1993 CHEVROLET LUMINA service interval

Downloaded from www.Manualslib.com manuals search engine ~~ Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.)
Schedule I
Follow Schedule I if your vehicle is
MAINLY driven under
one or more of
the following conditions:
When most trips are less than 4 miles
When most trips are less than 10
(6 km)
miles (16 km) and outside
temperatures remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as
in stop-and-go traffic.
When towing a trailer.**
When operating in dusty areas.
Schedule I should also be followed if
the vehicle is used for delivery service,
police,
taxi or other commercial
applications.
* An Emission Control Service.
Irr The U.S. Environmental Protection Agency has
determined that the failure to perform this
maintenance item will not nullify the emission
warranty
or limit recall liability prior to the
completion
of vehicle useful life. General
Motors,
however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in Section
E: Maintenance Record.
ITEM
NO.
TO BE SERVICED
See .?Zaplanation ofSch&d Mairueme
Services following Schedules I and I[.
WHEN TO PERFORM
Miles (kilometem) or Months
(whichever
occumjmt). I
2 Chassis Lubrication I
Ti and Wheel Rotation and Inspection At 6,000 Miles (lo OOO km) and then every l5,OOO
Miles (25 000 km) or as necessary. I
Camshaft Ti Belt Inspection
(3.4L Engine, VIN Code X)*
At 60,000 miles (lo0 OOO km) and then every
lspoo miles (25 ooo km). I
10 I ' Spark Plug Wire Inspeaion** I Every 30,000 Miles (50 000 km). I
12 Exhaust Gas Recirculation (EGR) System
Inspection (2.2L Code 4 and 3.4L Code X
engines only)**
Every 30,OW Miles (50 OOO km). I
14 I Fuel Tank, Cap & Lines Inspection** I Every 30,000 Miles (50 OOO km). I1 I I

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (Cant.)
Schedule I/
Follow Schedule I1 ONLY if none of
the driving conditions specified in
Schedule
I apply.
* An Emission Control Service.
A The U.S. Environmental Protection Agency has
determined that the failure to perform this
maintenance item will not nullify the emission
warranty
or limit recall liability prior to the
completion of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in Section
E: Maintenance Record.
‘ 266
TO BE SERVICED ITEM
No ‘ See Explanation of Scheduled Maintenance
Services
following Schedules I and II .
WHEN TO PERFORM
Miles (kilometem) or Months
(whichever occurs first).
I 2 I Chassis Lubrication I Every 7,500 Miles (12 500 km) or 12 Months. I
Tire and Wheel Rotation and Inspection At 7,500 Miles (E 500 km) and then every l5,OOO Miles (25 OOO km) or as necessary. I
1 * I Transaxleservice
See Explanation of Schea!ded Maintenance Services
following Schedules I and II. I
Inspection (2.2L Code 4 and 3.4L Code X
engines only)**
I 14 I Fuel Tank, Cap and Lines Inspection** I Every 30,OOO Miles (50 OOO km). I

Downloaded from www.Manualslib.com manuals search engine The services shown in this schedule up to 45,000 miles (75 OOO km) are to be
performed after 45,000 miles at the same intervals.
MILES (000)
I 7.5 22.5 I 30 I 37.5 145 1
I KILOMETERS (000) I
I I I I I I I
I .. I
I I I I I I I 0
267 =

