1992 MAZDA 323 low oil pressure

A PRE-DELIVERY INSPECTION TABLE
PRE-DELIVERY INSPECTION TABLE
[EXTERlORI
INSPECT and ADJUST, of necessary. the followlng Items to
specrfrcatron:
0 Glass, exterior bright metal and paint for damage
0 Wheel lug nuts
0 Tire pressures
0 All weatherstrips for damage or detachment
0 Operation of bonnet release and look
0 Operation of trunk Ild, hatch and fuel lbd opener
(of equipped)
0 Door operation and alignment
0 Headtrght aiming
INSTALL the foltowrng parts
0 Wheel caps or rrngs (if equipped)
0 Outsrde mirror(s)
1 UNDER BONNET-ENGINE OFF j
INSPECT and ADJUST. If necessary, the following items to
specrflcatlon.
0 Fuel, coolant and hydraulic tines, fittings, connectlons and
components for leaks
0 Engine 011 level
0 Power steering fluid level (of equipped)
0 Brake master cylinder fluky levels
0 Clutch master cylinder fturcl levels (If equipped)
0 Wtndshreld washer reservojr flurd level
0 Radiator coolant level and specrfic gravity
0 Tightness of water hose clamps
0 Tightness of battery terminals, electrolyte level and specific
gravity
0 Manual transaxle oil level
0 Drive belt(s) tension
Cl Carburetor lrnkage (choke control, wrde open throttle posi-
tion. etc ) (carburetor model only)
q Accelerator cable and linkage for free movement
0 Headlight cleaner and flurd level (if equipped)
BLEED air from fuel line (diesel engrne only)
CLEAN the spark plugs (except for diesel engine)
piEi6F]
INSTALL the following parts
0 Rubber stopper for rnsrde rear view mirror (if equjpped)
0 Fuse for accessories
CHECK the operation of the following items.
0 Seat controls (sliding and reclining) and head rest
0 Seat belts and warning system
Cl Ign&on switch and steering lock
0 Power window (if equipped)
D Door tacks including child proof door locks
Cl Inhibitor switch (ATX only)
Cl All Ikghts rncluding warning and Indicator lbghts
0 Ignition key reminder buzzer (If equipped)
A-Z
0 Horn, wbpers and washers (front and rear, If equipped)
0 Antenna (tf equipped)
0 Cigarette Ibghter and clock (if equipped)
0 Remote control outside mirror (if equrpped)
0 Heater, defogger and air conditioner at various mode selec-
tions (if equlppedj
0 Sunroof (If equipped)
CHECK the following items
0 Presence of spare fuse
0 Upholstery and Interior finish
CHECK and ADJUST, If necessary, the followjng items:
IJ Operation and fit of windows
0 Pedal height and free play of brake and clutch pedal
0 Parking brake UNDER BONNET-ENGINE RUNNING AT
OPERATING TEMPERATURE
CHECK the following items:
0 Operation of Idle-up system for air condbtroner or power steer-
ing (if equrpped)
0 Automatic transaxle flurd levet
0 tnltial ignrtlon timing (except disel engine)
0 Idle speed
0 Operation of throttle positron. sensor (EGI engrne)
0 Operation of cold start device and glow plug warning light
(diesel engine only)
0 Operation of dash pbt (EGI.engine)
fTiGGJ
CHECK the following items.
0 Underside fuel, coolant and hydraulic Irnes, ftttlngs, connec-
tions and components for leaks
0 Trres for cuts or brurses
0 Steering Itnkage, suspensron, exhaust system and all under-
side hardware for .looseness or damage 1 ROAD TEST j
CHECK the following items
0 8rake operation
0 Clutch operation
0 Steering control
!ZI Operation of meters and gauges
Cl Squeaks, rattles or unusual noises
Cl Engine general performance
0 Emergency locking retractors 1 AFTER ROAD TEST ]
REMOVE the seat and floor mat protective covers
CHECK for the necessary owner information materials, took
and spare tire
m vehicle
93EOAX-002
-- MAIN Char3 t: In
A: PC R: F!t T: Ti! Emis! The ed : to t!

TD TECHNICAL DATA
LU8RlCATtON SYSTEM
Item
Lubricating method
011 pump Engine
BP DOHC turbo
Force-fed
6 . Trochoid gear
Relief pressure
kPa I kgf/cm’. psi] 343-441 [ 3.5-4.5, 50-64 1
Regulated pressure kPa { kgf/cm’ , psi ] -rpm
294-392 { 3.0-4.0, 43--57.1.3,000
Inner rotor tooth tip to outer. rotor Standard
0.02-0.16 (OJOOS-O.O063]
clearance
mm {in]
Maximum I
0.20 [ 0.0078 )
Outer rotor to body clearance
Side clearance
Oil fIl!er
, TYpe
Relief pressure differential . mm [in) Standard
Maximum
mm {in) Standard
Maximum 1
kPa’ f kgf/cm’, psi 1 0.09-0.18 ~0.00354.Ofl71]
0.22 { 0.0087 1
0.03-0.11 ~0.0012-0.0043~
0.14 {0.0055)
Full-flow, paper element
. 78-118 (0.8-1.2. 11-17) Srade
----l-in
Viscosity
num her
Item
Cooling metha
Water pump
, We
Impeller diame
Number of imf
Speed ratio -
Water seal !$
Thermostat
Jype. _
Opening terq
/Full-open
1 F&open lift
I
Antifreeze E
TD-4

TO TECHNICAL DATA
FUEL AND EMISSION CONTROL SYSTEMS
Item.
