1994 CHEVROLET ASTRO PASSENGER cruise control

Downloaded from www.Manualslib.com manuals search engine Instrument Panel
14 13
27
/
1. Light Switches
2. Dimmer Switch
3. Instrument Cluster
4. Gearshift Lever
5. Air ConditionedHeater
6. Fog Light Switch
7. Remote Outside Mirror Switch
8. Rear Heater Switch
9. Rear A/C Switch
10. Interior Light Override Switch
11. Audio System
12. Convenience Tray
13. Glove
Box
14. Ashtray
15. Cigarette Lighter
16.
Hood Release Handle
17. Hazard Warning Flasher
18. Ignition Switch
19. Horn
20. Brake Release Handle
2
1. Multifunction Lever
22. Cruise Control
23. Tilt Wheel Lever
24. Rear Wipermasher Switch
25. Hatch Release Switch
26. Rear Window Defogger Switch
27. Vent

Downloaded from www.Manualslib.com manuals search engine Air Conditioning
Every now and then have your dealership check your air conditioning
system to be sure it has not
lost any cooling ability. If you think the system
is not working properly, have your dealership
check it out as soon as
possible.
The air conditioning will not work when the temperature is below
40°F
(4 O C).
Lubrication
Accelerator Control System
Refer to the Maintenance Schedule to determine how often the accelerator
linkage pivot points must be lubricated and what type of lubricant
to use.
Accelerator cables and cruise control cables should not be lubricated. Any
cables that are worn or are hard to pull should be replaced.
When cleaning the engine compartment with water or steam, avoid directing
the flow onto the throttle linkage in a manner that would cau\
se moisture
to
enter the cables.
Hood Latches and Hood Hinge
Refer to the Maintenance Schedule to determine how to lubricate the hood
latch and hood hinge assembly.
Sliding Door Tracks
Your vehicle’s sliding door has three tracks which need lubrication.
For the upper and lower tracks, open the door, wipe the track\
clean and then lubricate with Lubriplate
TM White Grease.
For the outside middle track, close
the door after you finish the upper and
lower tracks. Then, wipe
the track clean and lubricate with
Lubriplate
TM White Grease.
Body
Normal use of your vehicle will cause metal to metal wear at some points on
the cab and body
if they are not lubricated.
For exposed surfaces, such as door checks, door lock bolts, lock striker
plates, dovetail bumper wedges, etc., a thin film
of engine oil should be
applied.
Where oil holes are provided in the body or cab, a dripless oil can be used.
The seat adjusters and seat track should be lubricated with chassis grease.
6-42

Downloaded from www.Manualslib.com manuals search engine NAME
INST LPS
CIRCUITS
PROTECTED
Instrument Panel Lamps,
Radio Dial Lamps, Heater
Lamps
PWR ACCY Power Door Locks, Power
CIG LTWDM Digital Clock, Cigarette Seat
Lighter,
Dome Lights,
Radio Memory, Glove Box
Lamp
GAGES
AUX
HTR-A/C STOP-HAZ Instrument Cluster Gages,
Brake
Switch, Audio
Alarm, Headlight Switch
Illumination, Ash Tray
Illumination, Cruise
Control
Auxiliary Heater-Rear A/C (if equipped)
Stop Lamps, Hazard Flash,
Digital Instrument Cluster
HORN/TL Headlamp Switch, Tail and
LMPS Parking Lamps, Horn
Relay
TURN-B/U Direction Signal Flash,
Back Up Lamps
HTR A/C
RADIO
ECM B
ECM I
PWR WDO
AIR BAG
WIPER
BRAKE
FOG
LAMPS*** Front Heater
& Air
Conditioning
Radio
Engine Control Module
Engine Control Module
Power Windows
Air Bag
Windshield Wiper
Anti-Lock Brake System, Speedometer
Fog Lamps
FUSE
10 Amp
CIRCUIT
BREAKER
30 Amp
20 Amp
20 Amp
25 Amp
20 Amp
20 Amp
20 Amp
20 Amp
10 Amp
15 Amp
10 Amp
30 Amp
10 Amp
25 Amp
15 Amp
15 Amp
6-73