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (cont.)
Explanation of Scheduled Maintenance Services
Below are explanations of the services listed in Schedule I
and Schedule 11. The proper fluids and
lubricants to use are listed in Section
D. Make sure whoever services your vehicle uses these. All
parts should be replaced and all necessary repairs done
before you or anyone else drives the vehicle.
ITEM
NO.
1
2
SERVICE
Engine Oil and Filter Change*-Always use SG
Energy Conserving I1 oils of proper viscosity. The
“SG” designation may be shown alone or in
combination with others, such as “SG/CC,”
“SG/CD” or “SF, SG, CC,” etc. To determine the
preferred viscosity for your vehicle’s engine
(e.g.,
SAE 5W-30 or SAE 1OW-30) see the Index under
Engine Oil.
Chassis Lubrication-Lubricate the transaxle shift
linkage, parking brake cable guides, underbody contact points and linkage. Lubricate the front and
rear suspension.
ITEM
NO. SERVICE
3 Throttle Body Mounting Bolt Torque (3.1L
Code T or W engine only)*-Check the torque of
the mounting bolts and/or nuts.
4 Tire and Wheel Rotation and Inspection-For
proper wear and maximum tire life, rotate your
tires following the instructions in this manual. See
the
Index under Tires, Inspection G Rotation.
Check the tires for uneven wear or damage. If you
see irregular or premature wear, check the wheel
alignment. Check for damaged wheels also.
NOTE: To determine your engine’s displacement and code, see the Index under Engine Identification.
* An Emission Control Service.
* The US. Environmental Protection Agency has determined that the failure \
to perform this maintenance item will not nullify the emission
warranty
or limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended
maintenance services be performed at the indicated intervals and\
the maintenance be recorded in Section
E: Maintenance Record.
5 Engine Accessory Drive Belt Inspection
(California 3.1L Code T
or W engine*)-Inspect 1
the belt for cracks, fraying, wear and proper
tension. Replace as needed.

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (Cont.1
ITEM
NO.
12
13
SERVICE ITEM NO. SERVICE
Exhaust Gas Recirculation (EGR)
System
Inspection (2.2L Code
4 and 3.4L Code X
engines only)*-& as described in the service manual.
To purchase a
service manual, see the
Index under Service
Publications.
Air Cleaner Filter Replacement*-Replace every
30,000 miles (50 000 km) or more often under
dusty conditions.
Ask your dealer for the proper
replacement intervals
for your driving conditions.
14 Fuel Tank, Cap and Lines Inspection*+Inspect I
fuel tank, cap and lines (including fuel rails
and injection assembly) for damage
or leaks.
Inspect fuel cap gasket for an even filler neck
imprint or any damage. Replace parts as needed.
Periodic replacement of the fuel filter is not
required.
NOTE: To determine your engine’s displacement and code) see the Index under Engine Identification
* An Emission Control Service.
A The U.S. Environmental Protection Agency has determined that the failure \
to perform this maintenance item will not nullify the emission
warranty
or limit recall liability prior to the completion of vehicle useful life. General Motors, however, urges that all recommended
maintenance services be performed at the indicated intervals and the maintenance be recorded in Section E: Maintenance Record.

Downloaded from www.Manualslib.com manuals search engine Section B: Owner Checks & Services
Listed below are owner checks and services which should
be made at the intervals specified to help ensure the safety,
dependability and emission control performance of your
vehicle. Be
sure any necessary repairs are completed at once.
Whenever any fluids or lubricants are added to your vehicle,
make sure they are the proper ones, as
shown in Section D.
At Each he/ H// (It is important for you or a service station attendant to pe&m these underhood checks at each fuel fill.)
CHECK
I I Engine Coolant Level
I
Windshield Washer
Fluid Level
1 At Least Once a Month
WHAT TO DO
Check the engine oil level and add the proper oil if necessary. See the Index under Engine Oil for
further details.
Check the engine coolant level in the coolant recovery
tank and add the proper coolant mix if
necessary.
See the Index under Coolurzt for further details.
Check the windshield washer fluid level in the windshield washer tank and add the proper fluid
if necessary. See the Index under Windshield Washer Fluid for further details.
CHECK
I I OR SERVICE
Tire Inflation
I At Least Twice a bar
WHAT TO DO I
Check tire inflation. Make sure they are inflated to the pressures specified on the Tire-Loading
Information label located on the rear edge of the driver's door or inside the trunk lid.
See the
Inda under Tires for further details.
IL .I
CHECK
System Inspection
WHAT TO DO
Check the fluid level in the clutch reservoir. See the Iinda under Hydraulic Clutch. A fluid loss
in this system could indicate a problem. Have the system inspected and \
repaired at once.
27 I