1974 CHEVROLET CAMARO fuel

Downloaded from www.Manualslib.com manuals search engine Important Facts You Should
Know About Gasoline
Mileage and How to
Improve It
How you drive, where you drive,
and when you drive
all have an
effect on how many miles you can
get from a gallon of gasoline. The
careful attention you give your car
as far as maintenance and repairs
are concerned will also contribute
importantly to fuel economy.
Fuel Selection
Your vehicle is designed to op­
erate on unleaded or low-lead fuels
>of at least 91 Research Octane.
These fuels minimize spark plug
fouling and emission system
de­
terioration. Your engine does not
require premium fuel. Therefore,
its use would be an unnecessary
additional expense.
If the service
station gas pump has a symbol similar
to the following, use
un­
leaded or low-lead gasoline with a
symbol of 2. A higher number
is
satisfactory but not required.
"Jackrabbit" Starts
Gasoline can be conserved (and
engine and tire life prolonged) by
avoiding unnecessarily rapid
ac­
celeration away from lights and
stop signs.
Stop-And-Start Driving
Frequent stops and starts during
a. trip really cut down on your
64
miles per gallon. Plan even your
short shopping trips to take
advan­
tage of through streets to avoid
traffic lights.
Pace your driving like
the professional drivers to avoid
unnecessary stops.
Speed Versus Mileage
Excessive speed on the highway
raises your gas consumption
dras­
tically. Statistics prove that you
might save
as much as 19% on
your fuel bill by driving
50 MPH
instead of 70 MPH.
Excessive Idling
An idling engine uses gasoline,
too, (especially after a cold engine
start).
If you're faced with more
than a
few minutes wait you're
better
off to "turn off" and start
again later.
Sudden Stops
Sudden stops themselves don't

Downloaded from www.Manualslib.com manuals search engine waste gasoline, but energy is wasted
as heat in braking. Energy in the
form of gasoline
is also needed to
accelerate back to driving speed.
Lubricants
A properly lubricated vehicle
means less friction between moving
parts. Consult this manual and the
maintenance schedule for the
proper lubricants to use and the
lubrication intervals.
Automatic Choke
Your automatic choke should be
checked periodically
as it regulates
the gasoline/air mixture used in
starting and warming the engine.
Properly Tuned Engine
Overall tuning (a check on tim­
ing, distributor points, spark plugs,
emission control· devices , etc.) can
improve your car's gas mileage.
You just can't expect an
"out-of­
tune"
engine to give you good gas
mileage and cleaner air.
Excess Weight
Fuel economy is related to the
work the engine
must do. The
heavier the load, the more power
it takes. Keep excess weight to a
minimum by removing . any per­
sonal effects or luggage from the
65
car or trunk when they are not
needed.
Tire Inflation
Under inflation not only causes
needless wear of the tires, but can
also waste gasoline. It's a good
idea to check tire pressures regu­
larly.
Wheel Alignment
"Toe in" or "toe out" has the
effect of dragging your front tires
sideways and causes premature tire
wear.
It takes power to carry this
extra load and that takes gas from
your tank.

Downloaded from www.Manualslib.com manuals search engine MINOR TROUBLE SHOOTING GUIDE
FUEL SYSTEM AND ENGINE ELECTRICAL SYSTEM COOLING SYSTEM
IMPORTANT: For maximum performance and economy, keep your GM car I I I I all GM. Specify General Motors parts identified by one of these trademarks. liM Q ~
66

Downloaded from www.Manualslib.com manuals search engine The chart on the previous page, and the information on the pages which follow, contains information designed to aid the average driver to discover, and possibly correct, conditions resulting in minor
mechanical difficulties in his car. The chart, designed to point out
possible solutions to several of the most common automotive mal­functions and point out a logical checking sequence, will lead step by step to the most likely causes and corrective procedures. If, after making the checks and adjustments suggested, the source of the trouble has not been found and corrected, it is strongly recom­
mended that an Authorized Chevrolet Dealer insp~ct the vehicle and make whatever repairs or adjustments are necessary.
