1992 VOLKSWAGEN TRANSPORTER radiator

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

Warning
lamps

~ne layout of the warning lamps depends on
:ne model and the engine fitted. The sym-
: ols shown here are also on the actual warn-ng lamps.
|- Coolant temperature/ coolant level 47
1- Engine oil pressure 47
I- High beams 48
-- Turn signals 48

5-
Brake system 48
V Alternator 49
" Glow plugs 49 Coolant
temperature/

Coolant level1'

This
lamp flashes for a few seconds as a
functional check when ignition is switched
on.

If the lamp does not go out afterwards or

flashes
when driving, either the coolant
temperature is too high orthe coolant level1'
too low:
Stop,
switch
engine
off and check

level.
Add coolant if necessary.
11 Only on vehicles
with
automatic coolant level monitor(see page 102).
Attention

• Be
careful
when
opening the

coolant
expansion
tank!
When
the
engine
is hot the cooling
sys­

tem is
under
pressure -
Danger
of scalding!
Therefore
let
engine
cool
down
before
unscrewing

the cap.
• Do not
touch
the fan. The fan can
switch
on suddenly -
even

when
ignition
is
switched
off.

For
further details see pages 102 and 103.
If the coolant level is in order the trouble
may be due to failure of the radiator fan.

Check
radiator fan fuse and renew if
necessary-seepage
122.
If the warning lamp does not go out al­
though coolant level and fan fuse are in order, do not
drive
on - call in expert as­

sistance.

If the trouble is only caused by the fan and

assuming
coolant level is in order and tem­ perature warning lamp is out - one can drive
on to the nearest Volkswagen dealer. In
order to make good use of the air stream for

cooling,
do not let engine idle or drive very
slowly.
2 - Engine oil pressure -7
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DRIVING
TIPS

• Where possible make
full
use of the maximum permissible drawbar weight on

call
of the towing bracket - see page 151 -
cut do not exceed it.
• While observing the permissible trailer
and
drawbar weight, distribute the load in
the trailer so
that
heavy objects are as near
as
possible to the axle. The objects must
a
so be secured so
that
they cannot slip
aoout.
• Check the
tyre
pressures on the towing
/ehicle
and the trailer.
• The headlight settings, should be
:hecked
with
trailer attached before mov- ng off and adjusted as necessary.

On
vehicles
with
headlight beam control it

is
only necessary to
turn
the knurled disc in
:ash
in the appropriate direction.
Driving
instructions

To
obtain the best possible handling of ve­
hicle
and trailer, the following should be

noted:

• Try to avoid driving
with
an unladen ve­
hicle
and a loaded trailer. If this cannot be

avoided,
only drive slowly to allow for the unfavourable weight distribution.
• As driving stability of vehicle and trailer
decreases
when the speed increases do not
drive at the maximum permissible top
speed
in unfavourable road, weather or
wind conditions - particularly when going downhill. In any
case
the speed must be reduced im­
mediately the trailer shows the slightest

sign
of snaking. On no account try to stop
the snaking by accelerating.
• For safety reasons one should not drive faster than 80 km/h (50 mph). This also
applies
in countries where higher speeds
are permitted. • Always brake in good time. If the trailer

has
an overrun brake, apply the brakes gen­
tly at
first
then firmly. This will avoid the
jerk­
ing caused by the trailer wheels locking.

Change
down before going down a steep hill so
that
the engine can act as a brake.
• When a long climb in a low gear
with
ex­ tremely high engine revs must be nego­
tiated at exceptionally high ambient tem­peratures the coolant temperature gauge must be observed. When the gauge needle

moves
to the
>~zza'
e~z of :ne
scale,
the road speed must be reduced immediately. If nevertheless ~g amp flashes,
stop immediately and si ow the engine to

cool
off at idling speed for several minutes.
• The cooling effect of the radiator fan
can­
not be increased by changing down, be­

cause
the speec of t~e
~a~
s ~o! dependent
on the engine
speed.
One should therefore not change down even when towing a
trailer as long as :-e e-g -e zar cope with­ out the vehicle speed dropping too much.
83
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Engine
compartment

Page

Windscreen
washer
container
.. 108
Power
assisted
steering

fluid
reservoir*
100
Engine
oil filler
opening
97

Engine
oil
dipstick
97

Coolant
expansion
tank 102
Brake
fluid
reservoir
104

Battery
106 Attention
Particular care should be
taken

when working in the engine
com­
partment!

•
Switch off engine, remove ignition key.

•
Pull handbrake on firmly.

•
Move gear lever into neutral or
"P"
position.

•
Allow engine to cool off.

•
As long as the engine is at op­
erating temperature:

-
Do not put your hand into the radiator fan, it could switch on

suddenly.

-
Do not open the radiator cap be­
cause
the cooling system is

under
pressure.

