1993 GMC SIERRA fuel pressure

How To Use This Manual
These symbols are used on warning lights in your vehicle:
1-
Engine Coolant Temperature
BRAKE
Brake Battery
Charging
System
I RELEASE
Parking Brake Release
s Fuel
SHIFT
Shift Light
Engine Oil
Pressure
Low
Coolant
Here are some other symbols you may see:
Fuse
I II
Hood Release Lighter Horn
PO594
0-6
ProCarManuals.com

may not realize the surface is slippery until your vehicle is skidding. Learn to
recognize warning clues-such as enough water, ice
or packed snow on the
road to make a “mirrored surface’’-and slow down when you have \
any
doubt.
Remember: the rear wheel anti-lock braking system (RWAL) helps\
avoid only
a rear braking skid. In a braking skid (where the front wheels are no longer
rolling), release enough pressure on the brakes to get the front wheels rolling
again. This restores steering control. Push the brake pedal dow\
n steadily
when you have to stop suddenly.
As long as the front wheels are rolling, you
will have steering control. Steer the way you want to go.
Off-Road Driving with Your FourcWheel
Drive Vehicle
This off-road guide is for vehicles that have four-wheel drive. Also, see
“Anti-lock Brakes” in the Index.
If your vehicle doesn’t have four-wheel drive,
you shouldn’t drive off-road unless you’re on a level, so\
lid surface.
Off-road driving can be great fun. But it does have some defi\
nite hazards.
The greatest
of these is the terrain itself.
“Off-roading” means you’ve left the great North American\
road system behind.
Traffic lanes aren’t marked. Curves aren’t banked. There a\
re no road signs.
Surfaces can be slippery, rough, uphill
or downhill. In short, you’ve gone right
back
to nature.
Off-road driving involves some new skills. And that’s why it’s very important
that you read this guide. You’ll find many driving tips and suggestions. These
will help make your off-road driving safer and more enjoyable. \
Before You Go Off-Roading
There are some things to do before you go out. For example, be sure to
have all necessary maintenance and service work done. Be sure \
you read all
the information about your four-wheel drive vehicle in this manual.
Is there
enough fuel?
Is the spare tire fully inflated? Are the fluid levels up where
they should be? What are the local laws that apply to off-roa\
ding where you’ll be driving?
If you don’t know, you should check with law enforcement people\

in the area. Will you be on someone’s private land?
If so, be sure to get the
necessary permission.
4-25
ProCarManuals.com

close behind you, you can allow a little extra time and flash\
your brake lights (in addition to your turn signal) as extra warning that you are about to slow
down and exit.
The exit ramp can be curvea, somerlmes quite sharply. The exit\
speed is
usually posted. Reduce your speed according to your speedometer,\
not to
your sense of motion. After driving for any distance at higher\
speeds, you
may tend to think you are going slower than you actually are.\
For example,
40 rnph (65 km/h) might seem like only 20 mph (30 km/h). Obviously, this
could lead to serious trouble
on a ramp designed for 20 mph (30 kmlh)!
Driving a Long Distance
Although most long trips today are made on freeways, there are\
still many
made on regular highways.
Long-distance driving on freeways and regular highways is the s\
ame in some
ways. The trip has to be planned and the vehicle prepared, you drive at\

higher-than-city speeds, and there are longer turns behind the \
wheel. You’ll
enjoy your trip more
if you and your vehicle are in good shape. Here are
some tips for a successful long trip.
Before Leaving on a Long Trip
Make sure you’re ready. Try to be well rested. If you must start when you’re
not fresh-such as after a day’s work-don’t plan to make too many miles
that first part of the journey. Wear comfortable clothing and \
shoes you can easily drive in.
Is your vehicle ready for a long trip? If you keep it serviced and maintained,
it’s ready to go.
If it needs service, have it done before starting out. Of
course, you’ll find experienced and able service experts in \
your vehicle’s
dealerships all across North America. They’ll be ready and willing to help \
if
you need it.
Here are some things you can check before a trip:
Windshield Washer Fluid: Is the reservoir full? Are all windows clean
Wiper Blades: Are they in good shape?
Fuel, Engine Oil, Other Fluids: Have you checked all levels?
Lights: Are they all working? Are the lenses clean?
Tires: They are vitally important to a safe, trouble-free trip. Is the tread
good enough for long distance driving? Are the tires all inflated to the
recommended pressure? inside and outside?
445
ProCarManuals.com

Service & Appearance Care
This light also should come on when you start your engine, as\
a check. If it
doesn’t, have it fixed
so it will be there to let you know if you ever do get
water in your fuel.
If the light comes on at any other time, use this chart.
“WATER IN FUE
PROBLEM
Light comes on intermittently.
1) Temperatures above freezing.
Light stays on
2) Temperatures below freezing.
3) Immediately after refueling -
Large amounts of water
probably pumped into the
tank.
.” LIGHT CHART
RECOMMENDED ACTION
Drain water from fuel filter.
Drain fuel filter immediately.
If nc
water is drained and light stays on
-
replace fuel filter.
Drain fuel filter immediately.
If no
water can be drained
- water may be
frozen. Open air bleed
to check for
fuel pressure.
If no fuel pressure
replace filter.
Fuel tank purging required. See your
dealer for assistance.
1
iesitation or “flat” performance at high speed or hard acceleration may be an
ndication of premature fuel filter plugging due to dirty
or contaminated fuel.
The filter element may need
to be changed if this happens. See your dealer
or assistance.
f you drive when this warning light is on, you can damage your fuel I
njection system and your engine. If the light comes on right after you
efuel,
it means water was pumped into your fuel tank. Turn off your
mgine immediately. Then, have the water drained at once.
I
To drain water:
1. Remove the fuel tank cap.
2. Connect a hose going from the water drain valve to a fuel-resistant
container.
6-8
ProCarManuals.com