;iA~>~I/~,~.#Y'T~~hiri~~:e~It.;ne;CC2i'~6p'4~cl~.;.'Ii~;~;,;(i '~i.. . .....•.. l'for",;tlgC;(lnY;tlspec';o~;1J1 ainfenCJn.c:~ .. FUEL SYSTEM AND ENGINE
If the ignition switch will cause the engine to "turn over" or "crank" but the car will not start, check Steps A through 0 below. NOTE : If continual "flooding" of the carburetor is evidenced by a carburetor wet with
fuel or black exhaust smoke,
perform the operation sug­
gested in paragraph D only .
(A) The first and most obvious, and one of the most frequently Checking Fuel Flow
67
overlooked, items to check when you have difficulty in starting your car is the 'amount of fuel in the tank. Make it a habit to check the FUEL GAUGE regularly and most especially at a time when the engine will "turn over" but will not start.
(B) If the fuel tank is not empty, you may check further to see whether the fuel is reaching the carburetor. Disconnect the fuel line at the carburetor and remove the center wire (ground the secondary coil terminal or disconnect the primary wire from the coil to the
distributor at the coil) from the coil tower. Place a jar or cup under the open line and briefly "crank" the engine by means of the starter. If fuel spurts from the fitting, you may assume that the FUEL LINES are clear and the FUEL PUMP is operating properly. If no fuel leaves the line, either the fuel
lines or fuel pump are at fault ,
See your Authorized Chevrolet
Dealer.
(C) Before reconnecting the fuel
line
to the carburetor, remove the
FUEL FILTER from the carbu retor
inlet and check its condition . If it
appears to be clean, replace it
and reconnect the fuel line. Re­
place the filter if it appears to be plugged.
(0) If the' fuel seems to be
reaching the carburetor properly, Fuel Filter
the problem may be: an EMPTY CARBURETOR BOWL caused by a "stuck shut" carburetor; a FLOODED CARBURETOR caused by a "stuck open" condition and evidenced by gasoline seeping around and down the outside of the carburetor; or a stuck CHOKE valve. Remove the air cleaner from the carburetor. Check that the choke
•

Downloaded from www.Manualslib.com manuals search engine valve moves freely and is not stuck . (Don 't mistake normal spring
tension for a stuck valve.) Top the side of the carburetor sharply several times with a light tool such as a screwdriver handle or pliers. Replace the air cleaner and attempt to start the engine in the normal manner. IE) If the cor will start but stalls when hot or has a rough idle,
you can suspect a faulty IDLE ADJUSTMENT, a malfunctioning AUTOMATIC CHOKE or on extremely dirty and blocked AIR CLEANER ELEMENT. Replace paper element air cleaner if neces­sary. Idle' adjustment or automatic choke service (other than that outlined in paragraph 0 above) should be performed by your Chevrolet Dealer. If the above Fuel System checks and the checks suggested under the Electrical System following do not correct the malfunction, it is recommended that you return to your Authorized Chevrolet Dealer for further checks, adjustments or repairs.
ELECTRICAL SYSTEM • If, when the ignition key is turned to "Start", the engine will not
turn over, you have good reason to suspect electrical trouble. NOTE: Never remove Delcotron bat lead without first disconnecting
baHery ground cable.
, (F) When there is no response at all to attempts to start the car, check the obvious-your AUTOMATIC TRANSMISSION SELECTOR LEVER must be in Neutral or Park position (manucil transmission
must have clutch depressed all the way to floor) before the engine can be started. Turning the IGNITION SWITCH rapidly back and forth several times will sometimes correct a poor internal switch contact. (G) The BATTERY may be discharged. If so, lights will be dim and the horn will have a poor tone if it will blow at all. Usually a garage recharge will be necessary to return the bottery to operation. Occasionally, however, a long drive will recharge the battery.
68
NOTE: If the battery is determined to be dead, and for no apparent reason, have your Authorized Chevrolet Dealer check the
baHery, the GENERATOR and the VOLTAGE REGULATOR.
GENERATOR trouble should already have been indicated by the generator indicator light on the instrument panel.
POOR BATTERY CONNECTIONS may be suspected if the car has operated properly a short time before and now not even the horn will operate. Check both ends of both battery cables. If the con­nections are corroded, a cor may sometimes be restored to opera­tion by removing all cable ends, scraping all contacting surfaces clean with a pen knife, and reassembling. If the cables are broken, they must be replaced. The power supply should now be restored unless the battery is dead.
