A PRE-DELIVERY INSPECTION TABLE
PRE-DELIVERY INSPECTION TABLE
[EXTERlORI
INSPECT and ADJUST, of necessary. the followlng Items to
specrfrcatron:
0 Glass, exterior bright metal and paint for damage
0 Wheel lug nuts
0 Tire pressures
0 All weatherstrips for damage or detachment
0 Operation of bonnet release and look
0 Operation of trunk Ild, hatch and fuel lbd opener
(of equipped)
0 Door operation and alignment
0 Headtrght aiming
INSTALL the foltowrng parts
0 Wheel caps or rrngs (if equipped)
0 Outsrde mirror(s)
1 UNDER BONNET-ENGINE OFF j
INSPECT and ADJUST. If necessary, the following items to
specrflcatlon.
0 Fuel, coolant and hydraulic tines, fittings, connectlons and
components for leaks
0 Engine 011 level
0 Power steering fluid level (of equipped)
0 Brake master cylinder fluky levels
0 Clutch master cylinder fturcl levels (If equipped)
0 Wtndshreld washer reservojr flurd level
0 Radiator coolant level and specrfic gravity
0 Tightness of water hose clamps
0 Tightness of battery terminals, electrolyte level and specific
gravity
0 Manual transaxle oil level
0 Drive belt(s) tension
Cl Carburetor lrnkage (choke control, wrde open throttle posi-
tion. etc ) (carburetor model only)
q Accelerator cable and linkage for free movement
0 Headlight cleaner and flurd level (if equipped)
BLEED air from fuel line (diesel engrne only)
CLEAN the spark plugs (except for diesel engine)
piEi6F]
INSTALL the following parts
0 Rubber stopper for rnsrde rear view mirror (if equjpped)
0 Fuse for accessories
CHECK the operation of the following items.
0 Seat controls (sliding and reclining) and head rest
0 Seat belts and warning system
Cl Ign&on switch and steering lock
0 Power window (if equipped)
D Door tacks including child proof door locks
Cl Inhibitor switch (ATX only)
Cl All Ikghts rncluding warning and Indicator lbghts
0 Ignition key reminder buzzer (If equipped)
A-Z
0 Horn, wbpers and washers (front and rear, If equipped)
0 Antenna (tf equipped)
0 Cigarette Ibghter and clock (if equipped)
0 Remote control outside mirror (if equrpped)
0 Heater, defogger and air conditioner at various mode selec-
tions (if equlppedj
0 Sunroof (If equipped)
CHECK the following items
0 Presence of spare fuse
0 Upholstery and Interior finish
CHECK and ADJUST, If necessary, the followjng items:
IJ Operation and fit of windows
0 Pedal height and free play of brake and clutch pedal
0 Parking brake UNDER BONNET-ENGINE RUNNING AT
OPERATING TEMPERATURE
CHECK the following items:
0 Operation of Idle-up system for air condbtroner or power steer-
ing (if equrpped)
0 Automatic transaxle flurd levet
0 tnltial ignrtlon timing (except disel engine)
0 Idle speed
0 Operation of throttle positron. sensor (EGI engrne)
0 Operation of cold start device and glow plug warning light
(diesel engine only)
0 Operation of dash pbt (EGI.engine)
fTiGGJ
CHECK the following items.
0 Underside fuel, coolant and hydraulic Irnes, ftttlngs, connec-
tions and components for leaks
0 Trres for cuts or brurses
0 Steering Itnkage, suspensron, exhaust system and all under-
side hardware for .looseness or damage 1 ROAD TEST j
CHECK the following items
0 8rake operation
0 Clutch operation
0 Steering control
!ZI Operation of meters and gauges
Cl Squeaks, rattles or unusual noises
Cl Engine general performance
0 Emergency locking retractors 1 AFTER ROAD TEST ]
REMOVE the seat and floor mat protective covers
CHECK for the necessary owner information materials, took
and spare tire
m vehicle
93EOAX-002
-- MAIN Char3 t: In
A: PC R: F!t T: Ti! Emis! The ed : to t!
SCHEDULED MAINTENANCE SERVICES (Europe) A
Maintenance Number of months or km (miles), whichever comes first
Months’ ’
- 6 12 18 1 24 30 36 ] 42 48
Kllometers 1,000
10,000 20,000 30,000 1 40,000 50,000 60,000 1 70,000
80,000
(Miles) (600)
(6,000) j(12,000)~(18,000)~(24,000) (30,000) (36,000)~(42,000) (48,000)
Chassis and body (Cont’d)
Steering and front suspension
I ’ I
I 1 I
MTX oil A R
Rear axle oil
I R A A R
A A A R I
Trabsfercarrier oil R A 1 A
R A A A R
Bolts, nuts on chassis and body T T 1
T , T T
Body condltlon (Visual only) Inspect annually
Exhaust system heat shields I 1 I
Tires (Including spare tjresj with inflation
pressure adjustment I
I I I
Hinges and catches A A
A 1 A
Underside of vehicle I
I i 1 I I
Seat belt I
I f
I ’ I
Dnveshafl dust boots I I 1 I I
13EOAX.304
A-5
I :
;!
