1992 MAZDA 323 window

GI IDENTIFICATION NUMBER tOCATlONS/UNlTS/ABBREVIATlONS
IDENTIFICATION NUMBER LOCATIONS
VEHICLE tDENTtRCATtUN NUM8ER (VIM) ENGINE MODEL AND NUMBER
I
UNITS
N.rn { kgf m or kgfcm,
f-t&f or tn.lbf 1 . . . . . . . . . . . . . . . . Torque
rpm ._ . . . Revolutions per minute
A.. ,_...___.... Ampere(s)
v I... Volt(s)
$2 . .._..__......_.....__... Ohm(s) (resls‘tance)
kPa { kgflcm*, psr] . . . . . . . Pressure
{usually positive)
mmHg I inl-lg ] . . . . . . . . . Pressure
(usually negatrve)
W . . . ._ .._.__ .._ . . . . . . ..,......... Watt
titers [US qt, Imp qt 1 . V&me
mm { rn 1 . . . . . . . . . . . . . . . . . . . . . . . Length
89UOGX-006
ABBREWATIONS
ABDC _. . . . . . . . . . . After bottom dead
center
A/C . . . . . . . ._.. _. . . . . . . . . Air conditioner
ACC .__ . . . . . . . Accessones
ATX .._ ._ . . . . . . . . . . . . . . Automate transaxle
ATDC _.. __ _. . . . . After top dead center
ATF ,... ._....__._.. Automatic transmission
fluid
BAC ._ . . . . . . . . . . . . . . ,. Bypass air control
BBDC _. . . . . . . . . . . . . .._. Before bottom dead
center
BTDC ., ._._... . . . Before top dead center
CPU . . . . . . . . . Central processrng unit EC-AT
........................... Electronrcally-controlled
automatic transmlsslon
ECU ._ ....................... Engine control unit
EG 1 ..................... Electronc gasoll ne
injectron
E/L. ............................ Electrrcal load
EX .............................. Exhaust
IC ................................ Integrated clrcult
IGN ........................... lgnrtlon
IN ..... ........................ Intake
INT
............................... Intermittent
ISC ............................ Idle speed control
U-l ................................
Left hand
M..
........................... Motor
MIL
........ ...................... MatfunctIon Indicator
iamp
MTX. ........................... Manual transaxle
00.. .............................. Overdnve
Of F .............................. Swrtch off
ON
............................... Switch
on
PCV .............................. Positive crankcase
ventilation
PRC .......................... Pressure regulator
control
P/S ............................. Power steerrng
P/W ............................
Power window
RH ............................... Rlght hand
SST
............................. Special service tool
ST.. ............................... Starl
SW.. ............................. Switch
TDC. ............................ Top dead center
4WD .............................
4-wheel drive
03UGIX-802
INS7
If a t’
and
Whe
1, II-!
2. II-!
3. E-
4. Dr
W-1 2

