1994 CHEVROLET TRACKER transmission oil

Service and Appearance Care
Then, without shutting off the engine,
follow these steps:
1. Pull out the dipstick and wipe it with a
clean rag or paper towel.
2. Push it back in all the way, wait three
seconds and then pull it back out
again.
. . .I68
~
3. Check both sides of the dipstick, and
read the lower level. The fluid level
must be in the “COLD’ area for a
cold check or
in the “HOT” area or
cross-hatched area for a hot check.
4. If the fluid level is in the acceptable
range, push the dipstick back
in all
the way.
How to Add Fluid
Refer to the Maintenance Schedule to
determine what kind of transmission fluid
to use. See “Recommended Fluids and
Lubricants”
in the Index.
[f the fluid level is low, add only enough
of the proper fluid to bring the level up to
the “COLD” area for a cold check or the
“HOT” area for a hot check. It doesn’t take
much fluid, generally less than a
pint.
Don’t overfill. We recommend you use
only fluid labeled DEXRON@-III
or
DEXRON@-IIE, because fluids with that
label are made especially for
your
automatic transmission. Dama e caused
by fluid other than DEXRON
8 -m or
DEXRON@-IIE is not covered by your
new vehicle warranty.
0 After adding fluid, recheck the fluid
level as described under “How to
Check.”
obtained, push
the dipstick back in
all the way.
When the correct fluid level is
Manual Transmission Fluid
When to Check and Change
A good time to have it checked is when
the engine oil is changed. Refer to the
Maintenance Schedule to determine when
to change your transmission fluid. See
“Scheduled Maintenance Services”
in the
Index.
How to Check:
Because this operation can be a little
difficult, you may choose to have this
done at your Geo dealership Service
Department.
ProCarManuals.com

Capacities (Approximate)
The following approximate capacities are given in U.S. and metric conversions.
Air Conditioning”
............. See the refrigerant information label under hood.
Automatic Transmission Drain and Refill
....................................... 3.0 qt. (2.8 L)**
Overhaul ............................................. 5.4 qt. (5.1 L)
Automatic Transmission ................................ 5.5 qt. (5.2 L)
Manual Transmission ................................... 5.6 qt. (5.3 L)
With Filter Change ..................................... 4.5 qt. (4.2 L)*
Without Filter Change .................................. 4.2 qt. (4.0 L)
Front Differential ........................................ 1.1 qt. (1 .O L)
Fuel Tank ............................................. 11.1 gal. (42 L)
Manual Transmission
Cooling System
Crankcase
Four-wheel Drive
.................................... 1.6 qt. ( 1.5 L) **
Two-Wheel Drive ..................................... 1.8 qt. (1.7 L) **
Rear Differential ........................................ 2.3 qt. (2.2 L)
Transfer Case ........................................... 1.8 qt. ( 1.7 L)
T Not all air conditioning refrigerants are the same. If the air conditioning system
in your vehicle needs refrigerant, be sure the proper refrigerant is used. If you’re
not sure, ask your Geo dealer.
* When changing the oil filter, additional oil may be needed. Recheck the oil level
after filling. See “Engine Oil”
in the Index.
** Recheck fluid level after filling. See “Automatic Transmission Fluid” or “Manual
Transmission Fluid”
in the Index.
201 ...
ProCarManuals.com

