1991 MITSUBISHI MONTERO spark plugs
[x] Cancel search: spark plugsPage 723 of 1333
![MITSUBISHI MONTERO 1991 Service Manual Manual Transmission Oil & Transfer Case
\b\
\
\
\
\
\](/manual-img/19/57332/w960_57332-722.png "MITSUBISHI MONTERO 1991 Service Manual Manual Transmission Oil & Transfer Case
\b\
\
\
\
\
\")
Manual Transmission Oil & Transfer Case
\b\
\
\
\
\
\
\
Carburetor Choke Mechanism & Linkage (2.6L Engine)
\b\
\
\
\
\
\
\
Crankcase Emission Control System (PCV Valve)
\b\
\
\
\
\
\
\
Evaporative Emission Control System
\b\
\
\
\
\
\
\
Distributor Cap, Rotor & Spark Advanced System
\b\
\
\
\
\
\
\
Intake Temperature Control System
\b\
\
\
\
\
\
\
Secondary Air System
\b\
\
\
\
\
\
\
Front Disc Pads
\b\
\
\
\
\
\
\
Rear Drum Brake Linings & Wheel & Cylinders
\b\
\
\
\
\
\
\
Brake Hoses
\b\
\
\
\
\
\
\
Steering Linkage Seals & Drive Shaft Boots
\b\
\
\
\
\
\
\
Lubricate Ball Joints
\b\
\
\
\
\
\
\
Lubricate Front Wheel Bearing
\b\
\
\
\
\
\
\
Drive Axle Fluid (Without Limited-Slip Differential)
\b\
\
\
\
\
\
\
Lubricate Drive Shaft Joints
\b\
\
\
\
\
\
\
Exhaust System
\b\
\
\
\
\
\
\
Drive Belt (Water Pump & Alternator)
\b\
\
\
\
\
\
\
Vacuum, Water, Crankcase Ventilation & Secondary Air Hoses
\
\
\
\
\
\
\
Replace
\
\
\
\
\
\
\
Air Filter
\b\
\
\
\
\
\
\
Fuel Filter
\b\
\
\
\
\
\
\
Spark Plugs
\b\
\
\
\
\
\
\
Ignition Cables
\b\
\
\
\
\
\
\
Camshaft Timing Belt
\b\
\
\
\
\
\
\
Engine Coolant
\b\
\
\
\
\
\
\
Drive Axle Fluid (With Limited-Slip Differential)
\b\
\
\
\
\
\
\
Engine Oil & Filter
\b\
\
\
\
\
\
\
Automatic Transmission & Transfer Case Fluids
\b\
\
\
\
\
\
\
Vacuum Control System Solenoid Valve Air Filter
\
\
\
\
\
\
\
Lubrication Specifications
\
\
\
\
\
\
\
Application Specification
Brake & Clutch Fluid ............................ DOT 3 Or DOT 4
Page 736 of 1333
![MITSUBISHI MONTERO 1991 Service Manual Power Steering (Dexron-II)
Colt, Colt Vista, Colt 200, Mirage & Summit ...... 1.9 Qts. (.9L)\
Eclipse & Galant .................................. 1.9 Qts. (.9L)\
Montero ................](/manual-img/19/57332/w960_57332-735.png "MITSUBISHI MONTERO 1991 Service Manual Power Steering (Dexron-II)
Colt, Colt Vista, Colt 200, Mirage & Summit ...... 1.9 Qts. (.9L)\
Eclipse & Galant .................................. 1.9 Qts. (.9L)\
Montero ................")
