1994 CADILLAC DEVILLE fuel

Downloaded from www.Manualslib.com manuals search engine L
NOTICE:
Don’t let anyone tell you that underinflation or overinflation is
all right. It’s not.
If your tires don’t have enough air
(underinflation) you can get:
Too much flexing
Too much heat
Tire overloading
Bad wear
Bad handling
Bad fuel economy.
If your tires have too much air (overinflation), you can get:
Unusual wear
Bad handling
Rough ride
Needless damage from road hazards.
When to Check Check your tires once a month or more.
The tire pressures are:
Front - 30 psi (207 kPa)
Rear - 30 psi (207 kPa)
Recommended tire size
is:
Michelin XW4 Blackwall (P215/70R15)
T125/70RIS (Compact Spare)
c-
How to Check Use a good quality pocket-type gage to check tire
pressure. Simply looking at
the tires will not tell you the pressure,
especially
if you have radial tires -- which may look properly inflated even
if they’re underinflated.
293

Downloaded from www.Manualslib.com manuals search engine 7 UNDERBODYMNTEN~CE
Chemicals used for ice and snow removal and dust control can collect on
the underbody. If these are not removed, accelerated corrosion (rust) can
occur on the underbody parts such as fuel lines, frame, floor pan, and
exhaust system even though they have corrosion protection.
At least
every spring, flush these materials from the underbody with plain
water. Clean any areas where mud and other debris can collect. Dirt
packed in closed areas of the frame should be loosened before being
flushed. Your dealer or an underbody vehicle washing system can
do this
for you.
I
CHEMICAL PAINT SPOTTING
Some weather and atmospheric conditions can create a chemical fallout.
Airborne pollutants can fall upon and attack painted surfaces on your
vehicle. This damage can take two forms: blotchy, ringlet-shaped
discolorations, and small irregular dark spots etched into the paint
surface.
__.
Although no defect in the paint job causes this, Cadillac will repair, at no
charge to the owner, the surfaces of new vehicles damaged by this fallout
condition within
12 months or 12,000 miles (20 000 km) of purchase,
whichever comes first.
309

Downloaded from www.Manualslib.com manuals search engine r I
r i
r‘ I
!- I
r
? ! i
!- i
I
r‘ L
DlSTR SIR PCM (IGN) INJ INJ IGN 1
]mmmmmmri
~mnmmmml
PCM (BAT) RTD BATT A/C COMP HDLPS STOP LP TURN/HAZ
DRL
L HDLP LO
R HDLP LO L HDLP HI R HDLP HI IGN 3 COOL FAN TRANS
I FUSE CENTER IDENTIFICATION
ENGINE COMPARTMENT FUSE BLOCK
DISTR 20A TURN/HAZ 20A
SIR 20A - IGNITION CONTROL MODULE - HAZARD FLASHER
- DIAGNOSTIC/ENERGY RESERVE
- DUAL POLE ARMING SENSOR - DAYTIME RUNNING LIGHTS (CANADA)
- TURN FLASHER RELAY - TURN FLASHER MODULE
MODULE (DERM) DRL 10A (CANADA)
PCM IGN) 10A DRL 10A (CANADA)
- PASS-Key@ DECODER MODULE HTD W/S 1OA
INJ 1OA - HEATED WINDSHIELD CONTROL MODULE
INJ 1OA - LEFT REAR STRUT
IGN 1 10A
- P6WERTRAIN CONTROL MODULE (PCM) - LEFT AND RIGHT LO BEAM HEADLAMP
- 1,4,6, AND 7 FUEL INJECTORS LR STRUT 1OA
- 2,3,5, AND 8 FUEL INJECTORS RR STRUT 10A
- A/C REFRIGERANT PRESSURE SWITCH - TRANSAXLE RANGE SWITCH - STOP/BTSI/CRUISE BRAKE SWITCH - INSTRUMENT PANEL CLUSTER - KEYLESS ENTRY MODULE - DIAGNOSTIC/ENERGY RESERVE MODULE
- RIGHT REAR STRUT LF STRUT 1OA
RF STRUT 1OA
L HDLP LO 1OA
R HDLP LO 10A
L HDLP HI 1OA
R HDLP HI 1OA
IGN 3 10A
- LEFT FRONT STRUT
- RIGHT FRONT STRUT
- LEFT LO BEAM HEADLAMP
- RIGHT LO BEAM HEADLAMP
- LEFT HI BEAM HEADLAMP
- RIGHT HI BEAM HEADLAMP
- REAR DEFOGGER RELAY - ELECTRONIC LEVEL CONTROL (ELC) - HEATED WINDSHIELD - HEATER AND A/C PROGRAMMER - CRUISE CONTROL
LFR2RING
LIGHTS
-
- TURN/HAZARD SWITCH ASSY - CHIME MODULE - HEADLIGHT SWITCH - TWILIGHT SENTINEUDRL MODULE
- FUELPUMP - OIL PRESSURE SWITCH - POWERTRAIN CONTROL MODULE (PCM)
FUEL PUMP 20A
PCM BAT) 10A
RTD (BAT) 20A
A/C COMP 1OA
- POWERTRAIN CONTROL MODULE (PCM)
HDLPS 30A
- P6WERTRAIN CONTROL MODULE pCM) COOLING FAN 1OA - ROAD SENSING SUSPENSION (RSS) MODULE - EXTENDED TRAVEL BRAKE SWITCH
- A/C COMPRESSOR CLUTCH - COOLING FAN RELAYS 1,2, AND 3.
- HEADLIGHT DIMMER SWITCH - HEADLIGHT RELAY “D” (ENGINE COMP MICRO - OVERSPEED ALERT MODULE (EXPORT)
- DRL HEADLIGHT RELAY “E (WITH DAYTIME - POWER STEERING PRESSURE SWITCH - EXHAUST GAS RECIRCULATION (EGR) VALVE
- POWERS C13 - TRANSAXLE SHIFT SOLENOIDS A & B - EVAPORATIVE EMISSION CONTROL SOLENOID
- STOP/BTSI/CRUISE SWITCH - POWERTRAIN CONTROL MODULE (PCM)
- STOPLIGHT SWITCH CAPACITOR - TORQUE CONVERTER CLUTCH SOLENOID - TCC BRAKE SWITCH
- FRONT AND REAR HEATED OXYGEN SENSOR TRANS/ECS 1 OA
RELAY CENTER)
RUNNING LIGHTS)
STOP LP 20A
315

