CONTROL SYSTEM F
VB: Battery voltage
Incorrect voltage Possible cause
Always OV l ROOM 10A fuse burned l Open circuit in wiring from ROOM 10A fuse to ECU terminal 1A
Always OV
l Main relay malfunction (Refer to page F-171) l Open or short circuit in wiring from main relay to ECU terminal 1B
Always OV (Starter turns)
l Open or short circuit in wiring from or inhibitor switch (ATX) to ECU termi-
nal 1C
Always OV
Always Ve
Always 4.5~5.5U
l Main relay (FUEL INJ relay) malfunction (Refer to page F-171) l Open circuit in wiring from main relay to diagnosis connector terminal +B l Open or short circuit in wiring from diagnosis connector terminal MEN to
ECU terminal 1D
l Poor connection at ECU connector l ECU malfunction
l ECU malfunction
Always below
25v
Always Va MIL always ON
MIL never ON
l Short circuit in wiring from combination meter to ECU terminal 1E l ECU malfunction
l Open circuit in wiring from combination meter to ECU terminal 1E
l Poor connection at ECU connector l ECU malfunction
Always below
2.5V
Always VB No display on Self- * Main relay (FUEL INJ relay) malfunction (Refer to page F-171)
Diagnosis Checker
l Open circuit in wiring from main relay to diagnosis connector terminal +B
“88” displayed and
l Open or short circuit in wiring from diagnosis connector terminal FEN to
buzzer sounds con- ECU terminal 1F
tinuously
l Poor connection at ECU connector l ECU malfunction
Always OV
l Short circuit in wiring from igniter to ECU terminal 1G
Always below 1 .OV (Headlights OK)
l Open or short circuit in wiring from headlight relay to ECU terminal 1H
(Refer to page F-171)
Always OV
Always VB
Always OV Illumination lamp
ON when rear
window defroster
switch ON
Illumination lamp
never ON
Approx. 5V (California)
Always OV (Canada)
l Short circuit in wiring from diagnosis connector terminal TEN to ECU termi-
nal II
l Open circuit in wiring from diagnosis connector terminal TEN to ECU termi-
nal II
l Open circuit in wiring from diagnosis connector terminal GND to ground
l Open or short circuit in wiring from rear window defroster switch to ECU
terminal 1 J
l Open circuit in wiring from ignition switch to rear window defroster switch l Rear window defroster switch malfunction (Refer to page T-21)
l Open circuit in wiring from ECU terminal 1K to ground
l Short circuit in wiring from ECU terminal 1K to main relay (FUEL INJ relay)
23UOFX-14: 2
f-1 59
INSTRUMENT CLUSTER T
Symptom: Water temperature gauge does not operate.
9MUOTX-072
W/ TACHO W/O TACHO
OSUOTX-111
0
23UOTX-041
WI TACHO
W/O TACHO
9MUOTX-076
Step 1
1. Disconnect the connector from the water thermosensor.
2. Connect the red lead of the
SST to the connector and the
black lead to a body ground.
3. Set the
SST to the resistance values shown in the figure.
4. Turn the ignition switch ON, and check that the needle in-
dicates the correct values.
Gauge displays correct Action
Yes Replace water therm0 sensor
No Go to Step 2
Caution
l Continue the above checks for at least two minutes
each to correctly judge the condition.
l The allowable indication error is twice the width of
the needle.
Step 2
1. Remove the instrument cluster. (Refer to page T-69.)
2. Apply battery voltage to terminal 2L and ground terminal 2E.
3. Connect the red lead of the
SST to terminal 3L and the black
lead to a negative battery terminal.
4. Set the
SST to the resistance values shown in the figure.
5. Verify that the needle indicates the correct values.
Indicates correct
Yes Action
Repair wiring harness
(instrument cluster - Water thermosensor)
I--~ No I ReDlace water temperature gauge
I
Caution
l Continue the above checks for at least two minutes
each to correctly judge the condition.
l The allowable indication error is twice the width of
the needle.
