
give to the advisor:
0 Vehicle Identification Number
0 License plate number
Vehicle color
0 Vehicle location
0 Telephone number where you can be
0 Vehicle mileage
0 Description of problem
reached
Canadian Roadside
Assistance
Vehicles purchased in CANADA have an
extensive ROADSIDE ASSISTANCE
Program accessible from anywhere in
Canada or the U.S.A. Please refer to the
separate brochure provided by the dealer
or call 1-800-268-6800 for emergency
services.
w Courtesy Transportation
Chevrolet/Geo offers Courtesy
Transportation for customers needing
warranty service. Courtesy Transportation
will be offered in conjunction with the
coverage provided by the BUMPER TO
BUMPER New Vehicle Limited Warranty
to retail and retail lease purchasers of
1994 ChevroletlGeo passenger cars and
light-duty trucks.
Courtesy Transportation includes:
0 One-way SHUTTLE RIDE for any
warranty repair completed during the
same day.
0 Up to $30 maximum daily VEHICLE
RENTAL allowance for any overnight
warranty repair up
to 5 days.
OR
237.. .
ProCarManuals.com

A bout Driving Your Tracker ..... 3
ABS ......................... 103
Adding Coolant ................ 171
Additives. Engine
Oil ............ 165
Adjustment. Clutch
............. 169
Air Cleaner .................... 165
Air Conditioner Controls
......... 85
Air Filter Replacement
........... 166
Air Intake Lever ................ 84
Airflow Lever
.................. 84
Alignment and Tire Balance
.
Wheel ...................... 187
Aluminum Wheels
.............. 193
AM/FM Stereo
................ 88
With Cassette Tape and Compact
Disc Player
................ 93
With Cassette Tape Player ...... 89
Antenna
...................... 98
Anti-Lock Brakes
.............. 103
To Use ..................... 103
Appearance Care ............... I89
Appearance Care and Materials
.... 195
Appearance Care. Service and
..... 155
Approaching
a Hill .............. 1 10
Ashtrays and Lighter ............ 62
Ashtray. Front
................. 63
Ashtray. Rear .................. 63
Assist Grips. Passenger .......... 62
Add-on
Electrical Equipment
..... 196
Adjustable Steering Column
...... 53
Audio Systems ................. 87
Audio Systems. Comfort
Controls and
................. 83
Automatic
Freewheeling Hubs
........... 47
Transmission
................ 42
Transmission Fluid ............ 167
Axle. Front
.................... 170
Axle
. Rear .................... 169
Babies. Smaller Children
and (Safety Belts)
............. 26
Balance. Wheel Alignment
and Tire
.................... 187
Battery
....................... 176
BBB Auto Line
- Alternative Dispute
Resolution Program. GM
Participation
in ............. 235
Before Leaving
on a Long Trip .... 120
Belt. Lap-Shoulder .............. 20
Bi-Level ...................... 84
Bin. Coinholder and ............. 61
Bins. Instrument Panel ........... 61
Blizzard. If You’re Caught in a ... 124
Box. Glove
.................... 60
Brakes
Adjustment
.................. 176
Anti-Lock (ABS)
............. 103
Fluid ....................... 1 74
Master Cylinder
.......... 174
Parking
......... 48 Brakes
Pedal Travel
................. i76
System Parts. Replacing ........ 176
System Warning Light
......... 69
Trailer ...................... i27
Wear ...................... 175
Braking (Control of
a Vehicle) ..... 102
Braking
in Emergencies .......... 104
“Break.In. .. New Vehicle ........ 39
Bright Metal Parts. Protecting
Exterior
.................... 192
Brightness Control
.............. 57
Bulb Replacement .............. 177
Stoplight .................. 181
Headlights .................. 177
Rear Combination
............ 180
Rear Sidemarker
.............. 179
Sidemarker ......... . .179
Bulbs. Halogen
............... 177
Bulbs. Replacement
............. 199
Canadian Roadside Assistance ... 237
Canvas Top
Preparing for Storage
.......... 80
Special Care for
.............. 193
Capacities and Specifications
...... 200
Carbon Monoxide .............. 51
Center High-Mounted
Front Parking and Turn Signal
... 178
Removing and Installing Your
... 76
243 ...
ProCarManuals.com