ITEM
NO. SERVICE
6 Wheel Bearin? InsDection -
Inspect for wear and proper
adjustment. Relubricate the
bearings if grease is
contaminated.
7 Transmission (All) and
Transfer Case Differential
(Four-wheel Drive) Service
-
For the manual transmission and
transfer case differential, check
the fluid level every time the
oil is changed. See “Manual
Transmission Fluid” and
“Transfer Case” in the Index.
Inspect for damage and leaks
and change the fluid every
15,000 miles
(25 000 km) or
15 months for Schedule
I
conditions and every 30,000
miles (50 000 km) or 30 months
for Schedule
II conditions.
For the automatic transmission,
check the fluid level every time
the oil is changed. See
“Automatic Transmission
Fluid” in the Index. Inspect for
damage and leaks and change
ITEM
NO. SERVICE
8
9
the fluid every 15,000 miles
(25 0o0 km) or 15 months for
Schedule
I conditions and
100,000 miles ( 166 000 km) for
Schedule
I1 conditions. Replace
the automatic transmission cooler hoses every
45,000 miles
(75 000 km).
Propeller Shafts and U-Joints
Inspection
- Inspect for
looseness and damage.
Do this
every,.l5 months, or at 15,000
mile
(25 000 km) intervals, more
frequently if used off-road
or for
pulling a trailer. Tighten U-joint
flange bolts if necessary.
Freewheeling Hubs InsDection
/If Equipped) - Inspect the
locking front hubs for correct
operation. Repair or replace if
necessary. (Both hubs must
operate correctly for the front
axle to power the front wheels.)
ITEM
NO. SERVICE
10
11
Spark Plug Replacement” -
Replace spark plugs with the
proper type. See “Replacement Pans” in the Index.
Spark Plup Wire Replacement”
-
Replace wires. Check the boot fit
at the distributor and
at the spark
plugs. Operation in extreme cold
and/or on salted roads may require
more frequent replacement.
* An Emission Control Service.
t The U.S. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to perform this
maintenance item will not null@ the emission
warranty
or limit recall liability prior to the
completion
of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be pegormed at the
indicated intervals and the maintenance be
recorded
in “Section E: Maintenance
Record.
’’
215 ...
ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids & Lubricants
NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM Dealer.
USAGE
Engine Oil
Engine Coolant
Hydraulic Brake
System
Parking Brake Guides
Power Steering
System
Manual Transmission
Automatic
Transmission
FLUID/LUBRICANT
API service SH or SG Energy Conserving I1 oils of the proper viscosity. The “SH” or “SG”
designation may be shown alone or in combination with others, such as
“SH/CD,” or “SH, SG,
CD,” “SGKD,” etc. To determine the preferred viscosity for your vehicle’s engine, see “Engine
Oil”
in the Index.
50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze
(GM Part
No. 1052753 or equivalent) conforming to GM Specification 1825M or approved
recycled coolant conforming to GM Specification
1825M.
Delco-Supreme 11’” Brake Fluid (GM Part No. 1052535 or equivalent DOT-3 brake fluid).
Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade
2, Category LB or GC-LB.
DEXR0N’-IIE Automatic Transmission Fluid.
SAE
75W-90 GL-4 (GM Part No. 12346074 Castrol‘ Syntorq GL-4 or equivalent) or SAE
75W-90 GL-5 Gear Lubricant.
DEXRON3-III
or DEXRON”-IIE Automatic Transmission Fluid.
225. . . ProCarManuals.com

Maintenance Schedule
Section D: Recommended Fluids & Lubr
USAGE
Key Lock Cylinders Manual Transmission
Shift Linkage
Automatic
Transmission
Shift Linkage
Clutch Linkage Pivot Points
Floor Shift Linkage
Chassis Lubrication
*icants (Cont.)
FLUID/LUBRICANT
Lubricate with Multi-Purpose Lubricant (GM Part No. 12345120) or synthetic SAE 5W-30
engine oil.
Chassis lubricant
(GM Part No. 1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade 2, Category LB or GC-LB.
Engine oil.
Lithium base grease.
Engine oil.
Chassis lubricant (GM Part No.
1052497 or equivalent) or lubricant meeting requirements of
NLGI Grade
2, Category LB or GC-LB.
. .226
ProCarManuals.com