•
Avoid causing short circuits in
the electrical system - particular­ ly at the
battery
-.
•
If tests have to be
carried
out

with
the engine running,
there
is
an additional danger
present

from rotating parts - e.g.
V-belts,
generator, radiator fan etc. - and
from the high voltage ignition
system.

Attention must be paid to the warnings given in this Instruc­
tion Manual and to the generally
applicable
safety regulations.
When topping up fluids one
should
ensure
that
they are not mistaken,

one
for the other, under any
circum­

stances,
otherwise serious
func­

tional defects
will
result.
So
that
leaks
are quickly de­
tected
the ground underneath
the vehicle should be checked
reg­

ularly.
If spots as caused by oil or

other
operating fluids can be seen, the vehicle should be
taken
to the
workshop for checking.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE
nere are two marks
with
which the oil level
:an be
checked.

• Outside on container (Fig.) • Inside on dipstick attached to the cap. ~he oil level should always be between the
MAX."
and "MIN" marks. When the level

"as
dropped down below the "MIN" mark

:^e
power assisted steering should be
:necked
at a Volkswagen dealer. It is not
sufficient merely to top up
with
hydraulic oil.

Note
f the power assisted steering fails at any
: me or when engine is not running (vehicle on tow) the vehicle remains fully steerable cut more force must be used to
turn
the
steering wheel. Cooling
system

Under
normal conditions the cooling
sys­

tem is almost maintenance-free.
The vehicle is
fitted
with
a hinged radiator
which can be folded forward when required
- see page 104.
The cooling system is filled at the factory
with
a permanent coolant which is not

changed.
The coolant consists of water and

a
40 % concentration of our coolant additive
G
11 V8B (anti-freeze on glycol basis
with

anti-corrosion additives). This mixture not
only gives the necessary frost protection
down to -25 degrees C but also protects the
alloy parts in the cooling system against cor­
rosion.
In addition it prevents scaling and ra­
ises
the boiling point of the coolant.
The concentration of the coolant therefore must not be reduced in the summer or in
warm countries, by topping up
with
plain
water. The
coolant
additive
propor­

tion
must
be at
least
40 %.
If greater protection against frost is re­
quired, the proportion of G 11 V8B additive

can
be increased, but only up to 60 % other­
wise the anti-freeze protection is reduced
and furthermore the cooling effect is im­
paired.
Vehicles
for export to cold countries -s~a .
have frost protection down to -35 decrees

C.

Only
our G 11 V8B or an additive v/rs :~e

specification
TL-VW 774 B (markea or
container) should be added to the coolant.
The additives can be obtained from
Volks­

wagen dealers.

Other
additives
can be
very
detri­

mental
to the
anti-corrosion
effect
in
particular.

The
subsequent
corrosion
damage
can
lead
to
coolant
loss
resulting
in

major
engine
damage.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Checking
coolant
level

The
expansion tank
is in the
engine
com­
partment on the bulkhead
-
see Fig.

The
correct coolant level
is
essential
to
the satisfactory operation
of
cooling system.
For
this reason, the coolant level should
be

checked
regularly,
and
this
is
best done
when refueling.

The
level
can
only
be
checked properly
when engine
is
not running.

The
coolant level must be between the MIN
and
MAX marks
on the
expansion tank
when engine
is
cold
and can be
slightly
above
the MAX mark when
it
is warm.
When
the
coolant level
is too low on ve­

hicles
with
an automatic coolant level moni­
toring device,
it is
indicated by the coolant
temperature/coolant level warning lamp
flashing continuously (see page 47).

Coolant
losses

Coolant
loss normally indicates leaks in the

system.
In
this
case
the
cooling system
should
be checked by a Volkswagen dealer

without
delay.
It is
not sufficient merely
to

add
coolant.
In
a
sealed system
losses
can only occur
if

the boiling point
of
the coolant is exceeded
as
a
result
of
overheating, and coolant
is

forced out
of
the system.
Overheating can occur
if:

• the flow
of
cooling air is reduced, e.g.
by
a
radiator
muff,
very
dirty
radiator fins
(leaves,
dust, insects)
or
additional driving
lights
in
front
of
the cooling air intake.
• the boiling point
of
the coolant has been lowered by an incorrect mixture
-
see previ­

ous
page.
•
the
radiator
fan is not
working
- see
"Fan"
on next page
-
or, • the vehicle
is
driven up
a
long hill
in too

low a gear
with
engine speed very high and
at very high ambient temperatures
-
see
"Fan"
on
next page.
If
the
cause
of the
overheating cannot
be

found
and
eliminated, contact
a
Volks­
wagen dealer
as
soon
as
possible other­

wise
serious damage may
be
done
to the
engine.

Topping
up
coolant
Switch
engine
off
and let
it
cool down. Then

cover
expansion tank cap
with
a
cloth and

turn
cap carefully
to
the
left
and remove.