Power Steering (Dexron-II)
Colt, Colt Vista, Colt 200, Mirage & Summit ...... 1.9 Qts. (.9L)\
Eclipse & Galant .................................. 1.9 Qts. (.9L)\
Montero .......................................... 2.2 Pts. (1.0L)\
Pickup & Ram-50 ................................... 1.9 Qts. (.9L)\
Stealth & 3000GT
2-Wheel Steering ................................ 1.9 Pts. (.9L)\
4-Wheel Steering ............................... 2.5 Pts. (1.2L)\
Transfer Case (SAE 75W-85/API GL-4)
Colt Vista ........................................ 1.5 Pts. (.7L)\
Eclipse & Galant .................................. 1.3 Pts. (.6L)\
Montero, Pickup & Ram-50 ......................... 4.7 Pts. (2.2L)\
Stealth ............................................. .3 Pt. (.2L)\
3000GT .............................................. .6 Pt. (.3L)\
(1) - Add 1.0 Pt. (.5L) with oil cooler.
\
\
\
\
\
\
\
QUICK-SERVICE
SERVICE INTERVALS & SPECIFICATIONS
REPLACEMENT INTERVALS \
\
\
\
Component Miles
Colt, Colt 200, Mirage & Summit
Air Filter ....................... 30,000
Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Fuel & Vapor Hoses ............... 50,000
Oil ................................ 7500
Oil Filter ....................... 15,000
Spark Plugs ...................... 30,000
Timing Belt ...................... 60,000
Colt Vista
Air Filter ....................... 30,000
Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
EGR Valve ( 1) .................... 50,000
Fuel & Vapor Hoses ............... 50,000
Oil ................................ 7500
Oil Filter ....................... 15,000
O2 Sensor ( 1) .................... 80,000
Rear Axle Fluid .................. 30,000
Spark Plugs ...................... 30,000
Spark Plug Wires ( 1) ............. 60,000
Timing Belt ...................... 60,000
Vapor Canister ( 1) .............. 100,000
Mirage
Air Filter ....................... 30,000
Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Fuel & Vapor Hoses ............... 50,000
Oil ................................ 7500
Filter ........................... 15,000
Spark Plugs ...................... 30,000
Timing Belt ...................... 60,000
Eclipse
Page 737 of 1333
Air Filter ....................... 30,000
Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Fuel & Vapor Hoses ............... 50,000
Oil
Non-Turbo ........................ 7500
Turbo ............................ 5000
Oil Filter
Non-Turbo ...................... 15,000
Turbo .......................... 10,000
Spark Plugs ...................... 30,000
Timing Belt ...................... 60,000
Galant
Air Filter ....................... 30,000
Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Fuel & Vapor Hoses ............... 50,000
Oil
Non-Turbo ........................ 7500
Turbo ............................ 5000
Oil Filter
Non-Turbo ...................... 15,000
Turbo .......................... 10,000
Rear Axle Fluid .................. 30,000
Spark Plugs ...................... 30,000
Timing & Balance Shaft Belts ..... 60,000
Montero
Air Filter ....................... 30,000
Automatic Transmission Fluid ..... 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Front & Rear Axle Fluid .......... 30,000
Fuel Filter ...................... 50,000
Fuel & Vapor Hoses ............... 50,000
Oil ................................ 7500
Oil Filter ....................... 15,000
O2 Sensor (2) .................... 80,000
Spark Plugs ...................... 30,000
Spark Plug Wires ( 2) ............. 60,000
Timing Belt ...................... 60,000
Transfer Case Fluid .............. 30,000
Vapor Canister ( 2) .............. 100,000
Pickup & Ram-50
Air Filter ....................... 30,000
Automatic Transmission Fluid ..... 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
EGR Valve (2.4L) ( 2) ............. 50,000
Front & Rear Axle Fluid .......... 30,000
Fuel Filter ...................... 50,000
Fuel & Vapor Hoses ............... 50,000
Oil ................................ 7500
Oil Filter ....................... 15,000
O2 Sensor ( 2) .................... 80,000
Spark Plugs ...................... 30,000
Spark Plug Wires ( 2) ............. 60,000
Timing Belt ...................... 60,000
Transfer Case Fluid .............. 30,000
Vapor Canister ( 2) .............. 100,000
Stealth
Air Filter ....................... 30,000
Page 738 of 1333
Automatic Transaxle Fluid ........ 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Front & Rear Axle Fluid .......... 30,000
Fuel & Vapor Hoses ............... 50,000
Oil
Non-Turbo ........................ 7500
Turbo ............................ 5000
Oil Filter
Non-Turbo ...................... 15,000
Turbo .......................... 10,000
Spark Plugs ...................... 60,000
Timing Belt ...................... 60,000
3000GT
Air Filter ....................... 30,000
Belts ............................ 30,000
Coolant .......................... 30,000
Fuel & Vapor Hoses ............... 50,000
Front & Rear Axle Fluid .......... 30,000
Oil
Non-Turbo ........................ 7500
Turbo ............................ 5000
Oil Filter
Non-Turbo ...................... 15,000
Turbo .......................... 10,000
Spark Plugs ...................... 60,000
Timing Belt ...................... 60,000
(1) - Federal 4WD models only.