(H) If, however, the lights and horn work properly but the starter will still not turn over, check the STARTER connections. A "dick" from the starter solenoid indicates that the wiring to the starter is properly installed. If the wiring seems to be clean and tightly in­stalled, the trouble is probably in the starter itself and should be referred to your Authorized Chevrolet Dealer.
When the engine will "turn over" but will not start, the following
items may be checked along with the Fuel Systems Checks listed
previously.
(I) With a clean dry cloth, wipe the ceramic portions of the spark plugs dry. In particularly damp or rainy weather dampness may be the cause of not starting, espe­cially when the engine is cold.
(J) Check the cables at the top of the distributor and coil as well Distributor and Coil Cables

Downloaded from www.Manualslib.com manuals search engine Dealer Assistance ..................... 74 Defogger, Rear Window ............... 31 Defroster, Defogger, Windshield ........ 30 Dimensions, Vehicle ................... 70 Dimmer Switch, Headlamp. . . . . . . . . . .. 22 Directional Signals.. . . . . . . . . . . . . . . . . .. 18 Door Locks. . . . . . . . . . . . . . . . . . . . . . . . .. 4
Drive Belts, Engine. . . . . . . . . . . . . . . . . .. 49 Driver Seat Adjustment. . . . . . . . . . . . . . . . . . . . 5 "Drive". (D) Transmission Range. . . .. 17 Dusty Conditions, Operating Under Oil Change Interval. ................ 47 Oil Filter Change IntervaL ........... 47 Electric Clock. . .. .. . . . . .. .. . .. . .. . . .. 28 Electrical System Ammeter .......................... 27 Battery .......................... 63, 70 Bulbs ............................. 73 Fuses ............................. 73 Generator Indicator Light. . . . . . . . . .. 25 Emergency, In case Of. ............... 36 Brake Warning Light ................ 25 Generator Indicator Not Charging. . .. 25 Hazard Warning Flasher ............. 36 Jacking To Change Wheels ........... 39 Jump Starting with Auxiliary Battery .. 37 Overheated Radiator. . . . . . . . . . . . . . .. 39 (Temperature Indicator: Hot)
Pushing To Start. . . . . . . . . . . . . . . . . .. 36 ' Energizer (See Battery)
Engine Cooling
........................... 53 Exhaust Gas Caution ........ , . . . . . .. 13 Flooded, Starting Procedure .......... 14 Overheating. . . . . . . . . . . . . . . . . . . . . . .. 39 Serial Number ...................... 70
Specifications ................. , . . . .. 70 Starting ........................... 14 Temperature Light. . . . . . . . . . . . . . . . .. 25 Engine Oil Capacity ..... , . . . . . . . . . . . . . . . . . . . .. 70 Change Interval. ................... 47 Dip Stick. . . . . . . . . . . . . . . . . . . . . . . . .. 48 Filter .............................. 47 Pressure Indicator. . . . . . . . . . . . . . . . .. 24 Recommendation ............... ' ... 47 Ethylene Glycol Coolant. . . . . . . . . . . . . .. 54 Exhaust Gas Caution ............ ' ..... ' 13 Driving With Trunk Open. . . . . . . . . .. 13 Parked With Engine Running. . . . . . .. 13 Pulling A Trailer. . . . . . . . . . . . . . . . . .. 11 Exterior Finish and Trim care. . . . . . . .. 44
Fabric Care .......................... 41 Fan Belt. .............................. 49 Ventilating ......................... 28 Filters OiL ............................... 47 Finish Care, Exterior. . . . . . . . . . . . . . . .. 44 First Few Hundred Miles of Driving............................ 2 First Gear. . . . . . . . . . . . . . . . . . . . . . . . . .. 17 Flame Arrestor ......... , . . . . . . . . . . . .. 49 Flammable Cleaning Solvents .......... 41 Flashers
Hazard Warning .................... 36 Turn Signal. . . . . . . . . . . . . . . . . . . . . . .. 18 Flooded Engine, Starting. . . . . . . . . . . . .. 15 Floor Controls ....................... 21 Fluid Levels
Battery ............................ 63 Brake Master Cylinder. . . . . . . . . . . . .. 52 Engine Oil. ........................ 49 Power Steering ..................... 52
79
Radiator ........................... 55 Rear Axle. . . . . . . . . . . . . . . . . . . . . . . .. 49 Transmission ....................... 50 Fluid Recommendations
Battery ......................... , .. 63 Brake ............................. 52 Power Steering. . . . . . . . . . . . . . . . . . . .. 52 Radiator. . . . . . . . . . . . . . . . . . . . . . . . . .. 56
Transmission ....................... 50 Windshield Washer. . . . . . . . . . . . . . . .. 28 Fogging, With Air Conditioner. . . . . . . .. 33 Folding Seat Back Latches. . . . . . . . . . . .. 4 Foreign Countries, Operation In ........ 12 Four Way Hazard Flasher ............. 36 Front Suspension ..................... 51 Front Wheel Bearings. . . . . . . . . . . . . . . .. 52 Fuel (See Gasoline)
Full Rated Load (See Tires)
Fumes Engine Exhaust. . . . . . . . . . . . . . . . . . .
