Page 31 of 738
Downloaded from www.Manualslib.com manuals search engine GENERAL - How to Diagnose293. Jumper wire
A jumper wire is used to close an open circuit. Never
use one to connect a power supply directly to a load.
Z16602274. Voltmeter
A voltmeter is used to measure the circuit voltage. Normally,the positive (red lead) probe is applied to the point of
voltage measurement and the negative (black lead) probeto the body ground.
5. Ohmmeter
An ohmmeter is used to check continuity or measure resis-
tance of a switch or coil. If the measuring range has been
changed, the zero point must be adjusted before measure-
ment.
CHECKING SWITCHES
In a circuit diagram, a switch is represented by a symbol andin the idle state.
1. Normal open or normal close switch
Switches are classified into those which make the circuit
open and those which make the circuit closed when off.
INormal open (NO) typeIOFF
/4-
1X
t
Current does not flow
16X0690
ON
1
a
ia
Current flows
16X0691
00000401
Normal close (NC) type
i===ONOFF
1
/4-
1X
Current does not flow16X0690
00000402
a
III
Current flows
16X0691
TSB Revision
Page 32 of 738
Downloaded from www.Manualslib.com manuals search engine 30GENERAL - How to Diagnose
5432
1
18AO253
10W80800000403
Coil
Iron
Cover
Spring
Iron
core
- ContZt
21680231
(NO) type
Energized state1Normal op6
Deenergized state
--
nKilX
Current does not flow
lSXO804
!
Current flows10x0095000004042. SWITCH CONNECTION
This figure illustrates a complex switch. The continuity
between terminals at each position is as indicated in the
table below.4th stage
CHECKING RELAYS1. When current flows through the coil of a relay, its core
is magnetized to attract the iron piece, closing (ON) the
contact at the tip of the iron piece. When the coil current
is turned off, the iron piece is made to return to its original
position by a spring, opening the contact (OFF).
2.By using a relay, a heavy current can be turned on and
off by a switch of small capacity. For example, in the circuit
shown here, when the switch is turned on (closed), current
flows to the coil of the relay. Then, its contact is turned
on (closed) and the light comes on. The current flowingat this time to the switch is the relay coil current only
and is very small.3. The relays may be classified into the normal open type
and the normal close type by their contact construction.
NOTE
The deenergized state means that no current is flowing
through the coil and the energized state means that current
is flowing through the coil.
JI
TSB Revision
Page 48 of 738
Downloaded from www.Manualslib.com manuals search engine 46CONFIGURATION DIAGRAMS - Engine and Transaxle
ENGINE AND TRANSAXLE :
Connector
symbol
B
Front View
B-0: B;lO 53-11B-12R-i?
IB-06 B-07 B-08B-40*’
B-02
------+
B-01B-30
\ 7
I
B-29
- \B-:4B-23
B-25
A36F0176
B-01
B-02
B-03
B-04
B-05
B-06
B-07
B-08
B-09
i*B-25
NOTE
[:I*‘A992 models*2: From 1993 models*s:1994, 1995 models for California and from 1996 models*4: From 1996 models
Engine coolant temperature gauge unit
Engine coolant temperature sensor