A PRE-DELIVERY INSPECTION TABLE
PRE-DELIVERY INSPECTION TABLE
[EXTERlORI
INSPECT and ADJUST, of necessary. the followlng Items to
specrfrcatron:
0 Glass, exterior bright metal and paint for damage
0 Wheel lug nuts
0 Tire pressures
0 All weatherstrips for damage or detachment
0 Operation of bonnet release and look
0 Operation of trunk Ild, hatch and fuel lbd opener
(of equipped)
0 Door operation and alignment
0 Headtrght aiming
INSTALL the foltowrng parts
0 Wheel caps or rrngs (if equipped)
0 Outsrde mirror(s)
1 UNDER BONNET-ENGINE OFF j
INSPECT and ADJUST. If necessary, the following items to
specrflcatlon.
0 Fuel, coolant and hydraulic tines, fittings, connectlons and
components for leaks
0 Engine 011 level
0 Power steering fluid level (of equipped)
0 Brake master cylinder fluky levels
0 Clutch master cylinder fturcl levels (If equipped)
0 Wtndshreld washer reservojr flurd level
0 Radiator coolant level and specrfic gravity
0 Tightness of water hose clamps
0 Tightness of battery terminals, electrolyte level and specific
gravity
0 Manual transaxle oil level
0 Drive belt(s) tension
Cl Carburetor lrnkage (choke control, wrde open throttle posi-
tion. etc ) (carburetor model only)
q Accelerator cable and linkage for free movement
0 Headlight cleaner and flurd level (if equipped)
BLEED air from fuel line (diesel engrne only)
CLEAN the spark plugs (except for diesel engine)
piEi6F]
INSTALL the following parts
0 Rubber stopper for rnsrde rear view mirror (if equjpped)
0 Fuse for accessories
CHECK the operation of the following items.
0 Seat controls (sliding and reclining) and head rest
0 Seat belts and warning system
Cl Ign&on switch and steering lock
0 Power window (if equipped)
D Door tacks including child proof door locks
Cl Inhibitor switch (ATX only)
Cl All Ikghts rncluding warning and Indicator lbghts
0 Ignition key reminder buzzer (If equipped)
A-Z
0 Horn, wbpers and washers (front and rear, If equipped)
0 Antenna (tf equipped)
0 Cigarette Ibghter and clock (if equipped)
0 Remote control outside mirror (if equrpped)
0 Heater, defogger and air conditioner at various mode selec-
tions (if equlppedj
0 Sunroof (If equipped)
CHECK the following items
0 Presence of spare fuse
0 Upholstery and Interior finish
CHECK and ADJUST, If necessary, the followjng items:
IJ Operation and fit of windows
0 Pedal height and free play of brake and clutch pedal
0 Parking brake UNDER BONNET-ENGINE RUNNING AT
OPERATING TEMPERATURE
CHECK the following items:
0 Operation of Idle-up system for air condbtroner or power steer-
ing (if equrpped)
0 Automatic transaxle flurd levet
0 tnltial ignrtlon timing (except disel engine)
0 Idle speed
0 Operation of throttle positron. sensor (EGI engrne)
0 Operation of cold start device and glow plug warning light
(diesel engine only)
0 Operation of dash pbt (EGI.engine)
fTiGGJ
CHECK the following items.
0 Underside fuel, coolant and hydraulic Irnes, ftttlngs, connec-
tions and components for leaks
0 Trres for cuts or brurses
0 Steering Itnkage, suspensron, exhaust system and all under-
side hardware for .looseness or damage 1 ROAD TEST j
CHECK the following items
0 8rake operation
0 Clutch operation
0 Steering control
!ZI Operation of meters and gauges
Cl Squeaks, rattles or unusual noises
Cl Engine general performance
0 Emergency locking retractors 1 AFTER ROAD TEST ]
REMOVE the seat and floor mat protective covers
CHECK for the necessary owner information materials, took
and spare tire
m vehicle
93EOAX-002
-- MAIN Char3 t: In
A: PC R: F!t T: Ti! Emis! The ed : to t!

SCHEDULED MAINTENANCE SERVICES A
SCHEDULED MAINTENANCE SERVICES
MAINTENANCE TABLE
Chafi symbols:
1 : Inspect: Visual examination and/or functional measurement of system’s operation or
performance , A: Adjust: Examination resulting in adjustment or replacement
n
R: Replace or change
T: Tighten
REMARKS
After 80,000 km or 48 months, continue to follow the described maintenance at the recommended intervals.
As for * marked items in this maintenance chart, note the following points.
+ 1 Major service interval at 12 months/20,000 km (12,000 miles).
Lubrication service based on distance only 10,000 km (6,000 miles) not time.
l 2 Adjust or inspect alternator and water pump drive belt, and power steering and air conditioner drive belt
if equipped.
‘3 Replacement of the timing belt is required at every 100,000 km (60,000 mile). Failure to replace the tim-
ing bett may result in damage to the engine.
‘4 tf the vehicle is operated under any of the following conditions, it is suggested that the engine oil and
oil filter be changed more often than the recommended intervals.
a) Driving in dusty conditions. I
:
b) Extended periods of idling or low speed operation. i
i!
c) Driving for a prolonged periods in cold temperatures or regularly driving onty short distances.
*5 If the vehicle is operated in very dusty or sandy areas, inspect and, if necessary, replace more often
than at usual recommended intervals.
l 6 This IS a full function check of all electrical systems, i.e, atl
ltghts. washers (including condition of blades)
electric windows, sunroof, horn etc.
‘7 Replace every two years. $1
‘I
If there has been continuous hard driving, mountain
drivtng, or if the brakes are used extensively or the
vehicle is operated in extremely humid climates, the brake fluid should be changed annually.
Emission Control and Related Systems
The ignition and fuel systems are vitally important to the proper operation of the-emission control and relat-
ed system, as well as for efficient engine operation. It is strongly recommended that all servicing related
to these systems be done by your Authorised Mazda Dealer.
13EOAX-302 -4
I!
A-3

F3 TROUBLESHUOTING GUIDE
TROU8LESHOOTlNG GUIDE
RELATIONSHIP CHART
.