2. Unplug the Shut-Off solenoid wire from the fuel pump to prevent the
engine from starting.
3. With the air bleed valve open, turn your ignition key to Start for 10 to
15 seconds to crank (but not start) your engine. Keep doing this until
you can just see some clear fuel at the air bleed valve.
I A Diesel fuel is flammable. It could start a fire if it gets on hot engine
b parts. You could be burned. Don’t let too much fuel flow from the air
bleed valve or screw, and wipe up any spilled fuel with a cloth.
4. Close the air bleed valve, or replace the screw and reconnect \
the
Shut-Off solenoid wire.
5. Turn the ignition key to Start for 10 to 15 seconds at a time until your
engine starts.
Fuel Filter Replacement (6.5L Diesel Engines)
If you want to change the fuel filter yourself, here’s how \
to do it:
1 CAUTION
A Diesel fuel is flammable. It could start a fire if something ignites it,
-L and you could be burned. Don’t let it get on hot .engine parts, and
I keep matches or other ignition sources away.
1. Turn off your engine and set your parking brake.
2. Take off the fuel tank cap. This releases pressure in the tank.
6-1 1
ProCarManuals.com

Service & Appearance Care
To remove the filter:
1. Turn off your engine and set your parking brake.
2. Take off the fuel tank cap. This releases pressure in the tank.
1.. ,
K2669
3. The filter is behind the air cleaner on the intake manifold. Using a
4. If there is any dirt on the fuel port seal of the filter adapter, clean \
it off.
5. Snap the new filter into position with the bail wires.
screwdriver, separate both bail wires. Take out the filter.
K2671
6-1 4
ProCarManuals.com

Loading Your Vehicle
The CertificationKire label is found on the rear edge of the driver’s door or in
the incomplete vehicle document in the cab. The label shows th\
e size of your
original tires and the inflation pressures needed
to obtain the gross weight
capacity of your vehicle. This is called the GVWR (Gross Vehicle Weight
Rating). The
GWVR includes the weight of the vehicle, all occupants, fuel and
cargo.
The CertificationKire label also tells you the maximum weights for the front
and rear axles, called Gross Axle Weight Rating (GAWR). To find out the
actual loads on .your front and rear axles, you need to go to a weigh station
and weigh your vehicle. Your dealer can help you with this. .Be sure to
spread out your load equally on both sides of the centerline+
.. , - :I. -I lrT1 I I -
Never exceed the GVWR for your vehicle, or the Gross, Axle Weight Rating-
(GAWR) for either the front or rear axle.
And,
if you do have a heavy load, you should spread it out.
. -1 r,
In the case of a sudden stop or collision, things carried in the bed of 7
injuring you and others. If you put things in the bed of your truck,
you should make sure they are properly secured.
r! your truck could shift forward and come into the passenger are\
a,
-
6-67
ProCarManuals.com

On manual transmission vehicles, put the shift lever in N (Neutral), push the
clutch down halfway, and try to start the engine. The starter should work only
when the clutch is pushed down all the way to the floor.
Steering column lock operation -While parked, try to turn the key to Lock
in each gear shift position.
With an automatic transmission, the key should turn to
Lock only when the
gear shift is in
P (Park).
On vehicles with a key release lever, try to turn the key to
Lock without
pressing the lever. The key should turn to
Lock only with the key lever
depressed.
On all vehicles, the key should come out only in
Lock.
Parking brake and transmission
P (PARK) mechanism operation -
CAUTION I
4 When you are doing this check, your vehicle could begin to move.
You
or others could be injured and property could be damaged.
Make sure there is
room in front of your vehicle in case you begin
to
roll. Be ready to apply the regular brake at once should the
vehicle begin to move.
IW
Park on a fairly steep hill, with the vehicle facing downhill.\
Keeping your foot
on the regular brake, set the manual parking brake.
To check the parking brake: With the engine running and the
transmission in
N (Neutral), slowly remove foot pressure from the regular
brake pedal.
Do this until the vehicle is held by the parking brake only.
To check the “Park” mechanism’s holding ability: Apply the \
regular brake
and shift to
P (Park). Release the manual parking brake, then slowly
release the regular brake.
Lap and shoulder belts condition and operation -Inspect belt system,
including: webbing, buckles, latch plates, retractors, guide loop\
s and anchors.
Have a belt assembly replaced
if the webbing has been cut or otherwise
damaged.
Body
Lubrication Service -Lubricate all body door hinges with engine oil.
Also lubricate the tailgate, tailgate handle pivot points, and tailga\
te mounted
spare tire carrier
(if equipped). Lubricate the body hood, fuel door and rear
compartment hinges, latches and locks including interior glove
box and
console
doors, and any folding seat hardware. Lubricate the hood safety lever
pivot and prop
rod pivot. More frequent lubrication may be required when
exposed to a corrosive environment.
7-23
ProCarManuals.com