Idle speed
tgf-don trrmng-
Fuel pump
MaxImum output pressure
Transfer pump
Maximum output pressure
Fuel filter Engine
rPm
BTDC
kPa [ kgf/cm2, psi 1 1
kPa { kgflcm2, PSI ) 1 BP OUHC turbo
800 f 50
10 l 10
490-736 (5.0-7.5, 71-1 IO]
39 10.4, 5.7 ) or higher
I Type
Low-pressure side Nylon element (in fuel pump)
Hiah-Dressure side PaDer element
Pressure regulator
Regulating low kPa ( kgflcm2, psr 1 265-314 (2.7-3.2, 38-46 1
pressure High kPa { kgflcm2, psr 1 304-392 (3.1-4.0, 44-57 1
lniector
_ Type Low-ohmic
Type of drive
Electromechanical
Resistance q
Approx. 2.11 Q (at 20% ( 68*f )]
lniector reslstor
L - Resistance/injector
Idle-speed control (tSC) valve
TvDe n 1 6 [at 20°C 168OFjj
I Rotarv
Resistance
Solenoid valve (purge control)
Resbstance
Solenoid valve {wastegate)
Resistance n(
R I
i-l I 1 t-13 [at ZO*C {68OF j]
23-27 tat 20°C l68OFll
. r.
33-39 lat 20°C I68OF 11
Solenoid valve (PRC)
Resistance Low temp. q
33-39 [at 2O*C {SS*F]]
High temp. 0 1 33-39 [at 20°C (68OF]]
Water thermosensor
-20°C ( -4OFJ 1 14.6-17.8
Resistance kQ 2o”c I 68OF) 2.21-2.69
40°C ( tO4OF) 1.0-l 3
80°C I176OFJ 0.29-0.35
Airflow meter
Resistance R E244Vs
E2*Vc Fuity closed
Fully open I 20-600
20- 1,000
200-400
EP++THAA
(intake air
thermosensor) -2O*C ( -4OFj 1 13,600-l 8,400
20% 1 68OF) 1 2,210-2,690
6O*C 114OOFl i 493-667
EI ~Fc
I Fully closed 00
0 1
Oxygen sensor (ceramic beater coil)
Resistance
Fuel tank Approx. 6 [at 20°C f68OF)]
I CaDacW L I US oal. ImD aal I I 60 I 15.9, 13.2 I
I
Air cleaner
Element type
Fuel
Specrficatioir Oil permeated
Unteaded premium (RON 95 or higher)
l TEN terminal of diagnosis connector grounded. .
-
ENGINE ELI
3attery
I
Dark current’
Alternator
Starter
Distributor qr
Ignition timin?
ffEN terminal
Ignition coil
Spark plug
l ’ Dark current
r2 Standard pl

PARTS INDEX
PARTS NAME PAGE
PARTS NAME PAGE
I KNOCK CONTROL UNIT...................30
KNOCK SENSOR.........................30 .82
.82
.82
.82
.82
.32
.26
.72
a LICENSE PLATE LIGHT...............48.5 0
B MAIN RELAY(FUEL INJ)
............... ..2 8
1 NEUTRAL SWITCH.......................3 2
$3 OIL PRESSURE SWITCH..................3 8
OXYGEN SENSOR........................2 8
J PANEL LIGHT CONTROL..................7 0
PARKING BRAKE SWITCH.................3 8
POSITION LIGHT....................44,5 0
POWER DDOR LOCK SWITCH...............7 6
POWER DDOR LOCK TIMER UNIT...........7 6
POWER DOOR LOCK ACTUATOR.............7 6
POWER OUTSIDE MIRROR MOTOR...........7 0
POWER OUTSIDE MIRROR SWITCH..........7 8
POWER STEERING PRESSURE SWITCH.......3 2
POWER WINDOW MAIN SWITCH.............7 4
POWER WINDOW MOTOR...................7 4
e
1 BACK-UP LIGHT SWITCH.................60
BACK-UP LIGHT....
BLOWER MOTOR.....:::::::::::::::::::’
.E
BLOWER SWITCH........................62
BRAKE FLUID SWITCH...................38
POWER WINDOW SWITCH..................74
J D REAR FOG LIGHT RELAY.
REAR FOG LIGHT SWITCH
REAR FOG LIGHT.......
REAR SPEAKER......... ................
................ zz
................
52
................
................ E
................ 42
............... .
..: 2
.Riik+‘::::::::..6 4
SWITCH.........6 4
................
................ :z
................ 62
............. 44, 48
I CIGARETTE LIGHTER..
CIRCUIT OPENING REL
CLUTCH SWITCH...
