CHASSIS AND BODY MAINTENANCE
MAINTENANCE OPERATION MAINTENANCE INTERVAL
Periodic mamtenance should be performed Mdes x 1,000 15 30 45 60
at number of miles. kilometers or months IKnlometers x 1 0001 1241 1481 1721 196) Reference page
whichever comes first Months 12 24 36 48
Brake liner E hoses I I I I MA-26
Brake
pads E discs I 1 I I MA-27
Brake fluid
R R MA-26
Manual and
automatic transmission E differential gear 011 I I I I MA-18, 19. 20
Power rteerlng lines E hares I I I I MA-34
Steering gear & linkage, & suwenston parts I I I I MA-21,22,23.34
Steertng llnkage ball
~OlntL E front suspension ball JOllltS
Propeller shaft14 I I MA-20
Locks.
hinges E hood latch L L L L MA-35
Front wheel bearing grease
I I MA-22
Exhaust system
I I I I MA-17
Seat belts, buckles, retractors. anchors E adiusler I I I I MA-35
I MA-21,34
Abbreviations A =Adlust
R = Replace
I = Inspect Correct or replace if necessary
MAINTENANCE UNDER
SEVERE DRIVING CONDITIONS
The maintenance intervals shown on the
preceding pages are for normal operating
DW"g Mal"te"a"Ce Mal"te"a"Ce Malnte"a"Ce condition item OperaflO" interval
C Aw cleaner filter R More frequently
R Every 3.000 miles Engine 001 IExceDt turbo- ABC E charged engine) 15.000 km) or 3 months conditions If the vehicle is operated under
severe driving conditions as shown below, Engine 081 ITurboCharged R Every 2,500 miles
more frequent maintenance must be per-
formed on the following items as shown in A E
engd
Engine 081 filter R At the first 001 change
(4,000 kml or 3 months
and then every second 011 the table rhmae
Severe driving conditions
A - Repeated short distance driving
6 - Extensive idling
C - Driving in dusty conditions
D - Driving in extremely low or hlgh
ambient temperatures
E - Towing a trailer
F - Driving in areas using road salt or
G - Driving on rough andlor muddy
H - Driving in high humidity areas or in
other corrosive materials
roads
mountainous areas
A C EFG Brake pads & dorm I Every 7,500 miles 112,oW kml or 6 months
124.000 kml or 12 months
I48 Ow kml 01 24 monlhi
H Brakefluid R Every 15.000 miles
EG Manual and automatic trans- R Every 30.000 miles mmmn & drtferentml (lea, 011)
G Steering gear & linkage. I Every 7.500 miles 112 000 kml or 6 months
Every 7,500 miles
112.000 kml or 6 months
& rurpenrlon parm
(I front rurpenrlo" ball 1Ol"fS
CO FG Steering linkage ball pnts I
F Locks. hinges & hood latch I Every 7.930 miles
A EFG Exhaust system I Every 7,500miler
Maintenance operations I = lnr~ect Correct or replace 11 necerrary R = Replace
112.000 kml or 6 months
112.000 kml or 6 monthi
CHASSIS AND BODY MAINTENANCE
Checking Front Whe
2 Measure toe-in
Liner parallel to center line of body-
Toe-in = A - 8
SMA124 Front
Toe-in:
1 - 3 mm (0.04. 0.12 in)
6-16
3 Town can be adjusted by varying the length
of steering side rods
SMA727A
"A" standard dimension:
37.5 mm (1.476 in)
inner rocket
SST274A
Alignment (Cont'd)
FRONT WHEEL TURNING ANGLE
a Rotate steering wheel all the way right and
left, measure turning angle on inner wheel
SMA127
Turning angle.
Full turns
Inside
Outside
35" - 39"
27"
~ 31"
Toe-out turn (Insideloutside):
22"30/20"
If it is not within speclfication, check rack
stroke.
Refer to section
ST
Rack stroke
r Rack
Tie-rod inner i. socket Tie-rod inner socket
,Rack -1
Unit mm (in) (Cvlander end housing ndel SST223A
MA-24
.