Attention
Do
not
remove
expansion
tank

cap
when
engine
is
hot
-
Danger
of scalding.

System
is
under
pressure.

If, in an
emergency only water
can be

added,
the
correct mixture concentration must be restored
with
the specified coolant
additive (see previous page)
as
soon
as
possible.

•02
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

"=
lot
of
coolant has been lost, only add cold
:_:olant after
the
engine has cooled down.

~~
is
will prevent engine damage.
Do
not
fill
above the MAX. mark.

~~e
excess
coolant will
be
forced
out

"rough
the
pressure relief valve
in the
cap .-.nen engine becomes
hot.

Screw
cap on again tightly. Attention
The coolant additive and the coolant are a danger to health.
The additive must therefore only be stored in the original
con­

tainer
well
out of reach of
children.
If the coolant has to be
drained at any
time
it must be
caught and also stored in a safe
place.

Drained
coolant
should
not nor-
W*
mally
be
reused,
it
must
be
dis­
posed
of,
bearing
in
mind
environ­
mental
protection
regulations.
Fan
The radiator
fan is
driven electrically
and
controlled by a thermoswitch from the
cool­

ant temperature (also from the engine
com­
partment temperature on some models).

Attention
After the engine has been
switched off the fan can
con­

tinue running for a
while
(up to
about 10 minutes)
with
the igni­
tion off. It can also
start
to run
again suddenly
after
a short time, if the coolant temperature in­

creases
due to
heat
build-up.

Special
care must therefore be
taken when working in the en­ gine compartment. Notes

•
If
the fan is not running although the
cool­
ant temperature
is
very high,
the rse

should
be
checked
and if
necessary
re­
newed
-
see page 122.
• The speed
of
the fan does not depeno
or
engine
speed.
The
cooling effect cannot
therefore
be
increased
by
changing down.

As
long as
the
engine runs smoothly and
a
gradient can
be
taken
without
a
large drop in speed
it
is not necessary to change down.

Driving in
winter

To
ensure
that
the
frost protection
is ad­
equate, the coolant concentration should be

checked
and
if
necessary corrected, before
the cold
season
begins.
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
GENERAL
MAINTENANCE

Moving
radiator
forwards
For certain operations in the engine
com­

partment e.g. changing plugs or to reach the
V-belt it may be necessary to move the
radi­
ator forwards.
To do this
first
remove the four securing
screws
(left
illustration).
Then
lift the radiator and move it forward.
When work in the engine compartment is
finished the radiator must be moved back to
the normal position and secured with the screws.
Brake
fluid

The brake fluid reservoir is in the engine compartment.

Note
On
vehicles with righthand drive the reser­
voir is on the other side of the engine
com­
partment.
104
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans

Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Fuse
layout

<*'om
left
to
right)

No.
Component
A11
' - Dipped beam
left,
headlight range control
left
10
I- Dipped beam
right,
headlight range control
right
10
3-
Instrument
and number plate lighting 10
--
Rear
wiper, seat heating 15

5-
Windscreen wiper,
windscreen and rear window

washer/elec.
heated

washer
jets 15

5-
Blower, air conditioner 30
/- Tail and side
light
right,
engine compartment
light
10

3-
Tail and side
light
left
10
9-
Rear
window heating, mirror heating 20

10-
Fog lights, rear fog
light
15
II- High beam
left,
high beam
warning lamp 10

12-
High beam
right
10

13-
Horn, radiator fan (run-on) 10
1 Ampere No.
Component
A

14-
Reversing lights, electric outside mirrors, sliding/tilting
roof,
shift pattern auto, gearbox,

cruise
control system
(cancel contacts on the brake
and clutch pedal) 10

15-
Engine electronics 10

16-
Warning lamps,
dash
panel insert,
glove box
light
15

17-
Turn signals 10

18-
Electric fuel pump,

Lambda
probe 20

19-
Radiator fan, air conditioner 30

20-
Brake lights 10

21-
Interior
and luggage compartment lights, make-up mirror
light,

clock,
radio,
central locking 15

22-
Cigarette lighter 10
Additional
fuses
(in separate holders)
• above the relays A11

Fuse
for electric windows 20
• In the engine compartment on the bulk­
head
above the brake servo:

Glow
plugs21 50
• Under the driver's seat

Fuse
for additional water heater 10

Fuse
for heater blower .30

Fuse
for water heater
glow plug 20
Fuse
for auxiliary heater3' 25
Fuse colour code:

Red:
10 Ampere

Blue:
15 Ampere

Yellow:
20 Ampere

Green:
30 Ampere
21 This fuse should only be renewed by
a
Volks­
wagen dealer.
31 On vehicles
with
swivelling seats this fuse
can
be found in the side
trim
behind the
driver's seat.

123
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans