
Downloaded from www.Manualslib.com manuals search engine a bobby pin) between the rubber
cup at the end of the spark plug
wire and the tubular metal con
nector inside of it. If the spark
plug wire is wet or oily, wipe it
dry. Wrap a dry handkerchief or facial tissue, folded several thick.
nesses, around the wire at least three inches back from the end
and grasp the wire at this point.
Hold the bare wire about 1f4 inch
from the
bare tip of the spark
plug from which you removed the Checking Spark
wire. When the engine is "turned over" a spark should jump across
the V" inch space, indicating ample current supply. If no spark
jumps, the difficulty is probably caused by a defective ignition port
and should be corrected by your Authorized Chevrolet Dealer.
COOLING SYSTEM
When the cor will run but evidences serious overheating on the temperature gauge in the instrument panel, there are several items
which may be checked .
(L) Engine overheating will occur when the OIL lEVEL falls dangerously low. Check the oil level as a matter of course.
(M) Low COOLANT LEVEL will , of course, couse engine overheating. Determine . the cause of the low coolant level and have
it corrected if necessary.
(N) Check the RADIATOR CORE. Clean it if it is plugged with
bugs, leaves or other foreign material.
65
(0) Condition of the FAN BELT is very important, not only for engine cooling but also for proper generator operation. Check the
condition of the belt. Replace it if it is worn or frayed. Loosen the generator toward the engine to remove and replace the belt. Tighten the belt, whether new or old, by loosening the generator bolts, prying with a bar on the generator until the belt is tensioned properly, then retighten
the generator bolts.
(PI Another couse of engine ove rheating may be on inopera
tive COOLING SYSTEM THERMOSTAT. If the thermostat should foil in the closed position, it will not
perm it coolant to circulate through
the system . In such on emergency the thermostat may be removed
but should be replaced with a properly functioning thermostat as soon as possible.
Fan 8.11 Tension
Thermoslal Inslollo/ion

Downloaded from www.Manualslib.com manuals search engine Dealer Assistance. . . . . . . . . . . . . . . . . . . . . 70
Defogger, Rear Window ............ ... 30 Defroster, Defogger, Windshield .... .... 29 Delco Eye On Battery . . . . . . . . . . . . . . . .. 61 Dimensions, Vehicle ................... 66 Dimmer Switch , Headlamp ............ 21 Directional Signals.. . . . . .. . . . . . . . . .. .. 17 Door Locks. . . . . . . . . . . . . . . . . . . . . . . . . . 4 Drive Belts, Engine. . . . . . . . . . . . . . . . . .. 48
Driver Seat Adjustment. . . . . . . . . . . . . . . . . . . .
5 "Drive" (D) Transmission Range. . . . . 15 Dusty Conditions, Operating Under Oil Change Interval. . . . . . . . . . . . . . . .. 46 Oil Filter Change Interval. . . . . . . . . . . . 46
Electric Clock.. .. .. . .. .. . .. .. .. . . .. .. 27 Electrical System Ammeter ................ .......... 26 Battery ......................... ... 61 Bulbs ..................... ........ 69 Fuses ................... .......... 69 Generator Indicator Light. . . . . . . . . .. 24 Emergency, In Case Of ...... , . ........ 36 Brake Warning Light ................ 24 Generator Indicator Not Charging. . .. 22 Hazard Warning Flasher ............. 36 Jacking To Change Wheels ........... 39 Jump Starting with Auxiliary Battery.. 37 Overheated Radiator. . . . . . . . . . . . . . .. 39 (Temperature Indicator: Hot) Pushing To Start. . . . . . . . . . . . . . . . . .. 37 Energizer (See Battery)
Engine Cooling
........................... 53
Exhaust Gas Caution .......... ...... 12 Flooded, Starting Procedure .......... 14
Overheating. . . . . . . . . . . . . . . . . . . . . . .. 39
Serial Number.... . . . . . . . . . . . . .. . ... 66
Specifications ....................... 66 Starting. . . . . . . . . . . . . . . . . . . . . . . . . .. 13 Temperature Light .................. 24
Engine Oil
Capacity. . . . . . . . . . . . . . . . . . . . . . . . .
