Downloaded from www.Manualslib.com manuals search engine 4 OPERATION No MA. 100-00 : ChargctrJristics and special jeattlws of the engine. II. PARTICULAR FEATURES.
1. Engine sugpension :
4 speed manual gearbox
2 bearers under the engine gearbox unit :
- 1 on the engine side
- 1 on the gearbox side (adjustable by means o/ slots)
2 torque bars at the upper section :
- torque bar on the gearbox side :
- yellow paint mark at (( a ))
- torque bar on the engine side :
- blue paint mark at (( a ))
NOTE : When fitting, position the paint mark uppermost.
5 speed manual gearbox, and torque converter gearbox
bearer under the engine-gearbox unit on the engine
side
(adirrstable OH the subjranra by means oj slots)
vertical flexible mounting on the gearbox side
torque bar at the upper se‘ction
(green paint mark at CC a n to be positioned uppermost
072 jittiug )
NOTE : The 5-speed manual gearbox has a different
vertical flexible mounting from the torque converter
gearbox
a
- Mat7~ral gearbox : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36 mm - Manual S-speed gc,arbox and torque cowrvrtcr gearbox : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 42 mm 2. Crankcase :
a) Cylinder block in oast iron with removeable barrels.
+ 0.05 - Tappet housing bore : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..~.................................................
24 + 0.025 mm
Downloaded from www.Manualslib.com manuals search engine d) Valve springs :
The inlet and exhaust valve springs are identical.
Characteristics :
- Diameter of wire : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4.6 + 0.02 mm
Interior diameter : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 25 2 0.2 mm
- Length of spring under load : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
1 39mm(load=m40t2,8kg)
30.6 mm ( load = 84 ~‘1.8 kg )
Coating : ._._................................................................................................ Red or blue varnish
e) Upper spring cups : Identical inlet and exhaust.
f ) Retaining clips : Identical inlet and exhaust
6. Timing :
a) Camshaft :
Chain-driven camshaft, resolving in three cupro -lead bearings.
- Camshaft end-float (a,//>~ I /hi<-krlc~ss a,/ !/o,/s(, I: 0.05 to 0.30 mm
- Thickness of flange : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5.44 to 5.46 mm
- Amount of cam lift :
Inlet : . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ..__.._..._ _.;._.; .._...._ ..__.___.., 6.63
2’0.02 mm
Exhaust : ___._._..._.........................................................................................,... 6.14 + ‘0.02 mm
WARNING :
Never attempt to rotate the engine by means of the camshaft pulley fixing nut.
TIMING DIAGRAM
(With theoretical inlet and exhaust clearance of 1 .lO mm )
Downloaded from www.Manualslib.com manuals search engine III. CHECKING THE CAMBER ANGLE
NOTE : The camber angle is not adjustable.
1. Prepare vehicle and set in position f src chapfrrs
I and 2 ).
2. Setting up checking apparatus :
Place the apparatus on the magnetic support of the
wheel to be checked.
Use the axis corresponding to the blue mmu A..
Keep the level in a horizontal position. Tighten
locking screw ( 1).
3. Checking the comber angle :
IMPORTANT : Check that the reading Ll has not
changed ( SC<’ rhnprcr I ).
a) Turn the disc (2 ) until the fixed spirit-level
bubble (3 1 is centred.
b) Note in blur scnle (at o a n ) the reading of the
comber rmqle.
c ) Carry out the same operation on the other
wheel.
Comber angle must be between 0’ + 13’ - 29’
IV. CHECKING AND ADJUSTING THE,CASTOR ANGLE
IMPORTANT : For precise results from this check
it is imperative to set the vehicle heights as follows :
165 mm a+ front and 215 mm at rear f Salooss) or
228 mm ( Esfafes ).
1. Setting the vehicle height :
a) Check measurements Ll and L2 f see chapter I ).
b ) Release pressure in suspension system.