OUTPUT DEVICE
INPUT DEVICE

w
3
s
s
KNOCK SENSOR
0
0 0 0 DtAGNOStS CONNECTOR
(TEN TERMINAL)
0 0 0 IGNITION SWlTCH
(START POSITION) 0 0
0
0
0 0
0 0
0 0
0
0
0
0
0 0 0 0
E/L SIGNAL* 0
P/S PRESSURE SWITCH 0
0
A/C SWtTCH
NEUTRAL AND CLUTCH
SWITCHES
STOPLIGHT SWITCH
ATMOSPHERIC PRESSURE
SENSOR (IN ECU)
THROTTLE SENSOR
0 0 0 0
0
0
0 0’
0
0 0
0
0 0
0
’ 0
0
0 0 0 0 0 0 0
0 I
0 ~ INTAKE AIR THERMOSENSOR 0 0 0 0
0 -~
OXYGEN SENSOR
0 0 0 0 WATER THERMOSENSOR
A
0
* 0 0 0 c 0
13
3F3-32 IN, o . E/L SIGNAL: Blower fan control switch second position or higher, electric cooling fan operating, headlights
rear window defroster ON.
F3-19
i

F3 CONTROL SYSTEM
Ve: Battery voltage
Termina
1N ’
10
1P
IQ
IR
IS
1T
tlJ
IV Jnput Outpul
0
0
0
0
0
0
0
0
0 Connected to
Throttle sensor
(idle switch) Test condition
Correct voltage Remark
Accelerator pedal released
Below 1.0V
lgnltlon switch
Accelerator pedal depressed
VI3 ON
Foglrght relay
P/S pressure
switch Fogtight switch ON
Fogfight switch OFF
Ignition switch ON
P/S pressure switch ON at Idle
PIS pressure switch OFF at idle Va
ov
V3
Below 1 .OV
VB -
-
A/C switch A/C switch ON
A/C switch OFF Below 23 Ignition switch
Va ’ ON and blower
motor ON
1 f Ekctrtc cooltng fan Fan operating (coolant temperature over
Below 1 .OV
switch
97OC 1207OF 1 or diagnosis connector
terminal TFA grounded) -
Fan not operating (Idle)
VI3
Blower control Blower control switch OFF or 1st position
.Va
swbtch Ignitton switch
Blower control switch 2nd or hjgher po-
Below 1 .OV ON
sition
Rear window
defroster switch Rear window defroster OFF
Rear window defroster ON Below 1 .OV Ignition switch
V0 ON
Headlight switch
Headfights ON Va
Headlights OFF -
Below 1.OV
Neutral/Clutch
Neutral position or clutch pedal
9eJow I .OV
switches
depressed
Others
Va
7
r u-.
I-I-I
f
2y 2w 2u 2s 20 20 2M 2K 21 2G 2E 2C 2A 1U 1s 10 10 1M 1K 11 rG IE tC ;A
22 2% 2V 2T 2R 2P ZN 2L 25 2H 2F 2D 28 tV 1T ‘IR IF 1N It ;J. IH IF ID 18
i
A
F3-48
-- Alwa@
Always
Always
Always
--
Always
--
Always
--
Always
--
Always
--
Always
(electric
--
Alway<;
--
Always
-e
Afway?;
I .ov
Always
--
Always
--
Alway:;
--