.. 13 Gasoline. . . . . . . . . . . . . . . . . . . . . . . . . .. 13 Fuses Chart. ............................ 73 Location ........................... 72 Gas Station Information
Inside Back Cover
Gasoline
(See Also Fuel) Do Not Use For Cleaning ........... 41 Filler Cap Location ................ IBC
Fumes ............................. 13 Gauge ............................. 24 Low-Lead .......................... 46 Recommendations. . . . . . . . . . . . . . . . .. 46 Gauge, FueL... . . . . . . . . . . . . . . . . . . . . .. 24 Gearshift Lever.. . . . . . . . . . . . . . . . . . . . .. 17 Generator Indicator Light ' ("AMP") .......................... 25 Glove Box. . . . . . . . . . . . . . . . . . . . . . . . . .. 23

Downloaded from www.Manualslib.com manuals search engine Harness, Safety (See Seat Belts) Hazard VVarning Flasher ............... 36 Headlamp
High Beam Dimmer Switch .......... 22
High Beam Indicator ................ 26
Light and Instrument Panel
Switch ........................... 26
Heater Operation ..................... 30 High Speed Operation
During Break-In.. . . . . . . . . . . . . . . . . . . 2 Tires .............................. 56 Hitches, Trailer... . . . . . . . . . . . . . . . . . . .. 11 Hood Latch Maintenance.. . . . . . . . . . . . . . . .. 53 Release ........................... IBC Horn ................................ 20 "HOT" Light (See Engine
Temperature Light)
How To Improve Your Gas Mileage. . . ... . . . . . . . . . . . . . . . . .. 64 Hub Caps, Replacing.. . . . . . . . . . . . . . . .. 39 Hydroplaning. . . . . . . . . . . . . . . . . . . . . . .. 61 Identification Numbers
Body .............................. 70 Engine ............................ 70 Vehicle ............................ 70 Ignition Keys ............................. 3,14 Lock .............................. 14 In Case Of Emergency ............ , . . .. 36 Indicator Lights
Brake ............................. 25 Electrical Charging (Generator) ....... 25 Engine Temperature. . . . . . . . . . . . . . . .. 25 Oil Pressure .......•................ 24
Infant Restraining Methods. . . . . . . . . . .. 9
Infant Safety Carrier. . . . . . . . . . . . . . . . .. 9
Inflation Pressure, Tires..... . . . . . . . . . .. 57 Inlets,
Ventilation
System .............. 29
Inside Rearview Mirror.. . . . . . . . . . . . . . . 5 Instrument Panel. . . . . . . . . . . . . . . . . . . .. 23 Interior Appearance Care .............. 41 Jack Operation .......................... 39 Storage ............................ 39 Jump Starting VVith Booster Battery ..... 37 Key Buzzer System .................... 14 Keys................................ 3 Knocking Engine (See Fuel)
Recommendations)
Lacquer,
J\crylic Care ................. 44 Lane Changer and Turn Signal. . . . . . . .. 18 Lap and Shoulder Belts...... .. .. .... .. 7 Latches Door.............................. 4 Folding Seat Back. . . . . . . . . . .. . . . . .. 4 Hood ............................. IBC
Lighter, Cigarette ....•................ 28
Lights ............................. 23,73 Backup ............................. 73 Brake VVarning ..................... 25 Bright Beam Indicator ............... 26
Bright Beam Switch ................. 22