( 2) - Federal models only.
\
\
\
\
BELT ADJUSTMENT \
\
\
\
\
\
\
Deflection
Application ( 1) In. (mm)
Colt, Colt 200, Mirage & Summit
1.5L ...................................... .28-.35 (7.1-8.9)
1.6L ..................................... .35-.45 (8.9-11.4)
Colt Vista
2.0L ..................................... .28-.40 (7.1-10.2)
Eclipse
1.8L ..................................... .32-.43 (8.1-11.1)
2.0L ..................................... .35-.45 (8.9-11.4)
Galant
Alternator Belt .......................... .35-.45 (8.9-11.4)
A/C Belt .......................................... .32 (8.1)
Power Steering Belt ....................... .24-.35 (6.1-8.9)
Montero
3.0L ...................................... .20-.24 (5.1-6.1)
Pickup & Ram-50
2.4L ...................................... .27-.39 (6.8-9.9)
3.0L ...................................... .32-.39 (8.1-9.9)
Stealth & 3000GT
SOHC
Alternator & Power Steering Belt ........ .24-.35 (6.1-8.9)
A/C Belt ................................ .28-.37 (7.1-9.5)
DOHC
Alternator Belt (With or Without A/C) ... .16-.22 (4.1-5.6)
Power Steering Belt .................... .35-.43 (8.9-11.1)
( 1) - With 22 lbs. (10 kg) pressure applied midway on belt run.
Page 739 of 1333
![MITSUBISHI MONTERO 1991 Service Manual \
\
\
\
\
\
\
MECHANICAL CHECKS
ENGINE COMPRESSION](/manual-img/19/57332/w960_57332-738.png "MITSUBISHI MONTERO 1991 Service Manual \
\
\
\
\
\
\
MECHANICAL CHECKS
ENGINE COMPRESSION")
\
\
\
\
\
\
\
MECHANICAL CHECKS
ENGINE COMPRESSION
Check engine compression with engine at normal operating
temperature at specified cranking speed, all spark plugs removed and
throttle wide open.
COMPRESSION SPECIFICATIONS
\
\
\
\
Application (1) Specification
Compression Ratio
1.5L (VIN A) ...................... 9.4:1
1.6L (VIN Y) ...................... 9.2:1
1.8L (VIN T) ...................... 9.0:1
2.0L (VIN R) ...................... 9.0:1
2.0L (VIN U) ...................... 9.0:1
2.0L (VIN V) ...................... 8.5:1
2.4L (VIN W) ...................... 8.5:1
3.0L (VIN B) ..................... 10.0:1
3.0L (VIN C) ...................... 8.0:1
3.0L (VIN S) ...................... 8.9:1
Compression Pressure ( 2)
1.5L (VIN A) ....... 137 psi (9.6 kg/cm
)
1.6L (VIN Y) ...... 171 psi (12.0 kg/cm)
1.8L (VIN T) ....... 131 psi (9.2 kg/cm)
2.0L (VIN R) ....... 137 psi (9.6 kg/cm)
2.0L (VIN U) ....... 114 psi (8.0 kg/cm)
2.0L (VIN V) ....... 119 psi (8.4 kg/cm)
2.4L (VIN W) ....... 119 psi (8.4 kg/cm)
3.0L (VIN B) ....... 139 psi (9.8 kg/cm)
3.0L (VIN C) ....... 115 psi (8.1 kg/cm)
3.0L (VIN S) ....... 119 psi (8.4 kg/cm)
( 1) - See A - ENGINE/VIN ID article in the
ENGINE PERFORMANCE Section for VIN
information.