i
I
I
CONVENTIONAL BRAKE SYSTEM P
CONVENTIONAL BRAKE SYSTEM
PREPARATION
SST
49 0259 770B
Wrench, fiare nut For
removal and 49 U043 OAO
Gauge set, oil
pressure For
Inspectron of
brake fluId
pressure
49 uo43 004
Gauge, oil
pressure
{Part 04
49 U043 OAO) For
inspection of
brake fluid
pressure 49 UO43 005
Joint
(Part of
49 UO43 OAO) For
inspection of
brake fluid
o pressure
49 0208 70tA
Air-out tool, boot For
removal of
piston seal 49 FAf8 602
Wrench, disc
brake piston For
removal and
installat!on of disc
call per piston
49 1258 071
Puller, bearing For 49 0221 600C
removal of caliper
a-- E;.;d tool, disc needle bearing For
installation of
brake pads
TD TECHNICAL DATA
LU8RlCATtON SYSTEM
Item
Lubricating method
011 pump Engine
BP DOHC turbo
Force-fed
6 . Trochoid gear
Relief pressure
kPa I kgf/cm’. psi] 343-441 [ 3.5-4.5, 50-64 1
Regulated pressure kPa { kgf/cm’ , psi ] -rpm
294-392 { 3.0-4.0, 43--57.1.3,000
Inner rotor tooth tip to outer. rotor Standard
0.02-0.16 (OJOOS-O.O063]
clearance
mm {in]
Maximum I
0.20 [ 0.0078 )
Outer rotor to body clearance
Side clearance
Oil fIl!er
, TYpe
Relief pressure differential . mm [in) Standard
Maximum
mm {in) Standard
Maximum 1
kPa’ f kgf/cm’, psi 1 0.09-0.18 ~0.00354.Ofl71]
0.22 { 0.0087 1
0.03-0.11 ~0.0012-0.0043~
0.14 {0.0055)
Full-flow, paper element
. 78-118 (0.8-1.2. 11-17) Srade
----l-in
Viscosity
num her
Item
Cooling metha
Water pump
, We
Impeller diame
Number of imf
Speed ratio -
Water seal !$
Thermostat
Jype. _
Opening terq
/Full-open
1 F&open lift
I
Antifreeze E
TD-4
TO TECHNICAL DATA
FUEL AND EMISSION CONTROL SYSTEMS
Item.
Idle speed
tgf-don trrmng-
Fuel pump
MaxImum output pressure
Transfer pump
Maximum output pressure
Fuel filter Engine
rPm
BTDC
kPa [ kgf/cm2, psi 1 1
kPa { kgflcm2, PSI ) 1 BP OUHC turbo
800 f 50
10 l 10
490-736 (5.0-7.5, 71-1 IO]
39 10.4, 5.7 ) or higher
I Type
Low-pressure side Nylon element (in fuel pump)
Hiah-Dressure side PaDer element
Pressure regulator
Regulating low kPa ( kgflcm2, psr 1 265-314 (2.7-3.2, 38-46 1
pressure High kPa { kgflcm2, psr 1 304-392 (3.1-4.0, 44-57 1
lniector
_ Type Low-ohmic
Type of drive
Electromechanical
Resistance q
Approx. 2.11 Q (at 20% ( 68*f )]
lniector reslstor
L - Resistance/injector
Idle-speed control (tSC) valve
TvDe n 1 6 [at 20°C 168OFjj
I Rotarv
Resistance
Solenoid valve (purge control)
Resbstance
Solenoid valve {wastegate)
Resistance n(
R I
i-l I 1 t-13 [at ZO*C {68OF j]
23-27 tat 20°C l68OFll
. r.
33-39 lat 20°C I68OF 11
Solenoid valve (PRC)
Resistance Low temp. q
33-39 [at 2O*C {SS*F]]
High temp. 0 1 33-39 [at 20°C (68OF]]
Water thermosensor
-20°C ( -4OFJ 1 14.6-17.8
Resistance kQ 2o”c I 68OF) 2.21-2.69
40°C ( tO4OF) 1.0-l 3
80°C I176OFJ 0.29-0.35
Airflow meter
Resistance R E244Vs
E2*Vc Fuity closed
Fully open I 20-600
20- 1,000
200-400
EP++THAA
(intake air
thermosensor) -2O*C ( -4OFj 1 13,600-l 8,400
20% 1 68OF) 1 2,210-2,690
6O*C 114OOFl i 493-667
EI ~Fc
I Fully closed 00
0 1
Oxygen sensor (ceramic beater coil)
Resistance
Fuel tank Approx. 6 [at 20°C f68OF)]
I CaDacW L I US oal. ImD aal I I 60 I 15.9, 13.2 I
I
Air cleaner
Element type
Fuel
Specrficatioir Oil permeated
Unteaded premium (RON 95 or higher)
l TEN terminal of diagnosis connector grounded. .