Bulb Chart. ........................ 73 Courtesy ........................... 73 Engine Temperature Indicator. . . . . . .. 25 Generator Indicator ................. 25 Hazard Flasher.. . . . . . . . . . . . .. . . . . .. 36 Headlamp Circuit Breaker. . . . . . . . . .. 73 Headlamps. . . . . . . . . . . . . . . . . . . . . . . .. 73 Oil Pressure Indicator. . . . . . . . . . . . . .. 24
Sidemarker. . . . . . . . . . . . . . . . . . . . . . .. 73 Switch ............................. 26
Tail and Brake. . . . . .. . . . . . . . . . . . ... 73 Turn Signal Indicator ............... 18 Turn Signals. . . . . . . . . . . . . . . . . . . . . .. 18
80
Lining; Brake. . . . . . . . . . . . . . . . . . . . . . .. 22
Liquid Tire Chain. . . . . . . . . . . . . . . . . . .. 61 Load, Full Rated (See Tires)
Locks
Door.............................. 4 Glove Box. . . . . . . . . . . . . . . . . . . . . . . .. 23
Ignition ........................... 14 Steering Column .................... 14 "Low" (L) Transmission Range. . . . . . .. 17 Lubrication Oils ............................... 47
Recommendations. . . . . . . . . . . . . . . . .. 48
Luggage Compartment, Driving
VVhile Open ........................ 13 Luggage Or Cargo Caution. . . . . . . . . . .. 13
Maintenance
Appearance
Care. . . . . . . . . . . . . . . . . .. 41 Schedule. . . . . . . . . . . . . . . . . . . . . . . . .. 46 Manual Transmission. . . . . . . . . . . . . . . .. 18
Master Cylinder, Brake ................ 52
Metal Cleaners. . . . . . . . . . . . . . . . . . . . . .. 44
Methods Of Restraining Children. .... .. 9
Mirrors, Rear View
Inside, Adjustment Up or Down.... .. 5 Inside, Day/Night.... . . . ... . . . . . . . .. 5 Mountainous Terrain
Driving Down Grades ............... 18
Transmission Fluid Change Interval. " 50 "Neutral" (N) Transmission Range ..... 17 New Car Break-In.................... 2 Oil Additives. . . . . . . . . . . . . . . . . . . . . . . . .. 49
Change Interval, Engine ............. 47
Checking Engine Oil Level. . . . . . . . . .. 49
Engine ............................ 47
Filter .............................. 47 Pressure Indicator Light/Gauge. . . . . .. 27

Downloaded from www.Manualslib.com manuals search engine Recommendations. . . . . . . . . . . . . . . . .. 47 Transmissions. . . . . . . . . . . . . . . . . . . . .. 50 Viscosity. . . . . . . . . . . . . . . . . . . . . . . . . .. 48 Operation in Foreign Countries ......... 12 Other Controls and Features. . . . . . . . . .. 35 Outside Air Vents .................. " ...... 29 Overheated Engine
Indicator Light. . . . . . . . . . . . . . . . . . . .. 25 What To Do ....................... 25 Overseas Operation '. . . . . . . . . . . . . . . . . . . 12 Owner Assistance ..................... 74 Paint
Care ........................... ... 44
Touch Up ......................... 44
Parking Brake
............................. 21 Brake Check ....................... 21 Lights ............................. 73 "Park" (P) Transmission Position. . . .. 17 Precautions ........................ 14 Polishing And Waxing ............... " 44
Positive Traction Differential. . . . . . . . . .. 35 Power
Brakes ............................ 22 Steering. . . . . . . . . . . . . . . . . . . . . . . . . .. 19 Windows, .. , ,. " '.', ........ ... , 35 Pressure, Tire Inflation. . . . . . . . . . . . . . .. 56 Pushing To Start ................... " 36 Radiator
Coolant ........................... 54 Coolant Level Inspection. . . . . . . . . . .. 54
. Overheating ...................... " 39 Pressure Cap. . . . . . . . . . . . . . . . . . . . . .. 56