-. _.. . . . . . _ - ._.
-w
CONTROL SYSTEM F3
I .
-.
Ve: Battery voltaae I
Incorrect voltage
Atwafi below 1 .OV
Always VB
Always VS (foglight switch OK)
Always below 1 .OV
Always below 1 .OV
Always Vs
Always
below 23 (blower fan OK)
Always VB (blower fan OK)
Always below 1 .OV
(electric cooling fan OK) -
1-
Possible cause
l Throttle sensor mrsadjustment l Short circuit in wtrrng from throttle sensor to ECU terminal 1 N l ECU malfunction
l Throttle sensor mrsadjustment l Open circuit in wiring from throttle sensor to ECU terminal fN l Open circuit in mnng from throttle sensor to ECU terminal 20
l Foglight relay malfunctron
l Foglrght relay malfunction
l P/S pressure switch maltunctron l Short crrcurt In wrrlng from P/S pressure switch to ECU terminal 1 P l ECU malfunction
l P/S pressure switch malfunction l Open circuit in wlnng from P/S pressure switch to ECU terminal 7 P l Open circuit in wiring from P/S pressure switch to ground
l A/C switch malfunctron l Short circuit tn wiring from A/C switch to ECU terminal 1Q l Poor connection at ECU connector l ECU malfunction
l #C swatch malfunction l Open circuit in wiring from A/C switch to ECU terminal 1Q l Open circuit in wiring from A/C switch to blower control switch
l Open or short circuit in wiring from fan relay to ECU terminal 1R l ECU matfunction
Always below 1 .OV (blower fan OK}
Always Vs (btower fan OK)
Always betow illumination lamp
1 .ov ON when rear
window defroster
switch ON
Illumination lamp
never ON
Atways below 1 .OV (headttghts OK)
l Short circuit in wrrtng from blower control switch to ECU terminal IS l Poor connection at ECU connector l ECU m&function
l Open crrcuit in wrrrng from blower control switch to ECU terminal 1s
l Open or short crrcuit In wiring from rear window defroster switch to ECU
terminal t T
l Open circuit in wiring from ignitron switch to rear window defroster switch l Rear window defroster switch malfunction
l Open or short circuit in wiring from headlight relay to ECU terminal 1 U
Always below 1 .OV
l Neutral switch malfunction l Clutch switch malfunction l Short circuit in wiring from ECU terminal IV to neutral or clutch switch
Always VB
l Neutral switch malfunction l Clutch switch malfunction l Open circuit in wiring from ECU terminal 1V to neutral or clutch swdch l Poor connection at ECU connector
13FOl=3-36 .
F3-49
.:i

ST SPECtAL TOOLS
CHECKER AND OTHER EQUIPMENT
49 0187 280
Checker, fuel &
thermometer
49 0305 870A
Fool set, window
$9 HO18 9A1
System selector 49 GO18 903
Adapter harness
49 F018 002
Igniter checker
19 NO18 001
Adapter harness
49 DO66 8OlA
;lemoving tool
-
- -
ST-1 0

SYSTEM INDEX
ENGINE-RELATED SYSTEMS STARTING SYSTEM...............2 4
CHARGING SYSTEM...............2 6
ENGINE CONTROL SYSTEM.........2 8
COOLING FAN SYSTEM............3 6
CHASSIS-RELATED SYSTEMS ANTI-LOCK BRAKE SYSTEM........82
INSTFUJMENT CLUSTER-RELATED SYSIEMS IrS$;MENT CLUSTER 6 WARNING
........................ 38
BODY-F&LATEX) SYSTEMS
WINDSHIELD WIPER 6 WASHER.....4 0
HEADLIGHT CLEANER.............4 0
REAR WIPER & WASHER...........4 2
HORNS...................,......6 0
REAR WINDOW DEFROSTER.........6 4
SOUND WARNING SYSTEM..........6 6
POWER WINDOWS.................7 4
POWER DOOR LOCK...............7 6
POWER OUTSIDE MIRRORS.........7 8
SLIDING SUNROOF...............8 0
SEAT WARMERS..................8 4
INTERIOR LIGHTING SYSTEMS IG KEY CYLINDER LAMP..........6 6
INTERIOR 6 SPOT LAMPS.........6 6
COURTESY LAMPS................6 8
TRUNK COMPARTMENT LAMP........6 8
ILLUMINATION LAMPS............7 0
EXTERIOR LIGHTING SYSTEMS
HEADLIGHTS
EXCEPT F.R.GERMANY...........44
F.R.GERMANY..................46
HEADLIGHT LEVELING SYSTEM.....46
TAILLIGHTS
EXCEPT F.R.GERMANY...........48
F.R.GERMANY..................5 0
LICENSE PLATE LIGHTS
EXCEPT F.R.GERMANY...........4 8
F.R.GERMANY..................5 0
POSITION LIGHTS
EXCEPT F.R.GERMANY...........4 4
F.R.GERMANY..................!i? 0
FRONT 6 REAR FOG LIGHTS.......52
TURN 6 HAZARD FLASHER
LIGHTS.......................54
STOPLIGHTS
F.R.GERMANY.a................5 6
EXCEPT F.R.GERMANY...........5 8
BACK-UP LIGHTS................6 0
AIR CONDITIONING-RELATED SYSTEMS HEATER........................6 2
ACCESSORIES CIGARETTE LIGHTER.........<....64
DIGITAL CLOCK.................64
AUDIO SYSTEM..................72
OTHER DIAGNOSIS CONNECTOR...........86