-
ENGINE ELI
3attery
I
Dark current’
Alternator
Starter
Distributor qr
Ignition timin?
ffEN terminal
Ignition coil
Spark plug
l ’ Dark current
r2 Standard pl
TD TECHNICAL DATA
Power brake unit
Diameter
km Without ABS With ABS
mm [in] 188.4 I7.42) +215.2 18.47) [ -
More than 1,080 Itl, 15611 1
I cn I tding force
1- II ,I
I
r-km pressure per lrei
KYa 1 Kgr/cm-, PSI 196 120, 441
at 0 kPa ImmHg, inHgJ
‘) -
j/N tkgf, Ibfl More than 8,730 189, I,2701
1196 (20, 44)
at 66.7 1500, 19.7)
kPa ImmHg, InHgj
Rear wheel hydraulic control system
Type Dual proportlonrng valve 1 ProportionIng valve
Switching point (Master cylinder pressure) kPa t kgflcm2, psi) 1,960 {20, 284)
WHEELS AND TIRES
Item Type Standard Temporary Spare
Size 5 l/2-JJxt5 4-Tx15
Offset mm
Wheel (in) 47.5 { 1.87 j 45 it.771
Pitch circle diameter mm (in] 114.3 {4.50)
Material
I Aluminum alloy
I Steel
Size 195150R15 82V T125/7OD15
Tire
Air kPa i kgflcm2.
pressure psi 1 Front ‘L200 12.4, 351
l 2245 12.5, 36)
Rear “216 (2.2, 321 ‘*245 12.5, 361 412 (4.2, 60)
t-lorizontai 2.0 { 0.079 1 2.5
Runout limit mm [in! L IO.098 ]
Wheel and
Vertical 1 1.5 [0.059] 2.0 (0.079 j
tire
1lnbafanr.e a lo21 t 9 to.31 1 -
*le.. Up to 3 persons
*2 . . . -Full load
SUSPENSI
Front susp
Suspensiorr
Spw tyw:
Shock abs>
Stabilizer
Front wheel
alignment
(
l Unladen;
Rear suspj
Suspension
Spring typi
Shock absc
Stabilizer
Rear whet
alignment
(‘Unladenj
l Fuet tank f
Coil Sp&
+I Main rder
l 2 Auxiliary I
TD-12
ST SPECIAL TOOLS --
BRAKIN
STEERING (CONT’D)
--
TOOL fi
h DESC
--
19 1285
Wer,
Qeedle :
--
49 8065
Harness;
--
49 cw:
Setting
retainer
--
49 804
Socke: PRIORITY / ILLUSTRATJUN TOOL NUMBER
& DEScCRIPTION TOOL NUMBER
& DESCRIPTION PRlORITY
ILLUSTRATION
A
(IlIP
A
0
A
c!iz9 49 B032 310
49 8032 320
0
Wrench
A
(Power steermg)
jq
49 F032 303
Handle
(Power steering)
Protector, pmon seal
(Power steermg)
49 B032 311
Protector,
Jipper seat
(Power steering)
49 8032 325
Guide. rod seal
BRAKING
PRIORITY
ILLUSTRATION TOOL NUMBER
b DESCRlPTlON TOOL NUMSER
& DESCRIPTION PRIORITY
ILLUSTRATION
49 8043 001
Adjust gauge
I A 49 0259 770B
Wrench, flare nut
A
49 0221 60X
Expand tool,
disc brake 49 8043 002
Installer, bearing A
TOOL
& DES
--
49 BC:
Replac
rubber
InstallE
dust 3 49 0208 701A
Atr out tool, boot 49 8043 003
Turning, lock tool A
49 FAt8 602
49 U043 OAO
I
Gauge set,
I A
oil pressure Wrench ,disc
brake piston
INSTRUMENT CLUSTER
ILLUMINATION LAMP
;REFER TO SECTION I-4
c l INSTRUMENT CLUSTER &i WARNING LAMPS 0 .F.R.GERMAI
*....ABS
COMBINATION SWITCH
(SECTION E-l. 21
ENGINE CONTROL UNIT
(SECTIIXJ
B-ICI
SECTION F-2. 3)
l-l rr
II l-l
* * w
,,“,, W/R G/ G/Y Y l-l II
II rl
WY & * 2% l-l II II l-l
R R/B
* Y/L B B/G G/W 6/B 767 G/R
B/O * * L/W V * L
1.J II iH 1G *r- fk io IC pJ ipi * Y/R * W/E R/Y
a 2% 2.3 21 w 28 n- a a x ZB 2A
K 3 34 31 3 Lx+ 3 * a x 33 3*
-02 OIL PRESSURE
SWITCH(E) C-03 BRAKE FLUID SWITCH C-04 PARKING BRAKE
(0 SWITCH(R) C-05 WASHER LEVEL SENSO C-07 WATER THERMOSENSOR
(Fg
(INJ)
pjlfzJ
ma
f
38