Downloaded from www.Manualslib.com manuals search engine I 60A I
I I 30A
E "
I 60A I
60A
LH MAXI8 FUSE BLOCK
FUSE 1 (50 AMP) (STRG 1-2)
- RETAINED ACCESSORY POWER (RADIO/WIPERS)
- STARTER
- TRUNK COMF FUSES B11 AND 813
FUSE 2 (60 AMP) (BODY)
- ENGINE COMF! B11
- ROAD SENSING SUSPENSION
- FOG LIGHTS
- TRUNK COMF! FUSE C1, C3, C5, C7, C9, AND
c11
- TRUNK COMI? FUSE C13 (EXPORT)
- REAR FOG LIGHT (EXPORT)
CIRCUIT BREAKER 3 (30 AMP) (SEAT)
- LEFT AND RIGHT POWER SEAT SWITCHES
- LEFT AND RIGHT LUMBAR RELAYS
- POWER DOOR LOCKS
- KEYLESS ENTRY MODULE
- HORNS
- FUEL DOOR RELEASE SWITCH
- TRUNK RELEASE SWITCH
FUSE 4 (30 AMP) (IPC)
- POWERTRAIN CONTROL MODULE (PCM)
- ELECTRONIC CLIMATE CONTROL
'- RAPALLUMINATED ENTRY MODULE
- INSTRUMENT PANEL CLUSTER
- PASS-Key@ DECODER MODULE - THEFT DETERRENT
FUSE 5 (SO AMP) (HVAC) - LEFT AND RIGHT HEATED SEATS
- ELECTRONIC LEVEL CONTROL (ELC)
- TRUNK LID PULL DOWN
- POWER ANTENNA
- REAR DEFOGGER - LEFT AND RIGHT MIRROR DEFOGGERS
FUSE 6 (60 AMP) (STRG 3)
- RETAINED ACCESSORY POWER
(SUNROOF/POWER WINDOWS)
- ENGINE COMF! FUSES Dl, D3, D5
- TRUNK COMI? FUSES A1 , A3, A5, A7, A9
RH MAXI8 FUSE BLOCK
CIRCUIT BREAKER 1 (30 AMP) (DAB)
- RETAINED ACCESSORY POWER (RAP)
(SUNROOF/POWER WINDOWS)
FUSE 2 (30 AMP) (RADIO)
- DELCO-BOSEB SPEAKERS
- RADIO CONTROL HEAD
- REMOTE RADIO RECEIVER
FUSE 3 (50 AMP) (COOL)
FUSE
4 (40 AMP) HVAC BLOWER (BLOWER)
- COOLING FANS
- HVAC POWER MOTOR
- A/C COMPRESSOR
FUSE 5 (50 AMP) ABS (BRAKES)
FUSE
6 (50 AMP) (LAMPS)
- BRAKE PRESSURE MODULATOR VALVE
- TURN FLASHER MODULE
- HAZARD FLASHER
- STOP/BTSI/CRUISE BRAKE SWITCH
- PARKING LIGHTS
- DAY TIME RUNNING LIGHTS (CANADA)
- ENGINE COME FUSES 61, B3 AND B5
- TRUNK COMF! FUSES Dl 1, Dl3
316