Downloaded from www.Manualslib.com manuals search engine Periodic Maintenance Inspections
Listed below are inspections and services which should be perfo\
rmed at
least twice a year (for instance, each spring and fall). You should let your
GM dealer’s service department or other qualified service center do these
jobs. Make sure any necessary repairs are completed at once.
Steering and Suspension Inspection? - Inspect front and rear suspension
and steering system for damaged, loose or missing parts, signs of wear or
lack of lubrication. Inspect power steering lines and hoses for proper
hook-up, binding, leaks, cracks, chafing, etc. Lubricate the steering linkage.
Accelerator Control System - Lubricate all pivot points with engine oil,
except the
TBI throttle shaft. Do not lubricate the cam pulley. Remove all
external deposits from pulley.
Do not oil any accelerator or cruise control
cables. Replace any cables that have high effort or excessive \
wear.
Exhaust System Inspection - Inspect the complete system. Inspect the
body near the exhaust system. Look for broken, damaged, missing or
out-of-position parts, as well as open seams, holes, loose conn\
ections or
other conditions which could cause a heat buildup
in the floor pan or could
let exhaust fumes seep into the passenger compartments. See “\
Engine
Exhaust”
in the Index.
Drive Axle Service - Check readfront axle fluid level and add as needed.
Check constant velocity joints and axle seals for leaking.
Transfer Case (all-wheel drive) Inspection? - Every 12 months or at oil
change intervals, check front axle and transfer case and add l\
ubricant when
necessary. Oil the control lever pivot point (except
L Van) and all exposed
control linkage. Check vent hose at transfer case for kinks and proper
installation.
-F A fluid loss in these systems may indicate a problem. Have them inspected a\
nd
repaired
at once.
7- 12

Downloaded from www.Manualslib.com manuals search engine Trailer ...................................................... 4-26
Wear Indicators ............................................... 6-34
Braking ......................................................... 4-5
In Emergencies ................................................ 4-7
Break-In. New Vehicle ........................................... 2-12
Bulb Replacement ............................................... 6-36
Halogen ..................................................... 6-36
Replacement Chart .......................................... 6-70
Carbon Monoxide .......................................... 2-27. 4-27
Capacities and Specifications ....................................... 6-68
CassetteTapePlayer ............................................. 3-15
Catalyticconverter .............................................. 6-43
Certificatioflire Label ........................................... 6-44
Changing A Flat Tire ........................................ 5-19. 5-24
Charging System Light ........................................... 2-59
Chemical Paint Spotting ........................................... 6-61
Cigarette LightedAshtrays ......................................... 248
Cleaning ....................................................... 6-55
Glass ....................................................... 6-58
Inside of Vehicle .............................................. 6-55
Instrument Panel .............................................. 6-58
Outside of Vehicle ............................................. 6-59
Special Problems .............................................. 6-57
VinylorLeather .............................................. 6-58
Windshield .................................................. 6-58
AM Radio ................................................... 3-10
AM-FM Stereo Audio Compact Disc (CD) System ................... 3-21
AM-FM Stereo Audio System ................................... 3-12
AM-FM Stereo Audio System with Cassette Deck ................... 3-15
AM-FM Stereo Audio System with Cassette Deck and Equalizer ........ 3-18
Comfort Controls ................................................. 3-2
Cooling System ................................................. 6-69
Crankcase ...................................................... 6-69
CruiseControl .................................................. 2-35
Increasespeed ............................................... 2-38
OnHills ..................................................... 2-39
Passing ..................................................... 2-39
Reducespeed ................................................ 2-39
ResumeaSetSpeed ........................................... 2-37
ToGetOutOf ................................................ 240
ToSet ...................................................... 2-36
Customer Assistance for the Hearing or Speech Impaired ................. 8-3
Customer Satisfaction Procedure ..................................... 8-2
Child Restraints ................................................. 1-37
CHMSL (Centered High Mounted Stop Lamp) ......................... 640
Clock
2