.. 66
Change Interval ................... , 46 Dip Stick .......................... 47 Filter ................. , ........... , 46
Pressure Indicator ................. , 23 Recommendation . . . . . . . . . . . . . . . . . .. 46
Ethylene Glycol Coolant. ............. , 53 Exhaust Gas Caution ...... ............ 12
Driving With Trunk Open ........... 12 Parked With Engine Running. . . . . . .. 12 Pulling A Trailer ............... .. . , 10 Exterior Finish and Trim Care. . . . . . . .. 43
Fabric Care . ........ ................ , 41 Fan Belt .......... ..................... 48
Ventilating ......................... 27 Filters OiL ............................... 46
Finish Care, Exterior. . . . . . . . . . . . . . . .. 43
First Few Hundred Miles of Driving ........................ .... 2
First Gear. . . . . . . . . . . . . . . . . . . . . . . . . .. 17 Flame Arrestor. . . . . . . . . . . . . . . . . . . . . .. 48
Flammable Cleaning Solvents .......... 41 Flashers Hazard Warning .................... 36 Turn Signal. . . . .. .. .. .. .. .. .. .. .... 17 Flooded Engine, Starting. . . . . . . . . . . . .. 14 Floor Controls. . . . . . . . . . . . . . . . . . . . . .. 20
Fluid Levels
Battery
............... ............. 61 Brake Master Cylinder ............. , 51 Engine Oil. . . .. .. .. . . . . . . .. . . .. . . .. 48
75
Power Steering. . . . . . . . . . . . . . . . . . . .. 51 Radiator .................. , ........ 55 Rear Axle. . . . . . . . . . . . . . . . . . . . . . . .. 48
Transmission ................ . .. . , .. 49
Fluid Recommendations
Battery
.......................... .. 61 Brake ................... .......... 51 Power Steering . . . . . . . . . . . . . . . . . . . .. 51 Radiator ............ , ........... , .. 55
Transmission .......... ............. 49
Windshield Washer ...... ........... 27 Fogging, With Air Conditioner. . . . . . . .. 32
Folding Seat Back Latches ........... " 4
Foreign Countries, Operation In ........ 11 Four Way Hazard Flasher. . . . . . . . . . . .. 36 Front Suspension . . . . . . . . . . . . . . . . . . . .. 50 Front Wheel Bearings ................. 51 Fuel (See Gasoline) Full Rated Load (See Tires)
Fumes Engine Exhaust . . . . . . . . . . . . . . . . . . .
.. 12
Gasoline ........ ... ................ 12
Fuses
Chart ............................. 69 Location ........................... 68 Gas Station Information
Inside Back Cover Gasoline (See Also Fuel) Do Not Use For Cleaning ........... 41 Filler Cap Location ................ IBC
Fumes ...................... ....... 12
Gauge .......... ......... .......... 23 Low-Lead .......... ................ 45
Recommendations. . . . . . . . . . . . . . . . .. 45
Gauge, Fuel. . . . . . . . . . . . . . . . . . . . . . . . .. 23 GearshiftLever .................... '" 17 Generator Indicator Light ("AMP") .................... ...... 24

Downloaded from www.Manualslib.com manuals search engine Glove Box. . . . . . . . . . . . . . . . . . . . . . . . . .. 22 Harness, Safety (See Seat Belts)
Hazard VVarning Flasher .............. , 36 Headlamp High Beam Dimmer Switch .......... 21 High Beam Indicator.. . . . . . . . . . . . . .. 25 Light and Instrument Panel Switch ........................... 25 Heater Operation ..................... 22 High Speed Operation
During Break-In. . . . . . . . . . . . . . . . . . . . 2 Tires .............................. 55 Hitches, Trailer. .. . . . . . . . . . . . . . . . . . . .. 10 Hood Latch Maintenance .................. 52 Release ....................... .... IBC
Horn .... " .......................... 19 "HOT" Light (See Engine
Temperature Light)
Hub Caps, Replacing .................. 39 Hydroplaning. . . . . . . . . . . . . . .. . . . . . . . . 59 Identificat ion Numbers
~~J~~: : : : : : : : : : : : : : : : : : : : : : : : : : :: ~~ Vehicle .......... .................. 66 Ignition
Keys ............................. 3,13 Lock ... ........................... 13 In Case Of Emergency ................ , 36 Indicator Lights