Downloaded from www.Manualslib.com manuals search engine IGN 1 HDLP WASH IPC (IGN) RTD
~~l~~~mm
WIPER RAD (IGN) R DEFOG HTD MlRR IPC (BATT) THEFT HVAC/DABIE
CIGAR BODY
2 BODY 1 READ LP
L PRK LP
R PRK LP RAD (BAT) TRUNK PLD R HTD SEAT L HTD SEAT
DEVILLE TRUNK COMPARTMENT FUSE BLOCK
CRANK (10 AMP)
- DlAGNOSTlClENERGY RESERVE
- TRANSAXLE RANGE SWITCH (NSSS)
- RAP/ILLUMINATED ENTRY MODULE
MODULE (DERM)
ION 1 (10 AMP) - TRUNWFUEL DOOR RELEASE INHIBIT RELAY "E" - FUEL LEVER SENSOR - ELECTROCHROMIC MIRROR - RAP/ILLUMINATED ENTRY MODULE - THEFT DETERRENT MODULE - KEYLESS ENTRY MODULE - TURN FLASHER RELAY "F TRUNK COMP.
HDLP WASH (30 AMP) EXPORT ONLY
IPC
(ION) (10 AMP) - INSTRUMENT PANEL CLUSTER RTD SUSP (10 AMP)
- ENGINE COMP MICRO REL4Y CENTER
ABS (IO AMP) - ELECTRONIC BRAKE AND TRACTION CONTROL MODULE
(EBTCM)
WIPER (30 AMP) - WIPERMASHER SWITCH RAD (IGN) (10 AMP)
R DEFOG (30 AMP) - REAR DEFOGGER HTD MlRR (10 AMP) - LTAND RT OUTSIDE MIRROR DEFOGGERS IPC (BATr) (10 AMP)
THEFT
(10 AMP) - PASS-Key@ DECODER MODULE - THEFT DETERRENT RELAY "D" (TRUNK COMP.
- THEFT DETERRENT MODULE HVAC/DABIE (10 AMP) - HEATER AND A/C PROGRAMMER
RADIO (30 AMP) - ACTIVE AUDIO AMPLIFIER TRAILER (20 AMP)
ANT
I10 AMP)
MICRO RELAY CENTER
- NOT EQUIPPED
- SPEED SENSITIVE SUSPENSION
RSS DAMPER RELAY "F"
- REMOTE RADIO RECEIVER
- INSTRUMENT PANEL CLUSTER
RELAY CENTER)
- RAP/ILLUMINATED ENTRY MODULE
- NOT EQUIPPED
CIGAR (20 AMP) - LT AND RT REAR CIGARETTE LIGHTERS - FRONT CIGARETTE LIGHTER - CHIME MODULE BODY 2 (10 AMP) - POWER MIRROR SWITCH - RAPRELAY - LOCK-OUT INHIBIT RELAY "A" (TRUNK COMP 1 MICRO
- COURTESY LIGHTS RELAY "C" (TRUNK COME 2 MICRO
RELAY CENTER)
RELAY CENTER)
- RAP RELAY "E (TRUNK COMP. 2 MICRO
RELAY CENTER) - KEYLESS ENTRY MODULE - TRUNKLAMP
- FRONT DOOR LOCK SWITCHES BODY 1 (10 AMP)
- FRONT DOOR COURTESY LAMP - GLOVE BOX LAMP - HEADLIGHT SWITCH READ LP (10 AMP) - LTAND AT FRONT HEADER LAMP - GARAGE DOOR OPENER - LT AND RT REAR HEADER LAMPS L PRK LP (10 AMP) - LT REAR TAlUSTOPrURN LAMPS
- FRONT AND REAR LEFT SIDE MARKER LAMPS - RT REAR MARKER LAMP - HEADLIGHT SWITCH - INSTRUMENT PANEL CLUSTER R PRK LP (10 AMP) - RADIO CONTROL HEAD - RT TAIUSTOP TURN LAMPS - RT FRONT AND REAR SIDE MARKER LAMPS - RT FRONT PARK AND TURN LAMPS - ENGINE COME LAMP - LICENSE PLATE LAMPS RAD (BAT) (10 AMP) - RADIO TRUNK PLD (20 AMP) - TRUNK LID PULL DOWN MOTOR ELC (30 AMP) - ELECTRONIC LEVEL CONTROL (ELC) R HTD SEAT (10 AMP) - PASSENGERS HEATED SEAT
- LT FRONT PARWURN LAMPS
L HTD SEAT (10 AMP) - ANTENNA MOTOR - DRIVER'S HEATED SEAT
318
,