A bout Driving Your Tracker ..... 3
ABS ......................... 103
Adding Coolant ................ 171
Additives. Engine
Oil ............ 165
Adjustment. Clutch
............. 169
Air Cleaner .................... 165
Air Conditioner Controls
......... 85
Air Filter Replacement
........... 166
Air Intake Lever ................ 84
Airflow Lever
.................. 84
Alignment and Tire Balance
.
Wheel ...................... 187
Aluminum Wheels
.............. 193
AM/FM Stereo
................ 88
With Cassette Tape and Compact
Disc Player
................ 93
With Cassette Tape Player ...... 89
Antenna
...................... 98
Anti-Lock Brakes
.............. 103
To Use ..................... 103
Appearance Care ............... I89
Appearance Care and Materials
.... 195
Appearance Care. Service and
..... 155
Approaching
a Hill .............. 1 10
Ashtrays and Lighter ............ 62
Ashtray. Front
................. 63
Ashtray. Rear .................. 63
Assist Grips. Passenger .......... 62
Add-on
Electrical Equipment
..... 196
Adjustable Steering Column
...... 53
Audio Systems ................. 87
Audio Systems. Comfort
Controls and
................. 83
Automatic
Freewheeling Hubs
........... 47
Transmission
................ 42
Transmission Fluid ............ 167
Axle. Front
.................... 170
Axle
. Rear .................... 169
Babies. Smaller Children
and (Safety Belts)
............. 26
Balance. Wheel Alignment
and Tire
.................... 187
Battery
....................... 176
BBB Auto Line
- Alternative Dispute
Resolution Program. GM
Participation
in ............. 235
Before Leaving
on a Long Trip .... 120
Belt. Lap-Shoulder .............. 20
Bi-Level ...................... 84
Bin. Coinholder and ............. 61
Bins. Instrument Panel ........... 61
Blizzard. If You’re Caught in a ... 124
Box. Glove
.................... 60
Brakes
Adjustment
.................. 176
Anti-Lock (ABS)
............. 103
Fluid ....................... 1 74
Master Cylinder
.......... 174
Parking
......... 48 Brakes
Pedal Travel
................. i76
System Parts. Replacing ........ 176
System Warning Light
......... 69
Trailer ...................... i27
Wear ...................... 175
Braking (Control of
a Vehicle) ..... 102
Braking
in Emergencies .......... 104
“Break.In. .. New Vehicle ........ 39
Bright Metal Parts. Protecting
Exterior
.................... 192
Brightness Control
.............. 57
Bulb Replacement .............. 177
Stoplight .................. 181
Headlights .................. 177
Rear Combination
............ 180
Rear Sidemarker
.............. 179
Sidemarker ......... . .179
Bulbs. Halogen
............... 177
Bulbs. Replacement
............. 199
Canadian Roadside Assistance ... 237
Canvas Top
Preparing for Storage
.......... 80
Special Care for
.............. 193
Capacities and Specifications
...... 200
Carbon Monoxide .............. 51
Center High-Mounted
Front Parking and Turn Signal
... 178
Removing and Installing Your
... 76
243 ...
ProCarManuals.com

1 Keys ....................... 36
Label. Certification/Tire
........ 18 1
Label. Service Parts Identification . . 196
Lamp. Malfunction Indicator
...... 7 1
Lane Change Indicator.
Turn Signal and
.............. 54
Lap-Shoulder Belt (Safety Belts)
... 20
Larger Children (Safety Belts)
..... 32
Leaving Your Vehicle
............ 37
Leaving Your Vehicle with the
Engine Running
.............. 49
Lighter. Ashtrays and
............ 62
Lights Brake System Warning
......... 69
Bulb Replacement
............ 177
Charging System
............. 70
Check Engine
................ 71
Daytime Running ............. 56
Daytime Running Lights
Indicator
.................. 72
Dome
...................... 57
Engine Oil Pressure
........... 71
Gages and Indicators. Warning
. . 68
Interior ..................... 57
Malfunction Indicator Lamp
.... 71
Operation
of ................. 55
Safety Belt Reminder .......... 19
Lights On Reminder
............. 55
Loading Your Vehicle .... . 181 Locks.
Door ................... 37
Loss of Control
................ 107
Lubricant Front Axle
.................. 170
Rear Axle
................... 169
Recommended
............... 225
Transfer Case
................ 170
Main Fuse Block
............. 198
Maintenance Inspections. Periodic
.......... 223
Record
..................... 228
Schedule
.................... 203
Services. Scheduled
........... 206
Underbody
.................. 194
When Trailer Towing
.......... 129
Malfunction Indicator Lamp
...... 71
Manual
Adjust Mirrors. Outside
........ 60
Freewheeling Hubs ........... 46
Transmission Fluid
............ 168
Windows
................... 52
Master Cylinder. Brake
.......... 174
Mirrors Convex Outside
.............. 59
Inside Daymight Rearview
..... 59
Inside Rearview
.............. 59
Outside Manual Adjust
........ 60
Mountain Roads. Hill and ........ 121
Transmission. Five-Speed
...... 44 New
Vehicle “Break-In”
....... 39
Night Driving
.................. 116
Night Vision
................... 117
Nuts. Wheel
................... 202
Odometer. Speedometer and
..... 66
Odometer. Trip
................. 67
Off-Road Driving After
....................... 116
Before You Go
............... 108
Getting Familiar With
......... 109
Loading Your Vehicle for
....... 108
On Hills
.................... 110
With Your Geo Four-Wheel-Drive
Vehicle
................... 108
Off-Road Recovery
............. 105
Oil. Engine .................... 162
Opening and Closing Your Rear
Window
.................... 75
Opening and Closing Your
sunroof ..................... 74
Operation
of Lights ............. 55
Outside Manual Adjust Mirrors .... 60
Overheating. Engine
............ 140
Owner Checks and Services
....... 218
P (Park) Shifting into ...
P (Park). Shifting out of ...
.... 48
.... 49
247 ... ProCarManuals.com