Brake ............................. 24 Electrical Charging (Generator) ...... , 24 Engine Temperature ............. .. .. 24 Oil Pressure ....................... , 23 Infant Restraining Methods. . . . . . . . . . .. 9 Infant Safety Carrier. . . . . . . . . . . . . . . . . . 9
Intlation Pressure, Tires ................ 56 Inlets, Ventilation System .............. 28
Inside Rearview Mirror .......... , . .. .. 5 Instrument Panel . . . . . . . . . . . . . . . . . . . .. 22 Interior Appearance Care .............. 41 Jack
Operation .......................... 40 Storage ...... ......... ......... .... 40 Jump Starting VVith Booster Battery. . . .. 3 7 Key Buzzer System. . . . . . . . . . . . . . . . . . .. 13 Keys ....... '.............. ..... ...... 3 Knocking Engine (See Fuel)
Recommendations)
Lacquer, Acrylic Care
................. 43 Lan e Changer and Turn Signal. . . . . . . .. 17 Lap and Shoulder Belts ............... . 5 , 7 Latches Door.................. ............ 4 Folding Seat Ba ck ...... . ; . . . . . . . . .. 4 Hood . ........................... . IBC
Lighter, Cigarette ................. .... 27 Lights ............................. 22, 69 Backup .. ...... .................... 69 Brake VVarning ... .................. 24 Bright Beam Indicator. .............. 25 Bright Beam Switch ................. 21 Bulb Chart ....... ............ ...... 69 Courtesy . . . . . . . . . . . . . . . . . . . . . . . . . .. 69 Engine Temperature Indicator ........ 24 Generator Indicator.. . . . . . . . . . . . . . .. 24 Hazard Flasher .............. ; . . . . .. 36 H eadlamp Circuit Breaker. . . . . . . . . . . 69 Headlamps .......... ............... 69 Oil Pressure Indicator. . . . . . . . . . . . . .. 23 Sidemarker ... .............. ...... , 69 Switch ............................ . 25
Tail and Brake . . . . . . . . . . . . . . . . . . . .. 69 Turn Signal Indicator. . . . . . . . . . . . . .. 17 Turn Signals . . . . . . . . . . . . . . . . . . . . . . . 17
76
Lining, Brake ........................ 21 Liquid Tire Chain ............ ...... " 60
Load , Full Rated (See Tires)
Locks
Door.............................. 4 Glove Box ....................... " 22 Ignition . . . . . . . . . . . . . . . . . . . . . . . . . .. 13 Steering Column. . . . . . . . . . . . . . . . . . .. 13 "Low" (L) Transmission Range ........ 16 Lubrication Oils ....................... ........ 46
Recommendations. . . . . . . . . . . . . . . . .. 40 Luggage Compartment , Driving VVhile Open ......... ............. " 12 Luggage Or Cargo Caution . . . . . . . . . . .. 12 Maintenance
Appearance Care ................. " 41 Schedule. . . . . . . . . . . . . . . . . . . . . . . . .. 45 Manual Transmission ............... " 17 Master Cylinder , Brake .... , . . . . . . . . . . . 51 Metal Cleaners ... .. .... ............ " 43 Methods Of Re straining Children ..... .. 9 Mirrors, Rear View Inside, Adjustment Up or Down .... " 5 Inside, Day/Night.... . . . . . . . . . . . . . . . 5 Mountainous Terrain
Driving Down Grades ...... ... .... " 17 Transmission Fluid Change IntervaL.. 49 "Neutral" (N) Transmi ssion Range ..... 16 New Car Break-In .................. " 2 Oil Additives ........................ " 48 Change Interval, Engine ........... " 46 Checking Engine Oil Level. ........ " 47 Engine .......................... .. 46
Filter .................... .......... 46
Pressure Indicator Light/Gauge ..... " 23

Downloaded from www.Manualslib.com manuals search engine Steering Column Controls. . . . . . . . . . . . . . . . . .. 13 Column Lock. . . . . . . . . . . . . . . . . . . . .. 13 Gear Lubricant. .................... 51 Linkage Inspection. . . . . . . . . . . . . . . . .. 48 Maintenance. . . . . . . . . . . . . . . . . . . . . .. 48 Power ....................... ...... 18 Wheel, Tilt ......................... 19 Straps, Safety (See Seat Belts) Storage Of Items..... . .. . . . . . . . . . . . . .. 5 Suspension Maintenance. . . . . . . . . . . . . .. 50 Tape System, Stereo. . . . . . . . . . . . . . . . . .. 34 Temperature ........... ............ " 29 Control , Cooling.. . .. . . . . . . . . . . . . . .. 29 Control, Heating. . . . . . . . . . . . . . . . . . .. 29 Indicator Light/Gauge. . . . . . . . . . . . . .. 26 Thermostat ....... ................... 55 Tilt Steering Wheel.. . . . . . . . . . . . . . . . . .. 19 Tire
