1991 MITSUBISHI 3000GT Service Manual

BODY - Drir, Line Weatherstrir,42-65
DRIP LINE WEATHERSTRIPM42MFALREMOVAL AND INSTALLATION
/
L
iRemoval steps
Delta cover inner
Delta cover outer P.42-42.51.)
1(Refer to
Door trim (Refer to P.4241.)
1. Door belt line outer weatherstrip
*I) I)+2. Door outer opening weatherstrip
3. Door inner opening weatherstrip front
4. Door inner opening weatherstrip rear
5. Door opening weatherstrip lower
Drip line weatherstrip removal steps
6. Drip line weatherstrip
7. Door weatherstrip holder
2-18FO219
SERVICE POINT OF REMOVAL
2. REMOVAL OF DOOR OUTER OPENING WEATHER-
STRIP
Make a tool as shown in the illustration to remove the door
opening weatherstrip.
SERVICE POINT OF INSTALLATION
2.INSTALLATION OF DOOR OUTER OPENING WEATHER-
STRIP
The clip color identifies the left and right weatherstrips, so
be sure to use the coiors so as to install correctly.
IIdentification colorIApplicable sideIWhiteLeft door
TSB RevisionOrange,Right door

EXTERIORCONTENTS
MSIAA- -AERO PARTS
........................................................20
SERVICE ADJUSTMENT PROCEDURES........
10DOOR MIRROR
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38Inspection of Active Aero System. . . . . . . . . . . . . . . .10FRONT BUMPER
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..__...............11SPECIAL TOOLS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..__............_._...4
GARNISHES
AND MOULDINGS . ..__............... 16
REAR BUMPER
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .14SPECIFICATIONS
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .._...............2General Specifications
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .2Sealants and Adhesives
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3REAR WIPER AND WASHER
. . . . . . . . . . . . . . . . . . . . . . . . . . . .35Service Specifications. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3TROUBLESHOOTING
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5WINDSHIELD WIPER AND WASHER
. . . . . . . . . . . .24

51-2
SPECIFICATIONSEXTERIOR
- Specifications
GENERAL SPECIFICATIONSMSlKB-
-\ IItems
Windshield wiper motorType
Speed control system
Braking system
rpm at load of 1 Nm (0.72
ft.lbs.)Low speed
High speed
Nominal torque
Nm (ft.lbs.)
Rear wiper motor
Motor type
Braking system
rpm at load of 0.6 Nm (0.43
ft.lbs.)Windshield wiper blade
Wiping angle
Driver’s side
Passenger’s side
Wiper blade length
mm (in.)
Driver’s side
Passenger’s side
Tear wiper blade
Wiping angle
Wiper blade lengthmm (in.)
Nindow washer motor and pump
Motor type
Pump type
Power consumption A
Time of continuous usesec.
With washer fluid
Empty operation
Nozzle jet pressure
kPa (psi)
Tank capacity
lit.
(qts.)
3ear window washer motor and pump
Motor type
Pump type
Power consumption A
Time of continuous use
sec.With washer fluid
Empty operation
Nozzle jet pressure
kPa (psi)
Tank capacity
lit. (qts.)Specifications
Ferrite-magnet type
Third brush system
Dynamic brake system
48
_+ 4
70
2 724(17)
Ferrite-magnet type
Dynamic braking system
38
+ 5
89”
91”
525 (20.7)
500 (19.7)87”
k 1.5”
550 (21.7)Direct current ferrite magnet type
Centrifugal type
3.8 or less
Max. 60
Max. 20
120 (17) or more
2.0
(2.1) or more
Direct current ferrite magnet type
Centrifugal type
3.8 or less
Max. 60
Max. 20
120 (17) or more
1.2 (1.3) or more
LJ
L/iTSB Revision

/
L
,
LJEXTERIOR
- SDecifications-a- - -~------~----ItemsSpecifications
Wiper and washer switch
Rated load A
Wiper switch
LO, HI4
INT0.22 f 0.05
Washer switchMax. 4
Voltage drop (at
12V and the rated load)VWiper switch0.2 or less
Washer switch0.5 or less
Rear wiper and washer switch
Rated load A
Wiper switch
5Washer switch
5Voltage drop V0.1 or less
Intermittent wiper relay

Intermittent interval (min.-max.)sec.
Variable-interval intermittent wiperApprox. 3
- 12
Delay time in washer movingsec.
0.6
Intermittent intervalsec.
8+2Door mirror
Printed heater lines
Working voltage V
IO-15Operating current A3.5 or less
Resistance
s17.7 - 10.2SERVICE SPECIFICATIONSMBlKC-
-ItemsSpecifications
Standard value
Front wiper blade park position
(A)mm (in.)15 ‘-; (.6 +_$ISEALANTS AND ADHESIVES
itemsSpecified adhesive
I
3M ATD Part No. 8609 SUPER FAST URETHANor equivalent
3M ATD Part No. 6382 or equivalent
r--- ~~Side garnish3M ATD Part No. 6382 or equivalent
TSB Revision

EXTERIOR - SDecial Tools
SPECIAL TOOLSMBlKG- .
I-system inspectlon
MB991 359TSB Revision

EXTERIOR - Troubleshooting51-5
TROUBLESHOOTING
LWINDSHIELD WIPER AND WASHER
CIRCUIT DIAGRAMIGNITION :
i
ir
FRONT
KmYE7
-I--l--r-I-ii .
@
15A--
----
JUMPER
CONNECTOR
A-11X
Ea
d
53----
1
i4
CT
C-79
S&~DIAGNOSIS
CONNECTOR
EB'p%Jg@
g:f;:[pm1
:X35-AC-R1301-NY.:1
~;x2,--f-l--13L1------ ----- ---- ------ -7 q’,
I i
15:2 $x2
~-fi5
x3lTX2 pi2k%hw, :2~
3r,. I-EIv
s.LIjWl z
COLUMNn11 SWITCH C-113
MITTENTFROiiFRONTI IWIPER RELAYWIPER SWITCIII 1WASHER_SWITCHTI
34
TMSlKHBM
fITCH(ACC)
6LOll"FAST
VARIABLEINTERMITTENTo
WIPER
CONTROL
SWITCH
1 TSB Revision

51-6EXTERIOR - Troubleshooting
FRONT
wm
c
c-29
[ml
FRONT
E%iRr‘(
A-19L
II:C
Iza
C
.---
FRON'IWIPER
SWITCH
*WIPERIGNITIONRELAY SWITCH(ACC)
7
$1
1
7I
I27’
jA -’
I--CII;BRE+lk
5-------
%l:VEHICLES WITHCUT THEFT-ALARM SYSTEUZ2:VEHICLES WITH THZFT-ALARM SYSTEM
1
I
------_
CUITFAKER
-.--I
5
5:CD
d
44 31
1
rEBRMOTOR
A-15TSB Revision