Index
Steam Corning from Your Engine . . 140
Column. Adjustable
........... 53
Fluid. Power ................. 173
Power
...................... 104
Steering
...................... 104
In Emergencies ............... 105
Tips
........................ 104
Compartments. Door
.......... 60
Storage
Preparing Your Canvas Top for
. . 80
Vehicle
..................... 176
Stuck: In Sand. Mud. Ice or Snow
. . 153
Sun Visors
.................... 61
Sunroof. Opening and Closing
Your
....................... 74
Switch. Ignition
................ 39
Symbols. Vehicle
............... 7
Symbols. Safety Warnings and .... 5
Tachometer .................. 68
Tailgate
....................... 38
Tank. Filling Your .............. 158
Temperature Control Lever ....... 84
Terrain. Scanning
the ............ 109
Theft ......................... 39
Theft Deterrent Feature AM/FM Stereo
with Cassette Tape
AM/FM Stereo
with Cassette Tape
and Compact Disc Player
..... 96
Player
.................... 91
Thermostat .................... 172
... 250
Tips. Steering ................ 104
Tips. Ventilation
................ 87
Tires
......................... 183
Balance. Wheel Alignment and
. . 187
Buying New ................. 186
Chains
..................... 188
Inflation Pressure
............. 184
Inspection and Rotation
........ 185
Temperature Grades
........... 187
Traction Grades
.............. 187
Treadwear
................... 186
Uniform Quality Grading
....... 186
When It’s Time for New
....... 186
AM/FM Stereo
............... 89
and Compact Disc Player
..... 93
Player
.................... 90
Top Strap (Child Restraints)
....... 28
Top. Convertible
................ 72
Torque
Lock .................. 49
Towing
A Trailer .................... 125
Rear Hook-Ups
.............. 139
Recreational Vehicle
.......... 129
Your Vehicle
................. 136
Trailer Brakes
.................. 127
Changing a Flat .............. 146
Loading
.................... 18 I
Tone. Setting the
AM/FM Stereo
with Cassette Tape
AM/FM Stereo
with Cassette Tape
Front Hook-Ups
.............. 138 Trailer. Towing
a
............... 125
Transfer Case
.................. 47
Transfer Case (Service)
.......... 170
Transmission Automatic
................... 42
Fluid. Automatic
............. 167
Fluid. Manual
................ 168
Manual
..................... 44
Transportation. Courtesy
......... 237
Traveling to Remote Areas
....... 109
Trip Odometer
................. 67
Trip. Before Leaving on a Long
.... 120
Turn Signal and Lane Change
Indicator
.................... 54
Turn SignalLights Control/Headlight
Beam Lever
................. 54
Underbody Maintenance ....... 194
Understanding Radio Reception ... 97
Uniform Tire Quality Grading
..... 186
Uphill. Driving ................. 111
Used Oil. What to Do With ....... 165
Used Replacement Wheels
........ 189
Using the Recovery Hooks ....... 154
Vehicle Control of a
................. 102
Damage Warnings ............ 6
Dimensions ................. 202
Environment and Your
......... 204
Identification Number
(VIN) .... 196
ProCarManuals.com