Belted .. ........................... 55 Care ........................ ...... 55 Changing ........................ " 39 Full Rated Load ............ ....... . 57 High Speed Operation ............... 56 Hydroplaning. . . . . . . . . . . . . .. . . . . . .. 58 Inflation Pressure ............. ... , .. 56 Inspection ............ ... ........ " 57 Load Limit. . . . . . . . . . . . . . . . . . . . . . .. 56 Rotation ..... ............ .......... 58 Space Saver ........................ 60 Traction ............. .............. 59 Tread Wear Indicators .... ... ....... 57 Usage and Options... . . . . . . . . . . . . . .. 55 Towing
Caution ........... ................ . 36
Disabled Vehicle .................... 36 To Start. .... ........ .............. 36 Toxic
Cleaning Solvents ................... 41 Exhaust Fumes ..................... 12 Traction, Wet Roads. . . . . . . . . . . . . . . . . . 5
Traffic Hazard Flasher. . . . . . . . . . . . . . .. 36 Trailer Hauling.. . . . . . . . . . . . .. . . . . .. .. 10 Break-In Period .................... 11 Cautions . . . . . . . . . . . . . . . . . . . . . . . . . .. 11 Equipment.. . . . . . . . . . . . . . . . . . . . . . .. 10 Special Maintenance ............. .... 10 Tire Inflation ......... .............. 10 Trailer Tongue Load. . . . . . . . . . . . . . .. 10 Transmission 3-Speed Manual. . . . . . . . . . . . . . . . . . .. 17 Automatic .................. ....... 15 Braking Effect On Hills .............. 16 Checking Fluid Level. . . . . . . . . . . . . . .. 49 Fluid And Strainer.. . . . . . . . . . . . . . . .. 49 Fluid Change Interval. . . . . . . . . . . . . . . 49 Maintenance. . . . . . . . . . . . . . . . . . . . . .. 49 Shift Controls.. . . . . . . .. .. . . . . . . . ... 50 Shift Indicator
Turbo Hydramatic .................. 50 Tread Wear Indicators ................ 57 Trim Care, Interior .................. , 41 Trunk
Driving With Trunk Open ........... 12 Turbo-Hydramatic . . . . . . . . . . . . . . . . . . .. 50 Maintenance. . . . . . . . . . . . . . . . . . . . . .. 50 Operation. . . . . . . . . . . . . . . . . . . . . . . . . . 15 Turn Signals and Lane Change
Feature ................. ........... 17 Underbody Maintenance. . . . . . . . . . . . . . . 61
78
Upholstery And Carpet Care ........... 41 Vehicle Identification Number .......... 66 Vehicle Loading ................... '" 57 Ventilating Blower .................... 26 Ventilating Grilles .................... 26 Vents Outside Air ..................... 26 Vinyl Fabric Care Interior ........... .. .... 41 Roof Care. . . . . . . . . . . . . . . . . . . . . . . .. 43 Volatile Cleaning Solvents. . . . . . . . . . . .. 41 Caution ........................... 41 Volume Control, Radio ................ 33 Warning Flasher, Hazard .............. 36 Warning Lights. . . . . . . . . . . . . . . . . . . . . .. 23 Brake ............................. 24 Engine Temperature ....... .......... 24 Generator .......................... 24 Oil Pressure.. . . . . . . . . . . . . . . . . . . . . .. 23 Warranty (See Warranty Folder)
Washers
Windshield
...................... '" 27 Washing ............................. 43 Waxing And Polishing.. .. . . . .. . . . . .. .. 43 Wheel Bearings , Front .... . . . . . . . . . . . .. 51 Wheel Changing. . . . . . . . . . . . . . . . . . . . .. 39 Wheel Discs, Replacement. . . . . . . . . . . .. 39 Wheel, Tilt Steering ................... 19 Windshield
Defrosting and
Defogging . . . . . . . . . . . . . . . . . . . . .
.. 29 Washer Use In Cold Weather ........ 27 Washer Solution ............ .......• 27 Wipers And Washers.. . . . . . . . . . . . . .. 27 Wrecker, Towing. . . . . . . . . . . . . . . . . . . .. 36 Zone Offices ......... ............ .. 72, 73