COMBINATION SWITCH:
CONDENSER.......
COOLING FAN MOTOR::
COOLING FAN RELAY..
COURTESY LAMP.....,
CPU................ . .64
/ii’::::::::::::::..2 8
..................
... 44, 46, 48, 50, 52, %
..................
.................. 2:
..................
.................. 2:
............... 42, 66
B DIAGNOSIS CONNECTOR.....
DIGITAL CLOCK...........
n-rnnc ............
............ E
............
............ %
............
............ ZE
TURN LIGHT....
WASHER MOTOR.. REAR
REAR
REAR
REAR
REAR
REAR
REAR
REAR
-ih .ER
-ER
RESISTOR ASSEMBLY..
RUNNING LIGHT RELAY
il SEAT WARMER...........
SEAT WARMER REALY.....
SEAT WARMER SWITCH....
SHORT CONNECTOR.......
SLIDING SUNROOF MOTOR.
SLIDING SUNROOF RELAY.
SLIDING SUNROOF SWITCH
SLIDING SUNROOF.......
SOLENOID RESISTOR.....
SOLENOID VALVES
PRC HIGH TEMP........
PRC LOW TEMP.........
PURGE CONTROL........
WASTEGATE............
SPEED SENSOR..........
SPOT LAMP.............
STARTER...............
STOPLIGHT CHECKER..... ........
........
........
........
........
........
........
........
........ ....... 84
.......
....... ::
.......
.... 66.2
.......
.... 66, Ei
.......
....... ........
........
........
........
........
........
........
........
........
........
.
. . . . . . z:
. . .
. . . . zoo
. 1 .
. . . . E
. . . .
56, ::
. . 56, 58
. . 56, 58
“J.“LJL................. DISTRIBUTOR ............
DOOR SPEAKER ........... .
DOOR SWITCH........: .... 8
3 ENGINE CONTROL UNIT............ ,28, 30. 32
3 FLASHER UNIT...
FRONT FOG LIGHT
FRONT FOG LIGHT
FRONT FOG LIGHT
FRONT SIDE TURN
FRONT TURN LIGH
FUEL METER.....
FUEL PUMP REALY
FUEL PUMP UNIT.
FUEL PUMP......
-. -- ............
............ 22 .
. . RiiA‘i 1
SWITCH
i&ii 1 ............ 52
............ .
............ 22
.....................
..................... %
.....................
..................... %
..................... 28 -
tust ....................
B
G SENSOR ................
13 HAZARD SWITCH............
HEADLIGHT CLEANER MOTOR..
HEADLIGHT CLEANER SWITCH.
HEADLIGHT LEVELING ACTUAT
HEADLIGHT LEVELING SWITCH
HEADLIGHT RELAY..........
ENI- IGHT. . . . . .
HORN RELAY...............
HORN SWITCH.............. ...
40, 46, 52, 64
: ........... 82
............ 54
........... .
..: ii
&::::::::..4 6
HORN..................I 1
HYDRAULIC UNIT ..........
01 IC REGURATOR ............
IG KEY CYLINDER LAMP ....
IGNITER .................
IGNITION COIL ...........
ILLUMINATION LAMP .......
AUDIO SYSTEM ...........
BLOWER SWITCH .......... ............
46
............ 44
......... 44, 46
............
............ E
............
............ E
...........
........... 2:
...........
........... 2
...........
........... 5:
...........
........... 5:
...........
........... 5::
...........
........... 5:
..........
.%
;ci:::::::.;;
........... CIGARETTE LIGHTER: ;.I:;::
FRONT FOG LIGHT SWITCH...
HAZARD SWITCH...........
HEADLIGHT CLEANER SWITCH:
HEADLIGHT LEVELING SWITCH
INSTRUMENT CLUSTER.......
REAR FOG LIGHT SWITCH....
REAR WINDOW DEFROSTER SW1
SEAT WARMER SWITCH.......
INDICATOR LAMP...........
...........
........... 33:: ...........
30 STOPLIGHT SWITCH ......
STOPLIGHT .............
0 TAChOMETER...........................3 8
TAILLIGHT.........................48,5 0
TEMP METER...........................3 8
THROTTLE SENSOR......................3 2
TRANSFER PUMP........................2 8
TRUNK COMPARTMENT LAMP SWITCH........6 8
TRUNK COMPARTMENT LAMP...............6 8
TURN SWITCH..........................5 4
q WARNING LAMP.........................3 8
WASHER LEVEL SENSOR..................3 8
WATER THERMOSENSOR................30,3 8
WATER THERMOSWITCH................... 6
WINDSHIELD WASHER MOTOR..............4 0
WINDSHIELD WASHER SWITCH.............4 0
WINDSHIELD WIPER MOTOR...............4 0
WINDSHIELD WIPER SWITCH..............4 0 INJECTOR..........:;.:::::
INJECTOR RESISTOR .........
INSTRUMENT CLUSTER .....
INTERIOR LAMP..........:::
ISC VALVE .................
. . . . . , . . . . .
. . . . . . . . . . . iz:
,..........
30