1994 CHEVROLET ASTRO PASSENGER fuel filter

Downloaded from www.Manualslib.com manuals search engine Cooling System Capacity
ENGINE
4.3L
4.3L
VIN CODE
Z
w
QUANTITY* Without Rear
Heater
13.5 Quarts
( 12.8 Liters)
13.5 Quarts
(12.8 Liters)
QUANTITY*
With Rear Heater
16.5 Quarts
( 15.5 Liters)
16.5 Quarts
( 15.5 Liters)
*All quantities are approximate. After refill,
the level MUST be checked.
Crankcase Capacity
ENGINE
4.3L
4.3L
VIN CODE
Z
w
QUANTITY*
Without Filter
4 Quarts
(3.8 Liters)
4 Quarts
(3.8 Liters)
QUANTITY*
With Filter
4.5 Quarts
(4.3 Liters)
4.5 Quarts
(4.3 Liters)
*All quantities are approximate. After refill, the level MUST be checked.
Do not overfill.
Fuel Tank Capacity
TYPE
Standard Tank
*All quantities are approximate.
QUANTITY*
27 Gallons (102 Liters)
6-69

Downloaded from www.Manualslib.com manuals search engine NAME
DRL**
PWR
MIRRORS*
TRAILER*
CIRCUITS
PROTECTED
Canadian Daytime Running
Lights
Power Mirror
Trailer Wiring Harness
FUSE
10 Amp
3 Amp
30 Amp
*In-line fuse
**Canada only
***In-line fuse (certain models)
Service Replacement Part and Filter
Recommendations
ENGINE (VIN)
OIL FILTER
AIR CLEANER FILTER
PCV VALVE
SPARK PLUGS*
FUEL FILTER
RADIATOR CAP 4.3L (2)
PF52
A773C
CV789C
.CR43TSM
GF48
1
RC36
*Use copper-cored resistor type spark plugs.
CIRCUIT
BREAKER
4.3L
(W)
PF52
A1163C
cv774c
.CR43TSM GF48
1
RC36
6-74

Downloaded from www.Manualslib.com manuals search engine MAlNTENANCE SCHEDULE I/
Item Miles (000) 7.5 15 22.5 30
No. Kilometers (000) 12.5 25 37.5 50
Service
Oil Filter Change*- 12 Months, or
1 12 Months, or I 1 1 I
2 Chassis Lubrication-Every
3 Cooling System Service*
-Every
24 Months or
4 I Air Cleaner Filter Replacement* I I I I 0
5 Front Wheel Bearing Repack
(2WD Only) 0
6 Transmission Service **
7 Fuel Filter Replacement*$ 0
8 Spark Plug Replacement* 0
9 Spark Plug Wire Inspection*
10 Engine Timing Check*$
11 Fuel Tank, Cap and Lines
12 Engine Accessory Drive Belt
13 Tire and Wheel Rotation
0 0
14 Drive Axle Service 0.00
15 Brake Systems Inspection** Inspection*$
Inspection”
* An Emission Control Service
** See “Explanation of Scheduled Maintenance Services” in the Index
$ The California Air Resources Board has determined that the fail\
ure to perform this
maintenance item will not nullify the emission warranty or limi\
t recall liability prior
to the
completion
of vehicle useful life. General Motors, however, urges that all recommended
maintenance services be performed at the indicated intervals and\
the maintenance be
recorded.
THE SERVICES SHOWN
ON THIS CHART UP TO 60,000 MILES (100 000 km) ARE TO BE
DONE AFTER
60,000 MILES AT THE SAME INTERVALS.
TI 003
7-6

Downloaded from www.Manualslib.com manuals search engine 6. TRANSMISSION SERVICE: - Change the transmission fluid and
filter every
15,000 miles (25 000 km) if the vehicle is mainly driven
under
one or more of these conditions:
In heavy city traffic.
Where the outside temperature regularly reaches 90 “F (32” C) or
In hilly or mountainous terrain.
higher.
Frequent trailer pulling.
0 Uses
such as taxi, police, delivery or other commercial service.
If the vehicle
is not used mainly under any of these conditions, change
the fluid and filter every
30,000 miles (50 000 km). See “Automatic
Transmission Fluid” in the Index for more information.
7. FUEL FILTER REPLACEMENT*$ - Replace the fuel filter at the
specified interval or sooner if clogged.
8. SPARK PLUG REPLACEMENT* - Replace spark plugs with the
type listed in Section
6. See “Specification Charts” in the Index.
9. SPARK PLUG WIRE INSPECTION* - Clean wires and inspect
for bums, cracks or other damage. Check the wire boot fit at the
distributor and at the spark plugs. Replace wires as needed.
Adjust timing to underhood label specifications. Inspect the inside and
outside
of the distributor cap and rotor for cracks, carbon tracking and
corrosion. Clean or replace as needed.
10. ENGINE TIMING CHECK AND DISTRIBUTOR CHECK*$ -
11. FUEL TANK, CAP AND LINES INSPECTION*$ - Inspect the
fuel tank, cap and lines for damage or leaks. Remove fuel cap, inspect
gasket for an even filler neck imprint, and any damage. Replace parts
as needed.
12. ENGINE ACCESSORY DRIVE BELT INSPECTION* - Inspect
belt.
Look for cracks, fraying, wear, and proper tension. Adjust or
replace as needed.
* An Emission Control Service
$ The California Air Resources Board has determined that the failure to perform \
this
maintenance item will not nullify the emission warranty or limit recall liability prior to the
completion of vehicle useful life. General Motors, however, urges that all re\
commended
maintenance services be performed at the indicated intervals and\
the maintenance be
recorded.
7-8

Downloaded from www.Manualslib.com manuals search engine Exhaust System ................................................. 6-43
F
FanNoise ...................................................... 5-18
Filter Replacement Chart
.......................................... 6-74
Finish
Care
........................................................ 6-59
Damage
..................................................... 6-61
Automatic Transmission
........................................ 6-20
Brake
....................................................... 6-32
Capacities
................................................... 6-69
CoolantRecovery
............................................. 5-14
FrontAxle
................................................... 6-25
Leak Check
.................................................. 6-36
Powersteering
............................................... 6-30
Radiator
..................................................... 5-15
Rear Axle
................................................... 6-24
RecommendedFluids
.......................................... 7-13
Transfercase
................................................ 6-24
Windshield Washer
............................................ 6-31
FogLamps
..................................................... 2-42
Four-wheel Anti-lock
............................................. 4-7
Frontseats
...................................................... 1-2
Fuel
........................................................... 6-3
FillingYourTank
.............................................. 6-5
Foreign Countries
.............................................. 6-5
Gage
....................................................... 2-61
Gasolines for Cleaner Air
........................................ 6-4
Tankcapacity ................................................ 6-69
Fuses and Circuit Breakers
........................................ 6-72
FuseBlock
.................................................. 6-67
Headlights
................................................... 6-66
Power Windows and Other Power Options
......................... 6-66
Trailer Wiring Harness
......................................... 6-66
Windshield Wipers
....................... .............. 6-66
Fluid
G
Gages ......................................................... 2-61
Coolant Temperature Gage
...................................... 2-63
FuelGage
................................................... 2-61
Odometer
................................................... 2-53
Oil Pressure Gage
............................................. 2-62
Speedometer
................................................. 2-53
Trip Odometer
................................................ 2-53
Voltmeter
.................................................... 2-64
Gasolines for Cleaner Air
.......................................... 6-4
Hatch Release Switch ............................................. 2-28
HalogenBulbs
........................................ ....... 6-36