1993 VOLKSWAGEN GOLF warning

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

Warning lamps
Attention • Be careful when opening the coolant expansion tank! When the engine is hot the cooling sys­tem is under pressure -Danger of scalding! Let engine cool down therefore before unscrewing the cap_
• Do not touch the fan. The fan can switch on suddenly -even when ignition is switched off.
For furthe r details see pages 98 and 98.
1 -Coolant temperaturel _~_ If the coolant le vel is in orde r the trouble Coolant level') may be due to failure of the radiato r fan.
Check radiator fan fuse and renew is
T he wa rni ng lamp lights up for a few sec­
necessary -see page 119.onds as a functional check when ign ition IS coo lant level .
. 46 switched on.
2 - Engine oil pressure ... .. 47 If the warning lamp does not go out al­
If the lamp does not go out afterwards or 3 -Alternator . 47 though coolant level and fan fuse are inflashes when driving, either the coolant 4 -Glow plugs ... 47 orde r, do not drive on -call in expe rt as­tempe ratur e is too high or the coolant 5 -Brake system .. 48 sistance
.
level1 l too low: 6 -Brake pad wear indicator .48 If the trouble is only caused by the fan andStop, switch engine off and check7 -Turn signals 48
assuming coolant level is in order and tem­level . Add coolant if necessary . 8 -Main beam .
48
perature warning lamp is out -one can drive on to the nearest Volkswagen dealer. In 11 Only 011 vehicl es wi h a t omatic coolant order to make good use of the air stream for level lllonit or (see page 97 l. cooling , do not let engine idle or drive very
slowly .
he
layout
of the warning lamps depends on the model and the engine fitted. The sym­
bols shown here are also on the actual
warn ing lamps.
1 -Coolant temperature /

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

2 -Engine oil pressure ~
e wa rning lamp flashes when ignition is :ched on. the lamp must go out when ,=~g ne has started.
, 'Il e warning lamp does not go out or
ash es when driving -a buzzer also sounds
-' e!,gine spe,eds above 2000 rpm -stop, switch engine off, check oil level and if ecessary, add oil -see page 94.
- - he lamp comes
on although the oil level 5 n order, do not drive on. Do not even "'., t he engine at idling speed -call in expert ~slstance.
-du ring the Journe y the engine is operated
a : a speed less than idling speed, it ca n ~ appen that the oil warning lamp lights up. "crease engine speed by accelerating or :'langing down .
Note Th e oil pressure warning lamp is not an oil level indicator. The oil level shou.'d therefore be checked at reg, ular Intervals, preferably every time the fuel tank is filled.J
3 -Alternator
The warning lamp comes on w hen the igni­

tion IS sWitched on and must go out when

the engine is started .

The alternator
is driven by a long-life ribbed

belt.

If the warning lamp lights during the

Journey ,
stop, switch off engine and
check ribbed belt.

If
t~e ribbed belt is loose or broken, do not
drive on -the coolant pump is no longer

being driven. The ribbed belt must be
checked/renewed by the next Volkswagen

dealer.

If the ribbed belt
is not loose or broken, one
can normally drive on to the next Vo lks­

wag en dea ler. However as the battery is
then discharging co ntinuously , all electrical

consumers which are not absolutely essen­

tial should be switched off.

4 -Glow plugs
(Diesel engines only)

When the engine
is cold the w arning lamp

come s on when key IS turned to Drive posi­

tion (ignition on)

If the warning lamp does not come on, there IS a defectln the glow plug system -call in expert assistance.
When the lamp goes out, start the engine
Immediately -see page 37.
As the 55 kWDiesel engine glow period be­
gins automatically after closing the drivers'
door,
It can happen that after switching to
the driving position (Ignition on) with a cold
engine, that the glow plug warning lamp
does not light up . The engine
can be started
straight away
When the engine
is warm the glow plug
lamp does not come on -the engine ca n be started straight away
Note
If while driving a fault occurs in the engine
management system of the 66 kW Diesel
engine, this
is indicated by a flashing warn­Ing lamp The engine must be checked by a
Volkswagen dealer as soon as possible.
47

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

5 -Brake system
(CD)
The warning lamp* co mes on when
• the handb rake is
on • the brake fluid level is too low The ignition must be switched on.
Attention
If the lamp does not go out when handbrake is released or comes on when driving, the fluid level in the reservoir is too low. Immedi­
ately contact a Volkswagen dealer and have the brake system
examined.
You can drive on carefully to the
nearest Volkswagen dealer but allow for higher pedal pressures and longer braking distances on
the way.
I6 -Brake pad wear I,'0',
indicator*
The wa rning lamp lights up for one second when the ignition is switched on as a func­
tiona l check.
If the lamp then does not go out or it lights
up dur ing the Journey , the front brake pads
are worn. You should visit a Volkswagen
dealer to have the brake pads checked.
As the brake pad wea r indicator only moni­
t ors the front brake pads, we recommend
that you have the rear brake linings checked as well.
7 -Turn signals
The warn ing lamp flashe s when turn signals are sWitched on. If a turn signal fails, the
warning lamp flashes tw ice as fast. (Not
w hen towing a trailer )
Fur ther details are given
on pages 49 and 53.
8 -Main beam
The warning lamp come s on when th e main
beam is on or when the headligh t flas her is used.
48

Downloaded from www.Manualslib.com manuals search engine ----CONTROLS AND EQUIPMENT
Q1~ Trailer turn signals(8 ) Anti-locking Brake System
(ABS)* The warning lamp" flashes when turn sig­
nals are switched on when towing a trailer. The warning lamp comes on for a few sec­
onds when the ignition is switched on. The If a turn signal fai ls on the trailer or vehicle,
lamp goes out after
an automatic test se­ the
warning lamp does not flash.
quence has taken place,
If the ASS warning lamp does not go out. or if the ASS warning lamp comes on when
driving, the system is fau lty The vehicle can then only be braked with the normal system
- that is w ith out ASS. The vehicle must be taken to a Vol kswagen dealer as soon as possible .
- ne
warning lamp cluster can contain Further details on ASS is given on page 76 . •anous warning lamps. The warning lamps actually fitted can be recognized by the 5 mbols
to ~Airbag system
n e warning lamp lights for about 3 seconds Nhen the ignition is switched on. If the
N arning lamp does not go out or lights/
;Iickers during the Journey, there is a fault in :he Airbag system , The system should be ct16cked immediately by a Volkswagen
:lealer For further details see page 18.
49

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

Switches
Note
• On vehicles with right-hand drive the ar­rangement of the switches differs. The
symbols on the switches are however the
same as on vehicles wit h left-hand drive.
• The use of the lighting described here is subject to local regulations.
1 -Lighting swit ch -'0­, , '
El ­Switched off
:oo~ -Side lights 1)
Awarning lamp next to the side light symbol
lights up.
§D -Dipped or main beam
The headlights only w ork when the ignition
is on . When the engine is being started and after ignition has been switched off, the
headlights are switc hed off automatically.
Dipping
and flashing the headlights -see
page 53.
~D -Front fog lights*
With li ghting switch in side light or dippe d/
main beam position pull sw itch out to first
d etente .
A w arning lamp next to the front foglight
symbol lights up.
'I) On vehic le s fo r so me expo rt co untri es when
the side li ght s are switchea on with the igni­
tio n sWit ched on, the dip p ed headlig hts als o
c o me on with reduc ed inte slty.
0$ -Rear fog light-
Vehicles without fog lights
Turn lighting switch to dipped/ main beam
positi on and pull switc h out to 1st detente.
Vehicles with fog lights
With lighting sw itc h in d ipped/ main beam
position, pull svvitch out to 2nd detente.
A warning lamp next to the rear fog light
symbol lights up.
Due to the amount of dazzle it causes the
rear fog light should only be sWitc hed on when the visib ility is ve ry poor (in Germany
for example, below 50 m etres)
2 -Instrument ()~;"
lighting
When the lights are on, th e level of the in­
st rument lighting can be re gul ated by turn­
ing the knurled wheel.
50

Downloaded from www.Manualslib.com manuals search engine ____CONTROLS AND EQUIPMENT

3 -Headlight range
control *
lIJith the electrical range control the head ­ght settings can be matched exactly to the
o ad condition of vehicle. This prevents on­
:::oming traffic from being unnecessaril y
d a zzled . At the same time the correct head­
gh t beam setting provides the best poss­
ble v is ibilit y for the driver.
-he hea dlight s can only be regulated with
: h e dipped headlights switched on .
To lower the beams, turn knurled disc from :he basic position H downwards .
Hazard warning lights
~
When the hazard lights are on, a warn ing lamp in the switch flash es as well.
The system
also works when th e ignitio n is switched off.
Knurled wheel for
seat heating*
The cushion and backrest of the front seats

can be heated electrically w hen the ignition
is on.

The heating is switched
on and regu lated

w ith the knurled w heel.

T o
sWitch heating off, turn knurled whee l

down to the detent e posit ion .

51

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT
Tu rn signal and dip lever
~eturn sign als only w ork when the ignition -wit ched on.
~ gh t turn signa ls -lever up
_z turn signa ls -lever down
"en turn signa ls are working, the warning
p flashes as well - see page 48 also.
-'? tur n signa ls cance l automatica lly after rnplet ing a turn
To signal a lane change Note
Move le ve r up or do w n to pres sure point The use of the signals and lighting de­and hold in th is position ­the w arning lamp
scribed he re is subje ct to local regu lations
must also be f lash ing
To dip headlights
Pull le ve r past pressure point towards steer­ing w heel. When high beams are on, the
high beam warning lig ht w ill light up
Headlight flasher
Pull lever towards steeri ng wh eel to pres­
sure poin t - the main beam wa rning lamp
light s up .
Parking lights
The park ing lights on ly work when ignition is s w itched off.
Right park
ing lights -lever up
L
eft park ing li ghts -lever dow n.
53

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

Shelves and boxes
Glove box
-0 open lockable glove box* lift handle .
Attention For safety reasons all stowage box lids should always be closed w hen vehicle is moving.
On the estate there is further stowage
space behind flaps on the left and right-hand
sides of the luggage compartment. Pull handle in the direction shown to open these
boxes -see right-hand illustration .
Note
The stowage locations of the first aid kit and the warning triangle in both the saloon and
the estate are described on page 112.
69