T-67
Z-GI-10 Reading Wiring Diagrams
Logic symbols
‘ypes of logic symbols Operation Expressing output Simple relay circuits
OR Input to A or 6 will Low electrical potential (L) at A and B --,
produce output at C No output (L) at C
High electrical potential (H) at A or B -+ A
A
ID- C Output (H) at C
EB Q-f2 c
B B
AND Input to A and B will High electrical potential (H) at A and B -+
produce output at C Output (H) at C
A _
A
El-- Low electrical potential (L) at A or B -+
B C
No output (L) at C
B
II!I3 Q-00-Q
C
INV No input to A will produce Low electrical potential (L) at A +
an output at B
Ungrounds (H) B
-b- Input to A will not produce High electrical potential (H) at A +
A B
any output at B Grounds (L) B A-
El
PROCESS Simplified representation of complex functions within circuit Describes (Examples)
main function
Breakerless transistor
---
-I- 1 1 Signal detector for emission control unit, cooling unit and
I igniters
- ~._..._...._._..._._..__,
--L--A tachometer
P.Signal converter for turn and hazard flasher unit,breakerless : siinalcon”elter :
i..-.--...-.........---i
transistor igniter unit, etc. --j CoIlsignal ConVerted e
--I. .‘p. Y?YT?!!9’. . _ i
Abbreviations used in this booklet
A
%J Ampere
Auto Stop
Air Supply Valve
A/C AAS
Air Conditioner Auto Adjusting Suspension
A/F Air Fuel ABS
AIR Anti-lock Brake System
Auto Reverse
A/T ACV
Automatic Transmission
ACC Air Control Vafve
Acc%K4tIory
ACCEL Accelerator
ADD AE
Additional Acoustic Equilibration
ALT Alternator
EP AIS
Amplitude Modulation Air Injection System
Amplifier ALL
ANT Antenna Automatic Load Levelino
ATP Atmospheric Pressure
ATX Automatic Tmnsaxle FR Fmnt Right ELI?
FIB Feedback
F/I Fuel Injector Emergency Locking Retractor
EN ELEC Electric
Frequency Modulation
Generator
HEI Electronic Tuner
Hiih Energy lgnitiin
HID K!
Heat/Defmster
HEAT Heater Exhaust
HI Hiih F
ISC Front
Idk Speed Contml
IG Ignition
ILLUMI Illumination FICB
INT Intermittent FL Fast Idle Cam Breaker
Fmnt Left
JB
LH Joint Box
Left Hand
:AC Battery
Bypass Air Control Valve
B/L Ei-Level
CPU Central Pmcessing Unit
CSD COM start Device
CARB Carburator
CCT Circuit
CIGAR Cigarette
COMBI Combination
CON Conditioner
CONT Control
DOHC Double Overhead Camshaft
DEF Defroster
ECPS Electronicalfy Controlfed Power
Steering
EGI Electronic Gasoline Injection
EGR Exhaust Gas Recirculation LCD Liquid Crystal Display
:i Low
Low Wave
/IL Motor
MaWunction Indicator Lamp
MTR Mechanical Tuning Radio
Mrr Manual Transmission
MID Mkfdk,
MIN Minute
MIX
MiXtUt MPX Mukiplex
MTX Manual Transaxte
K Middle Wave
Normalty Closed
too Normally Open
Over Drive
OFF Switch Off ON
FRCV
PTC
P/S
PRG
ass
ii:
RPM
EC
SOL
ST
Et TCV
TICS
TEMP
ES
V
VRIS
VENT
VOL
W Switch On
Power
Pressure Regulator Control
Solenoid Valve
Positiie Temperature
Coefficiint Heater
Power Steering
Purge Solenoid Vahe
Quick Start System
Rear
Riiht Hand
Rear Left
Revolution Per Minute
Rear Right
Recirculation
Solenoid
Start
Short Wave
Switch
~;eScml Turbocharger Solenoid
Triple Induction Control System
Temperature
Transistor
Total Wiring System
volt
Variable Resonance Induction
System
Ventilation
Volume
Wan