Engine coolant temperature switch(for air conditioning circuit)
Crankshaft position sensor and camshaftposition
sensor*’Throttle position sensor
Control wiring harness and oil pressure wiring
harness combination
Control wiring harness and injector wiring
harness combination
Knock sensor
Variable induction servo motor
(with intake control valve position sensor)
B-10
B-11
B-12
B-13
B-14
B-15
B-16
B-17
B-18
B-19
B-20
B-21
B-22
Variable induction servo motor(with intake control valve position sensor)
Injector No. 5
Injector No. 3
Injector No. 1
Ignition coil
Capacitor
Left bank heated oxygen sensor (front)
- 1994, 1995 models for
California and 1996 models>
Generator
GeneratorRight bank heated oxygen sensor (front)
Magnetic clutch
Power Transistor
Power TransistorL)
TSB Revision
Page 50 of 738
Page 73 of 738
Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit71
I
/
2B-Y>:5IOD OR
%iMOR
1
B-W
I2B-W
.ENGINECONTROL MODULE.IGNITION COIL.IGNITION POWERTRANSISTOR,MFI RELAY
'REMOTECONTROLLED
MIRROR
.&~[E"~ORY
.ETACS UNITL
TRANSAXLE
f%m"
I
*tf@'$ESS CONTROL
.REAR
INTERMITTENT
WIPER RELAY.AUTO-CRUISECONTROL UNIT.WASHER MOTOR.ETACS UNIT.WIPER MOTOR.MOTOR ANTENNA.WIPER RELAYCONTROL UNIT$~~CJ&~AND TAPE:ABS
POWER RELAY.CONDENSOR 7
(UP TO 1993 October)AiFAyOTOR
.BACK UP LIGHT.LIGHT AUTOMATICSHUT-OFF UNIT
G~GAERoCONTROL UNIT.SPARECONNECTOR+J;&~L"U'SE
MAIN SWITCH(#&i;iE).AIR CONDITIONINGCOMPRESSOR LOCK
CONTROLLER$&JTR.INIC
SUSPENSION.AIR CONDITIONINGCONTROL UNITCONTROL UNIT*RADIATOR*&L"$R MOTORFAN MOTOR
RELAY
.#&lyCRUISE
$i$&NATION$$;NATION
.ETACS UNIT.MOTOR ANTENNACONTROL UNIT
.SPEED SENSbR.ggTDIAGNOSI~
.TURN SIGNALAND HAZARD
FLASHER UNIT.BLOWER MOTORRELAYCHI)
REMARKTHE ABOVE CIRCUIT DIAGRAM SHOWS THE CURRENT FLOW AT THEIGNITION KEY POSITION "ACC", "ON" AND "ST" COMBINED.BE SURE TRACE THE APPROPRIATE CIRCUIT DEPENDING ON THEIGNITION KEY POSITION.
0 (c-59) (c-70) (c-82)
~giJJ~jq$q
LHROlMOOBB
TSB Revision
Page 77 of 738
Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit75
IGNITION3y; 6
SWITCH
(c-59)
I
IGlVI
2B-YpL52B-W *2L-BIOD OR%ii&!OR
II
B-W
JGENERATOR7RELAY__-_--_-_____-___-_____________
2B-W
.ENGINECONTROL MODULE.IGNITION COIL.IGNITION POWERTRANSISTOR.MFI RELAYTRANSAXLE
ki8%EL
f
,BACK UP LIGHT.LIGHT AUTOMATICSHUT-OFF UNIT$$~TDIAGNOSIS
I$
'ABSPOWER RELAY(UP TO 1993 October).AIR CONDITIONINGCOMPRESSOR LOCK
CONTROLLER
.AIR CONDITIONINGCONTROL UNIT'&#R MOTOR
.BLOWER MOTORRELAYCHI)
.--_--
.&EE;qORY
.ETACS UNIT
+ L-l'#fiBi;'"
.REMOTECONTROLLED
MIRROR
+jjf$ESS CONTROLic
.REARINTERMITTENT
WIPER RELAY
.WASHER MOTOR.WIPER MOTOR.WIPER RELAY
.AUTO-CRUISECONTROL UNIT.ETACS UNIT.MOTOR ANTENNACONTROL UNIT.RADIO ANDTAPE PLAYER.ACTIVE AERO\
CONTROL UNIT.SPARECONNECTOR$@RC~UISE
MAIN SWITCH(jiifb%E)
~f$J&CRUISE.SPEED SENSOR
~'$@~NATION$/$TDIAGNOSIS
.&y&NATION.TURN SIGNALAND HAZARD
FLASHER UNIT
.ETACS UNIT.MOTOR ANTENNACONTROL UNIT
T
REMARKTHE ABOVE CIRCUIT DIAGRAM SHOWS THE CURRENT FLOW AT THE
IGNITION KEY POSITION "ACC","ON" AND "ST" COMBINED.
BE SURE TRACE THE APPROPRIATE CIRCUIT DEPENDING ON THE
IGNITION KEY POSITION.