( 2) - Maximum variation between cylinders is
14 psi (1.0 kg/cm
) \
\
\
\
VALVE CLEARANCE
NOTE: Valve adjustment is required on 1.5L engines only. Check
adjustment at 15,000 mile intervals.
VALVE CLEARANCE SPECIFICATIONS - 1.5L
\
\
\
\
Application ( 1) In. (mm)
Hot Engine
Intake ....................... .006 (.15)
Exhaust ...................... .010 (.25)
Cold Engine
Intake ....................... .003 (.07)
Exhaust ...................... .007 (.17)
( 1) - Adjust valves with engine hot.
\
\
\
\
Page 741 of 1333
No. 3 Wire ....................... 12,000
No. 4 Wire ....................... 14,000
3.0L (VIN B & C)
Coil Wire ...................... Not Used
No. 1 Wire ......................... 8600
No. 2 Wire ....................... 13,900
No. 3 Wire ......................... 6400
No. 4 Wire ....................... 11,500
No. 5 Wire ......................... 4500
3.0L (VIN S)
Coil Wire .......................... 3000
No. 1 Wire ......................... 9000
No. 2 Wire ......................... 8500
No. 3 Wire ....................... 10,000
No. 4 Wire ......................... 9000
No. 5 Wire ....................... 12,000
No. 6 Wire ....................... 10,000
No. 6 Wire ....................... 11,700
(1) - See A - ENGINE/VIN ID article in the
ENGINE PERFORMANCE Section for VIN
information.
( 2) - Information not available from mfg.
\
\
\
\
SPARK PLUGS
SPARK PLUG TYPE \
\
\
\
Application Nippondenso No.
1.5L (VIN A) .................... W20EPR-11
1.6L (VIN Y) .................... W20EPR-11
1.8L (VIN T) .................... W20EPR-11
2.0L (VIN R) ....................... W20EPR
2.0L (VIN U & V) ................ W20EPR-11
2.4L (VIN W) .................... W20EPR-11
3.0L (VIN B & C) ............... PK20PR-P11
3.0L (VIN S) .................... W16EPR-11
\
\
\
\
SPARK PLUG SPECIFICATIONS \
\
\
\
\
\
\
Gap Torque
Application In. (mm) Ft. Lbs. (N.m\
)
2.0L (VIN R & U) ....... .028-.031 (.7-.8) ......... 15-21 (20-\
30)
All Others ............ .039-.043 (1.0-1.1) ........ 15-21 (20-30\
)
\
\
\
\
\
\
\
FIRING ORDER & TIMING MARKS
WARNING: On the 3.0L V6, the firing order and the spark plug
connection order on the top of the distributor do not match.
Circuits internal to the distributor cap differ from the
external spark plug wire connections. This is intentional and
is done to avoid spark plug wires crossover. See Fig. 3.
Page 1146 of 1333
motor to increase idle speed. To prevent A/C compressor from switching
on before idle speed has increased, ECU momentarily opens A/C relay
circuit.
Idle Speed Control (ISC) Motor
Controls pintle-type air valve (DOHC engines) or throttle
plate angle (SOHC engines) to regulate volume of intake air at idle.
During start mode, ECU controls idle intake air volume
according to coolant temperature input. After starting, with idle
position switch activated (throttle closed), fast idle speed is
controlled by ISC motor and fast idle air control valve (if equipped).\
When idle switch is deactivated (throttle open), ISC motor
moves to a preset position in accordance with coolant temperature
input.
When automatic transmission (if equipped) is shifted from
Neutral to Drive, A/C is turned on or power steering pressure reaches
a preset value, ECU signals ISC motor to increase engine RPM.