Downloaded from www.Manualslib.com manuals search engine Ly ENGINE COOLING SYSTEM
Radiator Cap Relief Pressure ................. 15.0 psi (103 kPa)
Thermostat Starts To Open
................ 192-199'F (89-93OC)
Water Pump Type
................................. Centrifugal
Drive Belt
....................................... Serpentine
Radiator Core
................................... Aluminum
Radiator Cooling Fans (2)
............................ Electric
FUEL SYSTEM
Induction Type ............ Sequential Port Fuel Injection (SPFI)
System Pressure
.................... .33.4-43.5 psi (230-300 kPa)
Idle Speed
.................................. ECM Controlled
Filter Type
............................... Paper Type Element
Fuel Pump
................................ Electric (In Tank)
Fuel Required ................. Premium Unleaded (91 Octane)
AUTOMATIC TRANSAXLE
Trade Name ............................. Hydra- Matic 4T60E
Type ..................................... 4-Speed Automatic
.................................... Viscous Converter Clutch
Fluid Required
............... DEXRON IIE@or DEXRON HI@
Axle Ratio
........................................... 2.73:l
EMISSION CONTROL SYSTEMS
Exhaust Gas Recirculation .................... Controlled Flow
Catalytic Converter
......................... Ceramic Monolith
Evaporative Emission Control
................ Charcoal Canister
Crankcase Emission Control
....................... PCV Valve
Electronic System
..................... Open and Closed Loop
327
-

Downloaded from www.Manualslib.com manuals search engine EXhlAUST SYSTEM
Type ............................... Single with Crossover Pipe
Muffler
.................................. One-Reverse Flow
Resonator
............................................ None
Exhaust Pipe
.................................. .Stainless Steel
Intermediate Pipe
............................. ,- Stainless Steel
Tail Pipe
..................................... Stainless Steel
ELECTHCA SYSTEM
Voltage ................................................ 12
Generator ......................................... 140Amp
Ground
........................................... Negative
AIR CONRITIONING SYSTEM
Refrigerant-R134a ............................ .2.0 lbs. (.91 kg)
Not all air conditioning refrigerants are the same.
If the air conditioning
system in your vehicle needs refrigerant, be sure the proper refrigerant is
used. If you’re not sure, ask your Cadillac dealership.
FLUID CAPACITIES
Transaxle (4T60E) .............................. 20 pts. (9.5 L)
Engine Oil ................................... 5.0 qts. (4.7 L)
With Filter Change ............................ 5.5 qts. (5.2 L)
Engine Cooling System ......................... 11 qts. (10.5 L)
Fuel Tank .................................. 20 gallons (76 L)
Power Steering .............................. 1.3 quarts (1.2 L)
Windshield Washer Reservoir .................. 4.2 quarts (4.1 L)
TIGHTEN TORQUE
Spark Plugs ............................... .20 Nm (15 lbs. ft.)
Oil Pan Drain Plug. ......................... 30N.m (22 lbs. ft.)
328
tl
r_
.c-
FC

Downloaded from www.Manualslib.com manuals search engine NOW MNTENNCE REPLACEMENT PARTS
cc
c-
Air Cleaner Element ......................... AC Type A1096C
................................................. 25096932
Batte
............................................... 78A-72
................................................. 25121801
Engine Oil Filter
............................. AC Type PF-58
................................................. 25014377
PCV Valve
................................ AC Type CV-774C
................................................. 06487779
Spark Plugs
.................................. AC Type 41-902
.................................................. 5614235
Serpentine Drive Belt
............................... 3538853
Surge Tank Cap
.............................. AC Type RC 33
.................................................. 6410665
Thermostat
........................................ 3528974
Lower Radiator Hose
............................... 3521237
TransFilter
........................................ 8651909
TransPanGasket
................................... 8676250
Fuel Filter Element .......................... AC Type GF-624
Upper Radiator Hose
............................... 3521235
VEHICLE DIMENSIONS
Shipping Weight .......................... 3687 lbs. (1672.2 kg)
Wheel Base
................................ 111 in. (2819 mm)
Length .................................. .204.1 in. (5183 mm)
Height
................................... .54.5 in. (1384 mm)
Width .................................... -74.2 in. (1884 mm)
Front Track
............................... .60.9 in. (1546 mm)
Rear Track
............................... .60.9 in. (1546 mm)