Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT
Three-point
inertia
reel
belts
The
inertia reel belt gives complete freedom
of movement when pulled slowly. Sudden braking however will cause the belt to lock.
The
mechanism will also lock the belt when
accelerating,
driving down steep gradients
or cornering.
Putting
belt
on
Pull
the tongue slowly and smoothly across
the chest and hips and push it into the lock part
fitted
on the seat until the tongue en
gages
audibly (pull to check).
The shoulder
part
of
belt
must
run
roughly
across the
centre
of the
shoulder as
shown
- on no account
against
the
neck
- and be
firmly
in
contact
with
the body.
The backrests of the
front
seats
must
not be inclined too far to the
rear,
otherwise
the
belts
are no
longer
fully
effective.
With the aid of the
belt
height
adjust
ment
the routing of the
front
seat shoulder
belt can be set to fit the body properly.
• To adjust, push button
with
relay
fitting
(see
right
illustration) up or down so
that
the
shoulder
part of belt runs roughly across the centre of the shoulder as shown on the
left
- on no account
against
the neck.
• After adjusting, pull the belt
with
a
jerk
to
ensure
that
the relay
fitting
is properly en
gaged.
16
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans
Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Fuses
The
individual current circuits are protected by fuses..
The
central electrics
with
the relays is on
the
left
in the footwell behind a hinged shelf. It is advisable to always carry a few spare
fuses
on the vehicle. These can be obtained
from any Volkswagen dealer. Changing a fuse
• Switch off the component concerned. • Take box or lid off by turning knob 90 de
grees
to
right
or
left,
then pull and unhook box or lid out of retainers at the bottom.
• With the aid of the list of fuses (see next
page),
determine which fuse belongs to the
component
that
has failed. • Pull out the fuse concerned.
• Replace blown fuse - can be recognised
by the burnt metal strip -
with
a fuse of
same
amperage.
• Insert box or lid by turning knob again
905
to
right
or
left,
hook box or lid on at bot
tom, swing up and press knob in.
Notes
• If the newly inserted fuse blows again after a short time, the electrical system must be checked by
a
Volkswagen dealer as
soon
as possible.
• On no account should fuses be
patched
up because
this
can cause
serious
damage
elsewhere
in the
electrical
system.
• Some of the components listed are only found on certain models or are optional ex
tras.
122
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans
Downloaded from www.Manualslib.com manuals search engine
DO-IT-YOURSELF
Fuse
layout
<*'om
left
to
right)
No.
Component
A11
' - Dipped beam
left,
headlight range control
left
10
I- Dipped beam
right,
headlight range control
right
10
3-
Instrument
and number plate lighting 10
--
Rear
wiper, seat heating 15
5-
Windscreen wiper,
windscreen and rear window
washer/elec.
heated
washer
jets 15
5-
Blower, air conditioner 30
/- Tail and side
light
right,
engine compartment
light
10
3-
Tail and side
light
left
10
9-
Rear
window heating, mirror heating 20
10-
Fog lights, rear fog
light
15
II- High beam
left,
high beam
warning lamp 10
12-
High beam
right
10
13-
Horn, radiator fan (run-on) 10
1 Ampere No.
Component
A
14-
Reversing lights, electric outside mirrors, sliding/tilting
roof,
shift pattern auto, gearbox,
cruise
control system
(cancel contacts on the brake
and clutch pedal) 10
15-
Engine electronics 10
16-
Warning lamps,
dash
panel insert,
glove box
light
15
17-
Turn signals 10
18-
Electric fuel pump,
Lambda
probe 20
19-
Radiator fan, air conditioner 30
20-
Brake lights 10
21-
Interior
and luggage compartment lights, make-up mirror
light,
clock,
radio,
central locking 15
22-
Cigarette lighter 10
Additional
fuses
(in separate holders)
• above the relays A11
Fuse
for electric windows 20
• In the engine compartment on the bulk
head
above the brake servo:
Glow
plugs21 50
• Under the driver's seat
Fuse
for additional water heater 10
Fuse
for heater blower .30
Fuse
for water heater
glow plug 20
Fuse
for auxiliary heater3' 25
Fuse colour code:
Red:
10 Ampere
Blue:
15 Ampere
Yellow:
20 Ampere
Green:
30 Ampere
21 This fuse should only be renewed by
a
Volks
wagen dealer.
31 On vehicles
with
swivelling seats this fuse
can
be found in the side
trim
behind the
driver's seat.
123
www.vwT4camper.info - a useful website for owners and enthusiasts of VW T4 Transporter Campervans