HROlMOlBB
TSB Revision
Page 81 of 738
Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit79
FUSIB ELINK 4bB
Y3w c
'&# CONTROL
.;gTDIAGNO~~~
,STARTER MOTOR$$$;ER
IOD ORSTORAGECONNECTOR
4’
I
-J4a
*(c-70)
2L-w
2B-W
.ETACS UNIT
;I$@fLE
l-----l
IMODULE$i$ESS CONTROL
f$#;&TE
.REMOTECONTROLLED
MIRROR
.ENGINECONTROL MODULE,IGNITION COIL,IGNITION POWERTRANSISTOR,MFI RELAY
!
.REARINTERMITTENT
WIPER RELAY
.WASHER MOTOR.WIPER MOTOR.WIPER RELAY;gL"itGER
.AUTO-CRUISECONTROL UNIT.ETACS UNIT.MOTOR ANTENNACONTROL UNIT.RADIO ANDTAPE PLAYER
A.ACTIVE AERO
CONTROL UNIT:.#J$$;U'SE
MAIN SWITCHj&CRUISE
.ETACS UNIT.MOTOR ANTENNACONTROL UNIT.SPEED SENSOR.$WSTDIAGNOSI~
.TURN SIGNALAND HAZARD
FLASHER UNIT
TI
2.A1CC
R CONDITIONINGIMPRESSOR LOCK.CONDENSOR
INTROLLERFAN MOTOR
RELAY
R CONDITIONING
lNTROL UNITf~~~;~L"NIC
$kL"A"&R MOTORSUSPENSION
CONTROL UNIT
.BLOWER MOTOR.RADIATORRELAYCHI)[;FAyOTOR$&&NATION.~~~~RNATION
NOTETHE ABOVE CIRCUIT DIAGRAM SHOWS THE CURRENT FLOW AT THEIGNITION KEY POSITION "ACC", "ON" AND "ST" COMBINED.BE SURE TRACE THE APPROPRIATE CIRCUIT DEPENDING ON THEIGNITION KEY POSITION.
::HATCHBACK
HROlM02BB
1 TSB Revision
Page 85 of 738
Downloaded from www.Manualslib.com manuals search engine CIRCUIT DIAGRAMS - Power Distribution Circuit
L,
FUSIB ELINK 4bB
P3w P
$$d! CONTROL
jj!JyTDIAGNOSIS
.STARTER MOTOR$$eEl?ER
2L-w
:
J
I
2B-b
7@#"TO"
2__-__--__-__-_--_--_--~~-~~-~-- -_-----__-_--_C\
1I/4,/---t-_
/
i/.ENGINECONTROL MODULE.IGNITION COIL.IGNITION POWERTRANSISTOR.MFI RELAY
.REMOTECONTROLLED
MIRROR
.AUTO-CRUISECONTROL UNIT.ETACS UNIT.MOTOR ANTENNACONTROL UNIT.RADIO ANDTAPE PLAYER
.BACK UP LIGHT.LIGHT AUTOMATICSHUT-OFF UNIT.;;~TDIAGNOSIS
i
.REARINTERMITTENT
WIPER RELAY
.WASHER MOTOR.WIPER MOTOR.WIPER RELAY@L"'$jGER
:ACTIVE AEROCONTROL UNIT~~~&~~U'SE
MAIN SWITCH$&CRUISE
.@j&NATION
$'~$!$NATION
:.ETACS UNIT '.MOTOR ANTENNACONTROL UNIT.SPEED SENSORjiyTDIAGNOSIS
*TURN SIGNALAND HAZARD
FLASHER UNITr
*
.AIR CONDITIONING\
COMPRESSOR LOCK.CONDENSOR
CONTROLLER;@AiOTOR
.AIR CONDITIONINGCONTROL UNIT.~@;~~NIC
.&A";R MOTORSUSPENSIONCONTROL UNIT
.BLOWER MOTOR.RADIATORRELAY(HI)&JAFOTOR
THE ABOVE CIRCUIT DIAGRAM SHOWS THE CURRENT FLOW AT THE
IGNITION KEY POSITION "ACC", "ON" AND "ST" COMBINED
BE SURE TRACE THE APPROPRIATE CIRCUIT DEPENDING ON THEIGNITION KEY POSITION.
X:HATCHBACK
HROlM03BB
TSB Revision