Radio
AM/FM ........................... 34 Antenna ........................... 34 Stereo System. . . . . . . . . . . . . . . . . . . . .. 34
Raising Car With Jack. . . • . . . . . . . . . . .. 39 Rear
Axle .............................. 49 Speaker .................... ... .... 34 Window Defogger .. " .............. 31 Registration, Vehicle
Engine Number. . . . . . . . . . . . . . . . . . .. 70 Vehicle Identification Number. ....... 70 Release, Hood ............ '" ... ..... IBC
Replacement Tires ................ , . .. 60 Replacement Wheels. . . . . . . . . . . . . . . . .. 60 Restarting . . . . . . . . . . . . . . . . . . . . . . . . . .. 15
Restraints
Child........ ................... ... 9
Lap Belts.. .... . . .... . ... . . .. . . .. .. 7
Methods Of Restraining Children. . . .. 9 Shoulder Belts. . . . . . . . . . . . . . . . . . . . . . 7
Retractors, Lap Belt. . . . . . . . . . . . . . . . .. 7 "Reverse" (R) Transmission Range. . . .. 17 Roof Care, Vinyl. . . . . . . . . . . . . . . . . . . .. 45 Rotation, Tire ........................ 58 Safety Belts (Seat Belts). . . . . . . . . . . . . . . . . . . . 7
Carrier, Infant.... . . . . . . . . . . . . . . . . .. 9 Seat, Child. .. . . . . . . . . . . . . . . . . . . . . .. 9
Schedule
Break-In... .. .... .. . ... . . . . .. .... .. 2
Maintenance. . . . . . . . . . . . . . . . . . . . . .. 46 Seat .
Adjustment, Manual. . . . . . . . . . . . . . . . 5
Back Latch, Folding
Front. . . . . . . . . .. 4
Child Safety. . . . . . . . . . . . . . . . . . . . . . .. 9
Seat Belts
Buzzer Light Reminder. . . . . . . . .
. . . .. 9
Child Restraint. . . . . . . . . . . . . . . . . . . .. 9 . Inspection and Care. . . . . . . . . . . . . . . .. 9
Lap ............................... 7
Retractors. . . . . . . . . . . . . . . . . . . . . . . .. 7
81
Shoulder.... ..... . . .. . . .. .. .... .. .. 7
Self-Adjusting Brakes .......... ..... ,. 22 Service and Maintenance. . . . . . . . . . . . .. 46 Shift Linkage Maintenance ............... 51 Operation (See Transmission). . . . . . .. 16 Shoulder Belts Adjustment. . . . . . . . . . . . . 7 Side Marker Lights. . . . . . . . . . . . . . . . . .. 73 Signals, Turn ......................... 18 Solvents, Recommended Cleaning ....... 41 Sound Systems (See Radio) Space Saver Tire. . . . . . . . . . . . . . . . . . . . .. 61 Spare Tire
Jacking Instructions. . . . . . . . . . . . . . . .. 39 Spark Knock (See Fuel
Recommendations)
Speaker, Rear. . . . . . . . . . . . . . . . . . . . . . .. 34 Specifications
Body .............................. 70 Capacities. . . . . . . . . . . . . . . . . . . . . . . .. 70 Dimensions ....................... , 70 Engine ............................ 70 Filters ............................. 47 Fuses ....... ...................... 73 General ........................... 70 Light Bulbs. . . . . . . . . . . . . . .. . . . . . . .. 73 Lubricants. . . . . . . . . . . . . . . . . . . . . . . .. 47
Speedometer. . . . . . . . . . . . . . . . . . . . . . . .. 23 Spot Cleaning ........................ 41 Stainless Steel Protection. . . . . . . . . . . . .. 45 Stains, Removal of. ................... 41 Starter Interlock ......................... , 14 Safety Switch.. .. . . . . . . . . . . . . . . . . . .. 15 Starting Automatic Transmission Cars. . . . . . .. 15 Emergency. . . . . . . . . . . . . . . . . . . . . . . .. 37 Manual Transmission Cars ........... 15