Fast Idle Air Control Valve
Some models use a coolant temperature-sensitive fast idle air
control valve, located on throttle body, to admit additional intake
air volume during engine warm-up. Control valve closes as temperature
increases, restricting by-pass airflow rate. At engine warm-up, valve
closes completely.
IGNITION SYSTEMS
DIRECT IGNITION SYSTEM (DIS) - DOHC ENGINES
Ignition system is a 2-coil, distributorless ignition system.
Crankshaft angle and TDC sensor assembly, mounted in place of
distributor, are optically controlled.
Power Transistors & Ignition Coils
Based on crankshaft angle and TDC sensor inputs, ECU controls
timing and directly activates each power transistor to fire coils.
Power transistor "A" controls primary current of ignition coil "A" to
fire spark plugs on cylinders No. 1 and 4 at the same time. Power
transistor "B" controls primary current of ignition coil "B" to fire
spark plugs on cylinders No. 2 and 3 at the same time.
Although each coil fires 2 plugs at the same time, ignition
takes place in only one cylinder since the other cylinder is on its
exhaust stroke when plug fires.
ELECTRONIC IGNITION SYSTEM - SOHC ENGINES
Mitsubishi breakerless electronic ignition system uses a disc
and optical sensing unit to trigger power transistor.
Power Transistor & Ignition Coil
Power transistor is mounted inside distributor with disc and
optical sensing unit. When ignition is on, ignition coil primary
circuit is energized. As distributor shaft rotates, disc rotates,
triggering optical sensing unit. ECU receives signals from optical
sensing unit. Signals are converted and sent to power transistor,
interrupting primary current flow and inducing secondary voltage.
IGNITION TIMING CONTROL SYSTEM
Ignition timing is controlled by ECU. ECU adjusts timing
based upon various conditions, such as engine temperature, altitude
and detonation (turbo vehicles only).
Page 1205 of 1333
Incorrect ignition timing Reset ignition timing,
See TUNE-UP
Leaking valves Replace valves, See
ENGINES
Worn fuel pump diaphragm Replace diaphragm or
or piston piston
\
\
\
\
\
\
\
Intake Backfire Improper ignition timing Reset ignition timing,
See TUNE-UP
Faulty accelerator pump Replace accelerator
discharge pump
Improper choke operation Check choke and adjust
as required
Defective EGR valve Replace EGR valve
Fuel mixture too lean Reset air/fuel mixture,
See TUNE-UP
Choke valve initial Reset choke valve
clearance too large initial clearance
\
\
\
\
\
\
\
Exhaust Backfire Vacuum leak Inspect and repair
vacuum system
Faulty vacuum diverter Replace vacuum diverter
valve valve
Faulty choke operation Check choke and adjust
as required
Exhaust system leak repair exhaust system
leak
\
\
\
\
\
\
\
Engine Ignition timing too far Reset ignition timing,
Detonation advanced See TUNE-UP
Faulty ignition system Check ignition timing,
See TUNE-UP
Spark plugs loose or Retighten or replace
faulty plugs
Fuel delivery system Inspect lines, pump and
clogged filter for clog
EGR valve inoperative Replace EGR valve
PCV system inoperative Inspect and/or replace
hoses or valve
Vacuum leaks Check vacuum system and
repair leaks
Excessive combustion
chamber deposits Remove built-up
deposits
Leaking, sticking or Inspect and/or replace
broken valves valves
\
\
\
\
\
\
\
External Oil Fuel pump improperly seated Remove pump, replace
Leakage or worn gasket gasket and seat
properly
Oil pan gasket broken or Straighten pan and
pan bent replace gasket
Timing chain cover gasket Replace timing chain
broken cover gasket
Rear main oil seal worn Replace rear main oil
seal
Oil pan drain plug not Remove and reinstall
seated properly drain plug
Camshaft bearing drain Remove restriction
hole blocked
Oil pressure sending Remove and reinstall
switch leaking sending switch
\
\
\
\
\
\
\