2. Setting control opportus :
3. Checking castor angle :
Place the apparatus on the magnetic bracket of
the wheel to be checked using the axis corres-
ponding to grren (ITTOII’ H.
a) Turn wheels 20’ outwards : to the left for the
left-hand wheel and to the right for the right-
hand wheel.
Keeping the apparatus horizontal tighten locking
screw ( 1).
b) Turn the disc ( 4) until the zaro mark is opposite
arrow (at I( b n 1.
c) Turn knurled knob ( 5) until spirit-level
bubble (6) is centred.
Downloaded from www.Manualslib.com manuals search engine TABLE OF FUSES
Current supply
findow operation
ontrol relay Fuses
Equipment protected
Capacity Colour
Right-hand switch -Right-hand window winder
16 A White
Left-hand switch - Left-hand window winder
Ieating relay 16 A Mauve Heating unit
Stoplamps
Accessory terminal
Glove box lamp
‘ositive battery
erminal (( + )). 16
A Red Direction indicators
E Instrument panel
Lighting -- Windscreen wiper
switch Horns
Heating relay ( coil )
Window winder relay ( coil )
‘ositive battery
erminal (( t 1) 16 A Green Interior lamp
Boot lamp
Cigar lighter
Clock
Hazard warning lamp
Lighting
switch
E
Voltage’ regulator
Reversing lamps
Rear window heater
Ash-tray lighting
10 A Yellow Lighting for cigar lighter
Heating control lighting
Dashboard lighting
,ighting switch Side- and tail lamp warning lamp
Left-hand sidelamps and rear lamps
10 A Blue Right-hand sidelamps and rear lamps
Number plate lamp Cl RCUI T DIAGRAM
r>
Downloaded from www.Manualslib.com manuals search engine TABLE OF FUSES
Supply to
eater unit relay Fuse
Circuits protected
Rating Colour
16 Amps Mauve Heater unit
S toplamps
Accessory terminal
Glove box lightinq
Positive terminal
of battery u + )) 16 Amps Red
E Direction indicators
Ignition Windscreen wipers and washers
switch Horns
Heater relay windinq
Window-winder relay winding
Rheostat -speedometer lighting
Warning lamp panel ( Battery
meter ( Thermal voltmeter-- Brake pad wear warning
lamp - Fuel gauge - Oil pressure warning lamp -
Hydraulic fluid pressure warning lamp-Water temp.
warning lamp )
16 Amps Green Interior lamp
Boot lamp
Cigar-lighter
Clock
Hazard warning lamps
E Voltage regulator
Iqnition Reversing lamps
switch
Rear window heating element
Handbrake warning lamp
Window winder relay 16 Amps White R.H. Switch 0 R.H. window winder
L.H. Switch- L.H. window winder
Lighting
Switch 10 Amps Yellow Ashtray lighting
Cigar lighting
Heater controls lighting
Instrument panel lighting Clock
E Battery meter
Odometers
Sidelamp warning
L.H. sidelamps, front and rear 1 amp
Lighting
Switch 10 Amps Blue R.H. sidelamps, front and rear
Number-plate lamp CIRCUIT DIAGRAM
>
P.T.O.
Downloaded from www.Manualslib.com manuals search engine 2 OPERATION No MA. 510-00 b : Arratzgement of the electrical installation
( jhrl 9/1975 ) TABLE OF FUSES
Supply to
lelay for heater unit
‘ositive battery
erminal (( + 1) Fuse
Circuit protected
Rating Colour
16 Amps Mauve Heater unit
Stoplamps
Accessory terminal
Glove-box lighting
E Direction indicators
Windscreen washers and wipers
Ignition Horns
switch Winding for heater unit relay
Winding for window-winder relay
16 Amps Red Rheostat
- speed0 lighting
Instrument panel : ( Battery meter
( thermal voltmeter ) - Brake pad
wear warning lamp.-Fuel gauge- Oil pressure and temp.
warning lamps - Hydraulic fluid pressure warning lamp-
Coolant temp. warning lamp )
Interior lamp
Boot lamp
Cigar lighter
Clock
16 Amps Green Hazard warning
E Voltage regulator
Ignition Reversing lamps
switch Heated rear window element
Handbrake warning lamp
Relay for window
winder 16 Amps White R.H. switch u,R.H. window-winder
L.H. switch - L.H. window-winder
Lighting switch Ashtray lighting
Lighting for cigar-lighter
Lighting for heat’er control
Clock
10 Amps Yellow
Lighting for Battery meter and
instrument panel
E. Odometers
Sidelamp warning lamp
L.H. sidelamps front and rear
10 Amps Blue R,H. sidelamps front and rear
Number plate lamp Cl RCU I T DI AG RAM
Downloaded from www.Manualslib.com manuals search engine 10 OPERATION No MA. 510-00 b : A ,tnrt
( O.fjtft 91 107 5 ) TABLE OF FUSES
Supply to
I
Fuse
Circuits protected
Rating Colour
Heater unit relay 16 A Mauve Heater unit
Positive terminal of
battery (( + u 16
A Red Stoplamps
Accessory terminal
Glove-box lighting
E Direction indicators
Windscreen wipers and washers
Horns
Ignition
SW itch
Warning lamp panel ( Battery
meter ( thermal voltmeter ) -Brake pad wear warning
lamp -Fuel gauge- Oil pressure warning lamp - Hydraul.
fluid pressure warn. lamp-Water temp. warning lamp )
Tachometer, (( STOP)) warning lamp
16 A Green Interior lamp
Boot lamp
Cigar lighter
Clock
Hazard warning lamps
Voltage regulator
Reversing lamps
Ignition Heated rear window
switch
E Handbrake warning lamp
Rear screen washers and wiper
Window-winder relay
Lighting switch 16 A
10 A White
Yellow R.H. switch - R.H. window-winder
L.H. switch - R H. window-winder
Ashtray lighting
Cigar-lighter lighting
Heater controls lighting
Instrument panel lighting : Clock
Battery meter
Odometers
Sidelamp warning lamp
L.H. sidelamps, front and rear
10 A Blue R.H. sidelamps. front and rear
Number plate lamp Cl RCU IT DIAGRAM
Downloaded from www.Manualslib.com manuals search engine INSTRUMENT PANEL ( 01 1(J’5 --)
L 51 -L2 a
FRONT HARNESS IN STRUMENT PANEL HARNESS INSTRUMENT PANEL
Dipped heom
SIdelamps
BLUE
1 5
Worllli,q, lamp for
eilqlllc OII pressure F.MI N ‘f .Mj
Warlllnq lornp for 2 6
front broke pod weor
L worrnr~q lamp for
low fuel
worrung lamp for
Gr
2 F.Ve sIdelamps
?
7
Tachomctzr Woilllnq Iallp for
BI Mr hydr fiwd pressure I
I
I
Windscreen wiper
1 st speed WHITE
warning lamp for
Windscreen wiper
2nd speed f;ont foglomp switch
Windscreen wtper
self park;ng
position
Windscreen washers Rear foglomp switch
BLACK
R.H d,rect,on
tndicotors
relay far con,pr
horn
’ Swedish market ”
Dlrrct << ’ /, supply
through green f.,se
to clock and hazard
warn,ng headlamp wipe;5 A A
NO COLOUR
E art!,
H.R.W wor,,,ng lamp
Trailer djrectlon rndlr
worroi~g iomp
D lpped beam worn~nq
lamp
Fuel gauqe
Speedo ond tocho
Accessory Ilqhtlnq
Pre-heat wornrnq lamp
Front &zzke pod wcqr
woimng lamp
Low fuel woninq lamp
Enqinc 011 tcmp
worhnq lamp
Coolant tcmp~ worn,ng
lamp
II * ,>
supply through fuse
and contact
Tachometer
FM, 4
F.Gt 5
Hcndbroke warn,ng lamp GI 6
Rear foglamp warrllllq lamp k t.Mt 7